The contact owns a 2005 Ford F-350. The contact stated while driving approximately 60-65 MPH and coming up to a bridge, the contact stated that the roadway was a bit wet from ice and rain, and the contact stated that the vehicle ahead entered the bridge and started skidding, so the contact let up off the accelerator pedal; however, when the vehicle entered the bridge, the vehicle started sliding and the contact lost control of the vehicle and crashed head-on into the concrete barrier surrounding the bridge and broke the two picking eyes that was welded unto the front sub frame of the vehicle. The contact stated that the front bumper was severely damaged, and he was concerned that that the air bags had failed to deploy. The contact stated that his chin struck the steering wheel, and his neck was hyper-extended. The contact sustained neck and shoulder injuries. The contact had not received medical treatment at the scene and was not transported to the local medical center for treatment. The contact stated that a Police report was filed and he received paperwork to request a copy of the Police report. The vehicle was towed to a local tow yard. The vehicle was later towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 228,000.
The worst 2005 Ford F-350 problems
Ranked by number of owner complaints. Mileage and cost come from what owners wrote.
Problems by type
Tap a problem to see which part fails, at what mileage and in which other years.
- Fuel system36
- Engine35
- Steering28
- Suspension25
- Electrical15
- Brakes7
- Transmission5
- Driver assistance4
- Acceleration2
- Airbags2
- Lights2
- Tires2
- Wheels2
- Body1
Specific symptoms reported on the 2005 Ford F-350
Stalling 24Loss of power 10Overheating 6Ball joint 5Fuel pump 5
Recalls 3
Exterior lighting: brake lights
- What is wrong
- Ford is recalling certain model year 2011 ranger trucks built from january 25, 2011, through april 25, 2011 at the twin cities assembly plant, and service parts distributed to dealers for certain 2004 through 2011 model year ranger trucks, 2002 through 2005 model year excursion vehicles, and 2002 through 2007 model year f-250, f-350, f-450, and f-550 trucks for failing to comply with the requirements of federal motor vehicle safety standard no. 108, "lamps, reflective devices, and associated equipment." the multi-function switch was shipped with a subcomponent (slider) that may experience deformation. A multi-function switch with a deformed slider may malfunction causing the turn signal, tail lights, hazard warning signal flashers and/or brake lights not to activate.
- Risk
- Non-functioning lights could increase the risk of a crash.
- Remedy
- Dealers will replace the switches free of charge. The safety recall began on august 15, 2011. Owners may contact ford motor company customer relationship center at 1‑866‑436‑7332.
Recall number 11V352000 · Recall details
Equipment adaptive/mobility
- What is wrong
- Comm trans is recalling 108 my 2005-2008 ford e250 and e350 vans built on ford chassis and equipped with ricon platform style wheelchair lifts. These lifts fail to comply with the requirements of federal motor vehicle safety standard no. 403, "platform lift system accessible for motor vehicles." the anti-stow interlock may not detect the presence of a wheelchair or mobility aid user. The pressure sensing switch that detects the presence of weight on the platform was not adjusted to the necessary sensitivity level. The lift could stow even though someone or something is still on the lift.
- Risk
- A lift occupant can be injured should the lift begin to stow unintentionally.
- Remedy
- Comm trans is working with ricon to correct the wheelchair lifts free of charge (please see 07e097). Owners may contact ricon at 1‑818‑267‑3000 or comm trans at 901‑726‑9394.
Recall number 09V026000 · Recall details
Equipment adaptive/mobility
- What is wrong
- Comm trans is recalling 111 my 2005-2008 ford e250 and e350 vans built on ford chassis and equipped with ricon platform style wheelchair lifts. These vehicles fail to comply with the requirements of federal motor vehicle safety standard no. 404, "platform lift installations on motor vehicles." the threshold warning system may not detect the presence of a wheelchair or mobility aid user in a certain spot within the defined threshold area.
- Risk
- The user of the lift could be injured should the lift move unintentionally.
- Remedy
- Comm trans is working with ricon to correct the wheelchair lifts free of charge (please see 07e095). Owners may contact ricon at 1‑818‑267‑3000 or comm trans at 901‑726‑9394.
