2012 Ford F-350 problems

What is wrong

PJ's Truck Bodies & Equipment Co., (PJ's) is recalling certain 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis modified by PJ's and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.

Risk

The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.

Remedy

PJ's has notified owners and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on August 28, 2014. Owners may contact PJ's customer service at 1‑866‑475‑8782.

Recall number 14V498000 · Recall details

What is wrong

Ford Motor Company (Ford) is recalling certain model year 2011-2012 F-350/450/550 Ambulance Package vehicles manufactured February 22, 2010, through October 19, 2012 and equipped with a 6.7L diesel engine. Due to an exhaust sensor problem, the vehicles may experience loss of power followed by an engine stall.

Risk

An unexpected engine stall increases the risk of a crash. Additionally, if this were to occur when the ambulance is transporting a patient, there is an increased risk of injury to the patient.

Remedy

Ford will notify owners, and dealers will replace the exhaust gas temperature sensor, free of charge. The recall began on November 25, 2013. Owners may contact Ford Motor Company Customer Relationship Center at 1‑866‑436‑7332. Ford's recall campaign number is 13S10.

Recall number 13V535000 · Recall details

What is wrong

Manning Equipment Inc. LLC (Manning) is recalling certain model year 2012 Ford F-350, F-450 and F-550 gasoline engined dual rear wheel chassis vehicles manufactured October 2011 through June 2012. The tailpipe on the exhaust system does not extend out beyond the edge of the body, allowing heat to build up in rear curbside storage compartment.

Risk

Excessive heat build up in rear compartment could result in fire.

Remedy

Manning Equipment has notified owners, and dealers will install tailpipe extensions free of charge. The recall has already begun. Owners may contact Manning Equipment at 1‑502‑426‑5210.

Recall number 13V380000 · Recall details

What is wrong

Ford is recalling certain model year 2011 f-150 vehicles manufactured from september 9, 2011, through september 22, 2011, and model year 2012 f-250, f-350, f-450 and f-550 heavy duty vehicles manufactured from september 12, 2011, through september 22, 2011. These vehicles fail to comply with the requirements of federal motor vehicle safety standard number 114, “theft protection.” the transmission can be shifted out of the park position without pressing the brake pedal due to brake shift interlock switch problem.

Risk

This will allow the operator to inadvertently shift the vehicle into gear without the brake pedal being depressed, increasing the risk of a crash or injury to a nearby pedestrian.

Remedy

Ford will notify owners, and dealers will inspect the brake shift interlock switch function and replace the switch if necessary, free of charge. The safety recall began on december 22, 2011. Owners may contact the ford motor company customer relationship center at 1‑866‑436‑7332.

Recall number 11V582000 · Recall details

The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V‑535 were inadequate. Recall 13V‑535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V‑175) to address the 13V‑535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V‑175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V‑175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and the federal safety agency will take further action if such action is warranted.

RQ14005