The rack and pinion has failed twice within 2 and a half years. The steering has completely gone out twice while driving, causing extremely unsafe circumstances that could put multiple people in danger. After doing some research this is a common issue with Ford Fusions which is putting a lot of people in danger since it is a loss of steering issue. My wheel completely locked up while driving on the highway, how is this part not recalled yet? There are two separate safety recalls dealing with steering issues but the rack and pinion is not specifically mentioned so it is not covered under recall. This is extremely unsafe. Please look into this. Thank you.
Ford Fusion Hybrid power steering loss problems
129 of the 1,204 owner complaints about the Ford Fusion Hybrid describe loss of power steering, most of them for the 2010 model year.
- owner complaints
- 129
- worst model year
- 2010
- typical repair cost reported
- $2,000
- typical mileage
- 80,000
Is there a fix? No recall or service bulletin covers this area of the car yet.
By model year
Often reported together
Loss of power 40Steering lock-up 8Engine failure 8ABS 3Check engine light 2
Trouble codes mentioned
P2112 1
What owners say
The power steering has failed twice recently while driving and the dashboard warning displayed as follows: power steering assist fault. This makes it very hard to steer, dangerous and scary when this happens. Can a recall be issued for my vehicle? I am very disappointed that my 2010 ford fusion hybrid vehicle was left out of the recall even though it was manufactured at the same plant as the 2011 - 2013 models that were recalled. I found this online: Investigation and Recall ContextFederal Probes: the federal safety agency investigated 2010–2012 Ford Fusion and Lincoln MKZ models for sudden loss of electric power steering, logging thousands of complaints.Exclusion of the 2010 Model: Ford issued recalls (such as campaign 15S18) for 2011–2013 models to update power steering control modules or fix motor sensor faults, leaving 2010 models uncovered by the official action.Closure: the federal safety agency officially closed its investigation into the 2010 Fusion steering complaints after concluding the failure trend did not warrant a mandatory safety recall, noting drivers could still revert to manual steering.
While driving a 2013 Ford Fusion Hybrid Titanium (approximately 157,000 miles), the Electronic Power-Assisted Steering (EPAS) system suddenly failed without warning during heavy rain in Philadelphia, PA. I was driving near the riverfront area by [XXX] when the steering immediately became extremely stiff and difficult to turn. No prior warning lights or steering-related symptoms were present before the failure. Due to wet road conditions and the sudden loss of steering assist, I temporarily lost the ability to maneuver the vehicle normally and nearly collided with roadside structures near the river. Considerable physical force was required to maintain directional control and safely move the vehicle. This created an immediate safety hazard to myself and nearby traffic. The vehicle has not been involved in a crash, but the failure created a near-miss situation. My VIN currently shows no open recall for this issue, despite similar steering-system failures reported in comparable Ford vehicles using EPAS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
The contact owns a 2012 Ford Fusion Hybrid. The contact stated while driving at 50 MPH, the vehicle lost power steering functionality. There was no reservoir cap to check for power steering fluid. The power steering warning light was illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 72,000.
The contact owns a 2010 Ford Fusion Hybrid. The contact stated while reversing into a parking space at 2 MPH, the vehicle lost power steering functionality, and the steering wheel became significantly difficult to turn. The contact could not recall whether a warning light was illuminated. The contact was able to park the vehicle. The vehicle was taken to Tire Kingdom, where it was diagnosed. The mechanic determined that the failure was related to Ford Campaign Number: 15S18. The dealer was contacted and informed the contact that the VIN was not included in the campaign. The vehicle was not repaired. The manufacturer was notified of the failure and a case was filed. The failure mileage was approximately 150,000.
The contact owns a 2010 Ford Fusion Hybrid. The contact stated while driving at approximately 65 MPH, there was an abnormal sound coming from the driver's side front tire. The contact was able to exit the highway and drove to a tire store and had the tire replaced. The contact stated that after the tire was replaced while leaving the store parking lot, the check engine and power steering assist warning lights illuminated. The contact drove the vehicle to the residence but turning the steering wheel was extremely difficult, requiring extra effort to turn the steering wheel. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was informed of the failure. The contact researched online and related the failure to a closed the federal safety agency Action Number: EA17004 (Steering). The failure mileage was 229,875.
Power steering failed exactly as under recall 15S18 and 15N01 - however they say my car isn't included in the recall. The car is still at the dealer and broken, so the part is available at this moment. The steering warning came up while driving. Upon restarting, the car would only work in manual mode. The dealer has confirmed the problem. I have not contacted Ford yet, only talking to the dealer. There was no warning other than the one that came up when the failure occurred.
The contact owns a 2013 Ford Fusion Hybrid. The contact stated while driving at an undisclosed speed, he became aware that the electronic power steering was not functioning properly, requiring increased effort to maneuver the vehicle. The traction control and power steering assist warning lights were illuminated. The vehicle was towed to an independent mechanic, who diagnosed a failure with the electronic power steering gear motor. The vehicle was not repaired. After investigating the failure, the contact related the failure to the federal safety agency Campaign Number: 19V632000 (Steering), but the VIN was not included. The manufacturer was notified of the failure but referred the contact to the federal safety agency Hotline for assistance. The failure mileage was 112,000.
Driving down the road and suddenly all the lights came on and lost power steering there was no warning. Nothing. It stopped working. I then see something today in regards to this being an issue and when I contact ford about it was nothing we can do. Ford did not make this very public and I bet if you people expanded this to other newer models and made it public you might find more people that have had the same issue and thought it was just their car.
Code p2112, throttle body stuck closed. Lost power, no acceleration, no power steering. Has happened 3 times in the past 2 weeks. Check engine light comes on, no air bags, traction control or hill assist, messages pop up on dash. Too expensive too have Ford "diagnose" issue. No warning before this happens. There was no accident (yet) but it is my only vehicle so I have no choice about driving it.
Related recalls
No recalls on record for this model year.
Questions about the Ford Fusion Hybrid power steering loss
Which Ford Fusion Hybrid years have loss of power steering problems?
The model years with the most reports are 2010 (66 complaints), 2012 (19 complaints) and 2011 (17 complaints).
How much does it cost to fix loss of power steering on the Ford Fusion Hybrid?
Owners who mentioned a price put the repair at about $2,000 (median of 22 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Ford Fusion Hybrid?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history