Recall number 09V025000 · Recall details
See all 3 recalls for the 2005 Ford F-350
Defect investigations
Violent front end oscillation
This investigation was opened based on 78 consumer complaints of severe suspension and steering wheel oscillations after the subject vehicles traveled over an uneven surface.odi was concerned about these complaints because many of them alleged loss of control and the loss of control occurredat speeds above 50 miles per hour.at the time these complaints were received, odi was also aware of the tsb 07-10-10 and early warning field reports that discussed the shimmy condition on the subject vehicles.since opening this investigation, odi has confirmed, based on consumer complaints, warranty data, testing conducted by vrtc, and odi inspection of complaint vehicles, that the owners of the subject vehicles are experiencing shimmy events on their vehicles.however, odi has also confirmed that owners typically do not maintain their tires at the pressures recommended by ford on the tire label.further, odi has found that in order for shimmy to occur, tire pressures must be substantially below (at least 20%) those specified on the vehicle tire label.odi considers these unsafe tire conditions to be the result of one of three typical situations.the tires are being improperly maintained, the owners are intentionally setting the tire pressures low to enhance ride quality, or aftermarket tires (not designed for use on the vehicle) are installed to change the appearance or function of the vehicle.the subject vehicles are intended and designed to be used as heavy duty vehicles and as such require that the tires be capable of handling the loads for which the vehicle is designed and marketed.in order for the tires to be capable of handling these loads, the proper tire pressure must be maintained.in light of the information gathered in this investigation and ford's agreement to notify subject vehicle owners (now and every two years until the vehicles reach ten years from their production date) about the importance of maintaining proper tire pressures on their vehicles, further use of agency resources does not appear to be warranted.the closing of this investigation does not constitute a finding by the federal safety agency that no safety-related defect exists.the agency reserves the right to take further action if warranted by the circumstances.for additional information, see the attached closing report.
EA08007
Violent front end oscillation
Odi has received 78 consumer complaints of severe suspension and steering wheel shimmy and oscillations commencing after the subject vehicles traveled over an uneven road surface. The majority of these incidents occurred at speeds of 50 MPH or greater.thirteen of the complaints received by odi allege loss of steering control and that the vehicle changed driving lanes uncontrollably.four of the complaints received by odi allege that the vehicle left the road surface as a result of the violent suspension and steering wheel oscillations.in one case the consumer alleges that after the vehicle left the road surface, it crashed into a wooded area.additionalfactors contributing to the opening of this ea were early warning field reports,submitted by ford, describing suspension shimmy / oscillationsand a ford tsb (07-10-10) describing the suspension shimmy issue and how to repair the problem.ford has described shimmy as self-excited oscillation of the steering wheels with accompanying wheel tramp.this pe has been upgraded to an engineering analysis (ea) to determine if the shimmy condition that occurs on the subject vehicles creates a condition where the vehicle becomes difficult to control or startles the driver, thus presenting a safety risk.
PE07057
Technical service bulletins for the 2005 Ford F-350 8
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- In monitoring our technical service inquiries and technical service bulletins from Ford, there is the...
- Ford truck: some trucks equipped with a 6.0L diesel engine may exhibit a hard start/long crank or no start...
- Slow fuel fill--mil on with DTC P0191
- Water in the fuel tank behind rear axle - 6.0L, 6.4L and 7.3L diesel engine
- Vehicles equipped with a 5.4L 3V or 6.8L 3V engine built on or before 09/08/06 may exhibit an exhaust...
- Slow fuel fill
- Misfire and DTC P0300
- Brake line modification needed due to front wheels coming into contact with the brake lines
What 2005 Ford F-350 owners say
Most recent owner complaints, unedited.
Vehicle stalls while driving and wont start again suddenly while operating. Fuel injectors won’t feed fuel line to restart or operate. Occasional start but then stalls continuously until battery dies from trying. Will start when priming the carburetor however will not stay running and stalls out.
Twice today, traveling at 75mph on highway [XXX] (northbound and then several hours later southbound) just north of Ardmore OK, I experienced a violent shaking of the steering wheel/front wheel shimmy. The vehicle was difficult to control due to the violent shaking that did not stop until the vehicle slowed to approximately 20mph. Once the shaking stopped the vehicle was okay to drive. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
My 2005 F350 Diesel Pick up has suffered from the Ford death wobble on and off for the last 15 years. While navigating a left hand corner at speeds over 40 it begins to shake uncontrollably after hitting a small bump or pot hole until speed is reduced to 30mph or less. I have replaced bearings, uppper & lower ball joints, torque arms and other suspension parts without finding a cure.
