2011 Ford Fusion: sudden loss of power

Filed Oct 13, 2026 · Steering · 100,000 miles · TX

The contact owns a 2011 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle suddenly lost power steering assist, nearly causing the contact to lose steering control as the steering locked up, and an audible warning chime sounded. The contact safely maintained control of the vehicle and observed that a power steering warning light was illuminated. The contact associated the failure with the federal safety agency Campaign Number: 15V340000 (Steering); however, the VIN was not included in the recall. The vehicle was towed to the residence. The manufacturer was notified of the failure. The failure mileage was 100,000.

Filed Oct 13, 2026 · Steering · KS

My mom’s 2011 Ford Fusion SEL experienced a loss of electric power steering assistance. I cannot determine the exact moment the failure occurred. When I started the vehicle and attempted to drive away, I noticed that the steering wheel was extremely stiff. The dashboard displayed a “Power Steering Assist Fault” warning. The steering assistance has not returned, including after replacing the vehicle’s battery. I diagnosed the vehicle using FORScan, which identified the following diagnostic trouble codes in the Power Steering Control Module (PSCM): U3000:96-C8 — Control Module, Component Internal Failure. C200C:2F-48 — Steering Shaft Torque Sensor 2, Signal Erratic. Both codes were recorded as previously set and not present at the time of the diagnostic request. However, the power steering warning remains displayed and the steering wheel remains extremely difficult to turn with the engine running. This vehicle was previously included in Ford Safety Recall 15S18 / the federal safety agency Recall 15V340, addressing loss of electric power steering assistance. Ford confirmed that the recall was completed in 2015 through reprogramming the Power Steering Control Module only rather than replacing the steering gear. The current diagnostic codes are specifically identified in Ford’s original recall service instructions as codes associated with steering gear replacement under the recall procedure. I contacted Ford customer service regarding the recurrence of loss of steering assistance. Ford opened a case for internal review but did not confirm repair coverage or provide a decision timeline. I am reporting this because the vehicle has lost power steering assistance despite having previously received the recall remedy. I am concerned that the original safety-related condition may not have been permanently resolved.

Filed Sep 15, 2026 · Steering · NM

The contact owns a 2011 Ford Fusion. The contact stated that while driving 35 MPH, the vehicle lost power steering assist, making the steering wheel difficult to turn and causing the vehicle to wobble from side to side. The message "Power Steering Assist" was displayed, and an unknown warning light illuminated. The contact stated that the failure posed a safety risk to the contact and her children. The contact pulled over to the side of the road, and the vehicle was towed to her parent's residence. The contact associated the failure with the federal safety agency Campaign Number: 15V340000 (Steering); however, the VIN was not included in the recall. The manufacturer was notified of the failure by phone.

Filed Jun 18, 2026 · Steering · OH

Having loss of power steering assist the advanced trac peering steering says service now I feel it should fall under a recall cause I took it to a mechanic shop and they told me they ford fusion have issues with the power assist steering cause it goes out

Filed Mar 17, 2026 · Electrical, Steering · MI

I experienced a complete loss of power steering on my 2011 Ford Fusion. Luckily I managed to avoid an accident and had the vehicle towed to my mechanic. When he told me what caused the issue, I looked up all recalls on this vehicle using my VIN for the 2011 Ford Fusion on both Ford's website and the website. There was a recall in 2015 for Loss of Electric Power Steering Assist the federal safety agency ID Number: 15V340000. Ford's number for this recall is 15S18. I called Ford customer service at 1‑866‑436‑7332 and they told me that this recall was no longer open. I bought this vehicle in 2020 and was not made aware of this recall at all, otherwise I would have gotten it fixed like I did for the airbag recalls. This was something that happened with no warning. The Ford customer service is refusing to acknowledge this recall or assist me on this.

Filed Feb 19, 2026 · Steering, Wheels · KY

Complete loss of power steering while driving, Service Power Steering Now warning light came on right after, service advance trac warning right after that. After doing some research this is a known issue to Ford and customer service agent confirmed this in chat, screenshot included.

