2011 Ford Fusion: loss of power steering

Filed Oct 13, 2026 · Steering · 100,000 miles · TX

The contact owns a 2011 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle suddenly lost power steering assist, nearly causing the contact to lose steering control as the steering locked up, and an audible warning chime sounded. The contact safely maintained control of the vehicle and observed that a power steering warning light was illuminated. The contact associated the failure with the federal safety agency Campaign Number: 15V340000 (Steering); however, the VIN was not included in the recall. The vehicle was towed to the residence. The manufacturer was notified of the failure. The failure mileage was 100,000.

Filed Oct 13, 2026 · Steering · KS

My mom’s 2011 Ford Fusion SEL experienced a loss of electric power steering assistance. I cannot determine the exact moment the failure occurred. When I started the vehicle and attempted to drive away, I noticed that the steering wheel was extremely stiff. The dashboard displayed a “Power Steering Assist Fault” warning. The steering assistance has not returned, including after replacing the vehicle’s battery. I diagnosed the vehicle using FORScan, which identified the following diagnostic trouble codes in the Power Steering Control Module (PSCM): U3000:96-C8 — Control Module, Component Internal Failure. C200C:2F-48 — Steering Shaft Torque Sensor 2, Signal Erratic. Both codes were recorded as previously set and not present at the time of the diagnostic request. However, the power steering warning remains displayed and the steering wheel remains extremely difficult to turn with the engine running. This vehicle was previously included in Ford Safety Recall 15S18 / the federal safety agency Recall 15V340, addressing loss of electric power steering assistance. Ford confirmed that the recall was completed in 2015 through reprogramming the Power Steering Control Module only rather than replacing the steering gear. The current diagnostic codes are specifically identified in Ford’s original recall service instructions as codes associated with steering gear replacement under the recall procedure. I contacted Ford customer service regarding the recurrence of loss of steering assistance. Ford opened a case for internal review but did not confirm repair coverage or provide a decision timeline. I am reporting this because the vehicle has lost power steering assistance despite having previously received the recall remedy. I am concerned that the original safety-related condition may not have been permanently resolved.

Filed Oct 9, 2026 · Steering · 56,000 miles · IN

The contact owns a 2011 Ford Fusion. The contact stated that while driving at various speeds, the steering wheel became stiff and excessive force was needed to make a left or right turn. The power steering assist and Advancetrac warning lights were illuminated. The vehicle was taken to a local dealer where it was diagnosed and confirmed that the rack and pinion needed to be replaced. The contact stated that the vehicle was previously taken to a local independent mechanic; however, the failure was not duplicated. The manufacturer was made aware of the failure. The failure mileage was approximately 56,000.

Filed Sep 15, 2026 · Steering · NM

The contact owns a 2011 Ford Fusion. The contact stated that while driving 35 MPH, the vehicle lost power steering assist, making the steering wheel difficult to turn and causing the vehicle to wobble from side to side. The message "Power Steering Assist" was displayed, and an unknown warning light illuminated. The contact stated that the failure posed a safety risk to the contact and her children. The contact pulled over to the side of the road, and the vehicle was towed to her parent's residence. The contact associated the failure with the federal safety agency Campaign Number: 15V340000 (Steering); however, the VIN was not included in the recall. The manufacturer was notified of the failure by phone.

Filed Jul 17, 2026 · Steering · MO

The vehicle experienced a sudden, complete failure of the electronic power steering assist while operating, resulting in a dangerous increase in steering effort and an immediate safety hazard. A professional OBD-II diagnostic scan retrieved active trouble codes C1277-20 (Steering Wheel Angle Sensor Signal Failure) and C1963-20 (Stability Control Inhibit Warning). This internal sensor failure matches the exact physical defect detailed in the federal safety agency Campaign Number 15V340000 (Ford Recall 15S18). Ford Corporate and the local dealership refuse to authorize a hardware replacement because they claim a software update completed in 2015 closed the recall on this VIN, despite the software patch failing to prevent the underlying physical hardware failure.