Multiple times driving the truck at speed limit and hit small bump or a little bumpy part of road triggers the death wobble. Have to almost come to complete stop on highway to stop wobble.
The contact owns a 2005 Ford F-350. The contact stated while driving approximately 50 MPH, the vehicle started to shimmy. The contact stated that at the time of failure the steering wheel was very difficult to turn. The contact stated that after slowing down the vehicle operated normally. The contact stated that the brake warning light was illuminated. The vehicle was not repaired. The contact stated that she received notification in the mail of the federal safety agency Campaign Number: 20E090000 (Steering, Suspension, Equipment) however, her vehicle was not included in the recall. The contact stated that neither the dealer nor the manufacturer was notified of the failure. The failure mileage was unknown.
The all very common issues with the year f350 and the 6.0 l. Engines, are as such. The malfunctioning FICM. THE high and low oil coolers, the inter coolers and head studs. Also leaking break fluid .
Oil leaking from more than 4 parts of the engine and was told it’s normal for this model. Also, when driving over a bump or uneven pavement the trucks steering and suspension drives out of control.
Once I get up to 55-60 mph it just shakes really bad, I have had ball joints replaced bought new tires and it still shakes
[XXX], [XXX] approx age 40 lives and works at [XXX].[XXX] can also control the computers to cancel out and delete the use of catalytic converters, delete the use of DEF intake, delete the use of DPF particulate filters, and not react to controls such as manual braking or acceleration because the computer is controlling when and not the driver. [XXX] strictly states that he cannot have any emissions controls such as EGR, DEF, DPF, catalyst, or any pollutant controls. [XXX] intentionally set it up to have flaws and be dangerous for one reason: to get the customer to keep returning again and again with vehicle problems, wiring electrical problems, performance problems, overheating problems, and never ending engine problems not to mention transmission problems because the transmission could not handle the increased output of the engine. The hydroboost and ABS module and master cylinder that controls the brakes can be easily rigged so that when the driver stomps on the brakes, there is no braking action whatsoever for a 3-5 second delay before skidding the tires and locking the brakes. [XXX] altered the hydroboost and ABS module and master cylinder and the electronic controls to the braking system. [XXX] [XXX] partner admitted the hydrobooster and master cylinder was the problem because he admitted what [XXX] did as sabotage to the customer’s truck. [XXX] deletes the DPF and DEF and the electronics rewiring the truck. [XXX] has a pattern of keeping customers vehicles for excessively long periods of time: 42 days to change batteries, change fuel pump change PCM fusebox and rewire truck. [XXX] has removed the all the catalytic converters and he has removed all the EGR and emissions pollutant controls on [XXX]. [XXX] has sabotaged this truck’s braking system, electrical systems, fuse box wiring, electronic braking wiring, accelerator electronic control. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).
Compare the 2005 Ford F-350
Other model years
199019911992199319941995199619971998199920002001200220032004200520062007200820092011201220132014
Questions about the 2005 Ford F-350
Is the 2005 Ford F-350 reliable?
Owners have filed 114 complaints about the 2005 Ford F-350, close to a typical F-350 model year.
What is the 2005 Ford F-350 year score?
The 2005 Ford F-350 scores 74 out of 100 (average). The score compares it with the other model years of the Ford F-350: 75 is a typical year, 50 means twice the usual complaints, and serious complaints and recalls lower it.
What is the most common problem with the 2005 Ford F-350?
Fuel and propulsion system, with 36 complaints, typically around 98,000 miles. Next is engine (35).
How many recalls does the 2005 Ford F-350 have?
3 recalls, covering exterior lighting and equipment adaptive/mobility.
What year does the Ford F-350 have the most fuel system problems?
The Ford F-350 model years with the most fuel system complaints are 2005 (36 complaints), 2004 (25 complaints) and 1999 (24 complaints).
VIN decoder
See the problems and recalls for an exact car
Buying a used 2005 Ford F-350?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history