Filed Jan 6, 2026 · Steering · AR

While driving on a state highway at approximately 45 miles per hour got a message on the dash saying “service power steering now”. Drove another mile and a half and then suddenly lost all power steering. Steering was stiff annd difficult but I was able to drive another half mile to home and then had the car towed to a mechanic for repair. Mechanic stated that my 2011 Ford Fusion has EPAS (electric power assisted steering) and the steering rack had to replaced to fix the issue at a cost of $1900. Apparently there is a recall for this issue on 2010-2012 Ford Fusions but my VIN was not included in the recall.

Filed Sep 22, 2025 · Steering · 120,000 miles · NJ

The contact owns a 2011 Ford Fusion. The contact stated that while her son was driving approximately 30 MPH, the vehicle lost power steering functionality. The driver was able to pull over to the side of the road. The contact and her husband met her son on the side of the road, and the contact's husband drove the vehicle to the residence without power steering functionality. The contact stated that the vehicle was previously repaired under the federal safety agency Campaign Number: 15V340000 (Steering); however, the failure reoccurred. The dealer informed the contact that the repair was no longer covered because the VIN was not included in the recall. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 120,000.

Filed Jul 29, 2025 · Steering · TX

I am writing to file a complaint regarding a serious and potentially dangerous issue with my 2011 Ford Fusion. Recently, my vehicle completely lost power steering while in use. In the past, I had experienced intermittent problems where the power steering warning light would appear upon starting the car, and the steering would be stiff. Typically, turning the car off and restarting it temporarily resolved the issue. However, this time, the power steering has failed completely and restarting the vehicle does not fix it. Upon researching this issue, I discovered that Ford issued a Customer Satisfaction Program (15N01), which extended the warranty on the power steering gear due to known defects. The extension covered up to 10 years or 150,000 miles from the original purchase date—whichever came first. Unfortunately, I only recently became aware of this program, well after my vehicle passed both the 10-year mark (August 2021) and 150,000 miles (I’m currently at 103,000). I never received any notification from Ford about this issue or the extended warranty. Had I known, I would have addressed the problem while within the eligibility window. Ford is now refusing to cover the cost of repairs, despite this being a well-documented issue caused by faulty components. I believe it is unacceptable for a manufacturer to acknowledge a defect, offer limited corrective action, and then leave customers to deal with costly and dangerous consequences when their notification system fails. This failure of power steering poses a serious safety risk, especially at higher speeds or in emergency maneuvers. I respectfully request that the federal safety agency investigate this issue further and hold Ford accountable for properly notifying affected vehicle owners and ensuring this defect is repaired, regardless of arbitrary mileage or date limits—especially in cases where owners were never notified in the first place.

Filed Jun 4, 2025 · Steering · 200,000 miles · NE

The contact owns a 2011 Ford Fusion. The contact stated that the power steering failed intermittently. The contact had to restart the vehicle to regain power steering functionality. The failure became more persistent, and the vehicle lost complete power steering functionality. The message “Loss of Power Steering” was displayed during the failure. Additionally, the TPMS fault sensor message was displayed; however, all tires were properly inflated. The contact found information on the federal safety agency Campaign Number: 15V340000 (Steering) and related the failure to the recall; however, the VIN was not included. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 200,000.

Filed May 5, 2025 · Steering · NY

Sudden power steering failure multiple times while on the road (at both higher speeds of ~55mph and lower speeds of ~20 mph). There was a warning light and notification on that dashboard about 10 seconds before it happened each time. The vehicle will be taken into the dealership tomorrow to be looked at, but after doing some online research this seems to be a very common issue for this year, make and model of Ford Fusion. Loss of power steering makes the vehicle very difficult to steer and pull off the road safety and puts both me and other drivers at risk.

Filed Nov 29, 2024 · Steering · 120,000 miles · AR

The contact owns a 2011 Ford Fusion. The contact stated while driving at an undisclosed speed, the power steering assist warning light illuminated, and the vehicle lost power steering functionality while his wife and minor children were inside the vehicle. The contact stated that the steering wheel was significantly difficult to turn. The contact was able to drive the vehicle to a safe location. The contact's family was provided alternative transportation. The vehicle was driven to the residence. The dealer was made aware of the failure and provided a diagnostic test fee. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure, but no assistance was provided. The failure mileage was approximately 120,000.