Filed Jul 15, 2026 · Steering · MN

Yesterday evening, my power steering went out (EPAS), it did that when the car had been parked for the night and not in motion thankfully so nobodies safety was at risk, but I don’t know if and when it’ll happen again. According to Ford, it has been a recurring problem with ford fusion modules similar to mine, that the EPAS has been defective, and therefore making it dangerous to drive. My exact car has been inspected by a mechanic, and while it has been looked at, there were no warnings of this error happening, the vehicle was driving fine and all of a sudden, the error occurred.

Filed Jun 18, 2026 · Steering · OH

Having loss of power steering assist the advanced trac peering steering says service now I feel it should fall under a recall cause I took it to a mechanic shop and they told me they ford fusion have issues with the power assist steering cause it goes out

Filed May 4, 2026 · Steering · TN

The contact owns a 2011 Ford Fusion. The contact stated while driving at an undisclosed speed, the steering wheel failed to steer in the intended direction. In addition, the power steering failure warning light illuminated. The contact had to apply all of her strength to turn the steering wheel in the intended direction. The vehicle was driven to the contact's residence. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact referenced an unknown recall which had a similar failure description, however the contact's VIN was not associated. The manufacturer was not made aware of the failure. The failure mileage was unknown.

Filed Mar 17, 2026 · Electrical, Steering · MI

I experienced a complete loss of power steering on my 2011 Ford Fusion. Luckily I managed to avoid an accident and had the vehicle towed to my mechanic. When he told me what caused the issue, I looked up all recalls on this vehicle using my VIN for the 2011 Ford Fusion on both Ford's website and the website. There was a recall in 2015 for Loss of Electric Power Steering Assist the federal safety agency ID Number: 15V340000. Ford's number for this recall is 15S18. I called Ford customer service at 1‑866‑436‑7332 and they told me that this recall was no longer open. I bought this vehicle in 2020 and was not made aware of this recall at all, otherwise I would have gotten it fixed like I did for the airbag recalls. This was something that happened with no warning. The Ford customer service is refusing to acknowledge this recall or assist me on this.

Filed Feb 25, 2026 · Steering · 82,000 miles · KS

The contact owns a 2011 Ford Fusion. The contact stated that while driving approximately 3 MPH and turning left into a driveway, the steering wheel became extremely difficult to turn. The contact stopped, turned off and restarted the vehicle, and drove back to the residence. The contact had researched online and associated the failure with the federal safety agency Campaign Number: 15V340000 (Steering). An appointment was scheduled with a local dealer who diagnosed the vehicle and determined that the power steering assist had failed and needed to be replaced. The contact informed the service manager of the recall and was informed that the VIN was no longer covered under warranty, and that the vehicle was previously covered under Manufacturer Recall Number: 15N01. The vehicle was not repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 82,000.

Filed Feb 19, 2026 · Steering, Wheels · KY

Complete loss of power steering while driving, Service Power Steering Now warning light came on right after, service advance trac warning right after that. After doing some research this is a known issue to Ford and customer service agent confirmed this in chat, screenshot included.

Filed Jan 15, 2026 · Steering · IA

Power steering failed, there is a recall (15S18/15V340) that was done in Jan 2017 but all they did was electrical reprogramming. My power steering system (referenced in the recall) mechanical issues failed and I took the vehicle to Ford and Ford Corporate denied the recall claim. I called Ford Recall department on 1/15/2026 at 4:36PM CT and requested to speak to a manager and got connected with the manager on 1/15/2026 at 5:08PM CT in which the manager ended up hanging up on me. Therefore, I called Ford Corporate Customer Service to file a complaint on 1/15/2026 at 5:38PM CT and the representative denied me my complaint and would not provide me the recording of my conversation with her or the representative and manager even though they all told me that our conversation would be recorded. The fact that this mechanical failure occured under the recall terms is dangerous to the public as I was on the highway when my power steering just failed, it was not a wear and tear problem. This recall needs to be seriously looked at again and a complaint should be issued to Ford customer service and Ford Recall Service. This should also be a class action lawsuit.