2016 Ford Escape: engine failure

Filed Sep 9, 2026 · Engine · TX

Bought car in 2023, one year later engine failure due to overheating from head gasket issue widespread with this vehicle. Replaced engine, and two years later facing identical issue with another engine failure. Unidentifiable coolant leak led to low oil pressure and car shaking on the highway. Will require yet another engine replacement.

Filed Aug 19, 2026 · Engine · CA

First the transmission failed on the freeway and was almost squished between a semi and car. I pay thousands to get it fixed and now the engine light is on and the transmission fluid and the coolant are leaking into each other. I can't accelerate very well and they said it can't be fixed only a NEW engine. The mechanic at your dealership said it's a known problem and that there is no recall yet. I'm sorry for the working family this a cost that can not be endured! This is terrible. The car can not accelerate very well for passing vehicles or when entering onto the freeway. It is very much a safety issue and needs to be addressed.

Filed Jun 24, 2026 · Engine · VA

Coolant has leaked into the engine cylinder which apparently is a well known issue that Ford is refusing to rectify. Ford dealership confirmed this diagnosis and says I have to pay $12k for a new engine.

Filed Jun 13, 2026 · Engine · OH

My car overheated repeatedly and it was diagnosed by Liberty Ford Aurora Ohio to be caused by Coolant Intrusion. I was quoted a price of more than $11,000.00 to replace the engine

Filed May 16, 2026 · Engine · PA

I am one of the unlucky ones with the coolant leak into my engine that caused white smoke from my exhaust and caused my engine to stop working with under 100,000 miles. I have documentation and a new engine ready to be installed and have spent a lot of money out of pocket so far.

Filed Mar 11, 2026 · Engine · OH

I bought the 2016 Ford Escape and 2 weeks after the purchase the check engine light came on. I took it to Auto Zone and they said it was a spark plug. I had a full tune up done 2 days after the purchase so I called the garage and they replaced the spark plug. The light came back on a few hours later so I then took it to the Ford dealership and paid over $500.00 to have it fixed, along with the camera glitching. The day I picked up my car the check engine light came back on so I immediately took it back. They re-evaluated it and said that it is a manufacturing defect and that there is nothing they can do unless I want to replace the engine and that there was no guarantee that the new engine would not have the same issue. Apparently there are holes all throughout the engine and the antifreeze is mixing with the oil. I only drove it a total of 6 months before it completely died. Because I bought it from a buy here pay here lot he wouldn’t take it back even though I only had it 2weeks. My extended warranty would not cover the engine because it’s a manufacturing defect and I was stuck with a car note plus full coverage insurance on a car I could not drive. Ford never reimbursed me for the camera glitch that I paid for that is still not fixed and when I called Ford to see if there was anything that they could do to help me they said unfortunately they are in a lawsuit in California over the same issues I was having so no help is available at the time. The craziest part is the clerk at the Ford dealership told me to hurry up and trade it in at a different dealership that’s not Ford owned because I have a “Ford Pass” all Ford dealership can see the history of the car. And let it be someone else’s problem.

Filed Feb 20, 2026 · Engine · 110,000 miles · NJ

The contact owns a 2016 Ford Escape. The contact stated that while driving at an undisclosed speed, the instrument panel indicated that the engine was overheating. While driving at 35 MPH, the temperature gauge indicated that the engine was overheating. The contact pulled over to the side of the road, where the vehicle experienced complete engine failure. The vehicle was towed to a certified mechanic, who diagnosed the vehicle and determined that coolant was leaking into the engine because of a fault in the engine block. The engine needed to be replaced. The mechanic informed the contact that it was a known failure with the vehicle and referred the contact to the dealer for assistance. The vehicle was not repaired. The engine block failure was related to the federal safety agency Campaign Number: 26V011000 (Equipment); however, the VIN was not included. The manufacturer was informed through an online complaint of the failure; however, the contact was not able to speak with a representative. The failure mileage was approximately 110,000.

Filed Dec 24, 2025 · Transmission · VA

Complete loss of power and the transmission just going out, there was no warning or indication that something was wrong with the transmission prior to it going out on the highway. Car has 120K miles on it. It was diagnosed as needing a new transmission, and cooler. The pump may have needed to be replaced as well. But the transmission was pushing fluid out into the engine. If the car was fixed, I would likely need a new engine as well. This was a platinum edition 2016 Ford Escape.

Filed Aug 29, 2025 · Transmission · 104,362 miles · OH

The contact owns a 2016 Ford Escape. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The vehicle decelerated and failed to exceed 4 MPH. The contact stated that the vehicle stalled, and eventually the engine seized. No warning lights were illuminated. The contact restarted the vehicle; however, the engine seized again. The vehicle was towed to an independent mechanic, and the failure was linked to a recall that was performed on the vehicle in 2022. The vehicle was towed to the residence. In addition, the vehicle had been parked and inoperable since. The dealer was made aware of the failure. The contact stated that in 2022, a recall notification for the power train was received. The vehicle was taken to the dealer, and the recall repair was performed, but the failure reoccurred. The manufacturer was made aware of the failure but provided no assistance. The contact stated that in 2022, when the initial failure occurred, a case was filed and then closed. The contact was advised to contact the federal safety agency Hotline to report the failure. The contact was advised to ask the federal safety agency about approving the unknown recall to be performed again because of the recurring failure. The failure mileage was approximately 104,362.

Filed Aug 25, 2025 · Engine · TX

According to Cleburne Ford, my 2016 Ford Escape had a coolant leak that makes the engine malfunction and they quoted me a price for a new engine installation. My safety had been impacted because now I don’t know when my engine will stop working but I need a car to get to work. An independent mechanic I took it to told me he could not find a leak or see anything wrong with it, but of course he isn’t a Ford dealership employee. I had a check engine light to which then I contacted Cleburne Ford and they were able to diagnose it and give me the bad news.

Filed Jul 18, 2025 · Engine · WA

The engine light came on so we took it to a mechanic. The diagnostic said "coolant leaking in cylander 1". We were told the engine was allowing coolant to leak into it (because of a design flaw known to Ford) and the only option was to completly replace it. That engine is no longer being manufactured and Ford won't help me in any way. My car has less than 70,000 miles on it and is undriveable. Total engine failure due to head gasket leak.

Filed Jul 3, 2025 · Engine · 132,000 miles · IN

The contact owns a 2016 Ford Escape. The contact stated that while his wife was driving 25 MPH, she noticed white smoke coming from the exhaust. The driver pulled over into a gas station and called her husband to inform him of the failure and drove the vehicle to the dealer. The vehicle was taken a dealer and was inspected, and the technician became aware of a leak; however, the technician was unable to determine the location of the leak. The vehicle was then taken to another dealer where it was diagnosed with coolant leaking into cylinder #1. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure. The contact related the failure to Technical Service Bulletin: 22-2229 (Eco boost 2.0L Engine Failures); however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline to report the failure and opened a case. The failure mileage was 132,000.