2012 Ford Fusion: loss of power steering

Filed Nov 5, 2026 · Steering · NY

Driving my car and the error message flashes "service trac now" and "service power steering". I got home, but the next morning I had no power steering. This is the second time this has happened. This first time Ford reset some codes and it was fine for 2 month but it happened again. Apparently my car was made about a month after the cut off date for the recall for the power steering issue 15S18 (the federal safety agency Campaign ID 15V340000). I do also want to note that it could be a coincidence, but the low tire pressure came on, I was on my way to fill it up and then all these error started flashing. That happened both times but I'm not sure if it is related. Ford has refused to fix this issue even though it is the same issue that is included in that recall. I cannot drive my vehicle without power steering, it will be very costly and seem like it should have been included in the recall.

Filed Sep 24, 2026 · Steering · WA

Our 2012 Fusion suffered a sudden loss of power steering, was diagnosed with code U3000 at a Ford dealer, and that the dealer confirmed it matches the 15S18 recall symptoms despite being built two months outside the window. Our vehicle was manufactured at the Hermosillo plant in 2012, just two months outside the 15S18 recall window. It suffered an identical, sudden loss of power steering assist while driving, indicating Ford's recall parameters failed to capture all vehicles fitted with the defective component.

Filed Sep 23, 2026 · Steering · 98,000 miles · PA

The contact owns a 2012 Ford Fusion. The contact stated that while driving 50 MPH, the vehicle lost power steering assist, causing the steering wheel to be significantly difficult to turn. The contact was able to drive to the nearby residence and parked in the driveway. The message "Service Power Steering Assist" was displayed after the failure. The contact associated the failure with the federal safety agency Campaign Number: 15V340000 (Steering). The failure mileage was approximately 98,000.

Filed Aug 20, 2026 · Electrical, Steering · WA

While I was driving my 2012 Ford Fusion on August 3rd the steering cut out. I parked the car and re-started it and it worked again. It went to the shop (Extra Mile Automotive) on XXX where they informed me of the 2015 recall on the steering. Recall number 15S18 and program 15N01 When I spoke with [XXX] Ford in [XXX], they said they replaced the electrical piece of the recall on December 7th 2015, but not the steering shaft. [XXX] (the westlie ford employee) said because the electrical was completed, the recall procedure was marked as completed, even though [XXX] said that this is very much tied to the original recall. I asked him to submit a Special Service Support Center request to get this fixed and he did submit that on XXX. On XXX it was denied. On XXX I also requested to speak to [XXX] supervisor and was connected to [XXX] (id # XXX) who also said there was nothing she could do because this was already "solved" in 2015. This is not a new or unrelated repair request, it is the unresolved second half of a federally mandated safety recall. Ford's own dealership confirmed that my steering gear failure is directly connected to the original defect covered under Recall 15S18, and Ford's own extended coverage program, 15N01, exists specifically to remedy this exact scenario. Despite this documented connection, Ford has now denied a remedy twice, once through the dealer's SSSC request, and once directly through Ford Customer Service, without providing any technical explanation for why a known, recall-covered defect is being treated as ineligible for repair. My vehicle experienced a complete loss of steering assist while in motion. This is an active, unresolved safety hazard on a vehicle currently in use on public roads, and I am filing this formal complaint because Ford has failed to meet its obligation under federal law to remedy a safety defect without charge to the owner. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 17, 2026 · Steering · CA

Vehicle experienced loss of power steering so it was hard to steer.When I called a ford dealership I was told my vehicle didn’t qualify for any power steering recalls so I would have to pay full price which is unaffordable

Filed Aug 5, 2026 · Steering · WA

I am submitting this formal complaint against Ford Motor Company and its authorized dealership network for falsely reporting a safety recall repair as "resolved" while applying an unauthorized, temporary workaround that left the primary safety defect active. In 2023, I brought my vehicle to an authorized Ford dealership to perform mandatory safety recall service regarding the Electric Power Assist Steering (EPAS) failure. The dealership subsequently updated Ford’s central database (OASIS) to show that the safety recall was fully resolved and completed for my VIN. However, the official Repair Order / Invoice provided to me by the technician explicitly documents that a permanent remedy was not performed due to a lack of replacement parts. The technician’s exact written notes state: "Customer states power steering is not working. Tech and advised verified concern finding that the ground wire pin on the high current wiring harness to PSCM had backed out of the connector. Reconnected pin and cleared codes finding issue resolved. Issue will continue to happen until the harness is replaced. Harness is unavailable at this time. Glued pin into connectors."Because the dealership glued the loose pin rather than replacing the backordered wiring harness, the temporary repair failed shortly thereafter, resulting in a total loss of power steering assist. For the past three years (approximately 47,698 miles driven), I have been forced to operate this vehicle without functional power steering. Every attempt to have Ford or its franchised dealerships address this safety hazard has been denied because Ford’s internal system incorrectly lists the recall as "The Harness Powers the Recalled Module: The "high current wiring harness to PSCM" is the primary electrical supply to the exact module being recalled. Reprogramming software on a module while leaving a damaged, glued power connector defeats the entire purpose of restoring power steering safety.see photoes of invoice below

Filed Jul 27, 2026 · Steering · 138,000 miles · SC

The contact owns a 2012 Ford Fusion. The contact stated that while driving at an undisclosed speed, the steering wheel became difficult to turn. The message "Power Steering Assist Fault" was displayed. The failure was a recurring failure. The first failure was serviced by the dealer under the federal safety agency Campaign Number: 15V340000 (Steering); however, a year later, the failure reoccurred. The vehicle was then taken to an independent mechanic where the rack and pinion was replaced but the failure persisted. The manufacturer was made aware of the failure. The failure mileage was approximately 138,000.

Filed Jun 30, 2026 · Steering · 130,000 miles · WA

The contact owns a 2012 Ford Fusion. The contact stated that while driving 50 MPH, the vehicle lost power steering functionality and almost caused a crash. The message "Service Power Steering Now" was displayed. The contact was able to drive to the destination. The contact stated that the vehicle had become undrivable due to the failure. The contact related the failure to the federal safety agency Campaign Number: 15V340000 (STEERING); however, the VIN was not included. The dealer and the manufacturer were not contacted. The vehicle was not diagnosed or repaired. The failure mileage was approximately 130,000.

Filed Jun 23, 2026 · Electrical, Steering · PA

I was just driving and I lost power steering, it was incredibly difficult to steer and it was Heavy Steering, and warnings appeared on the dash.

Filed May 14, 2026 · Steering · NJ

Our 2012 Ford Fusion had a sudden and complete loss of power steering & “Power Steering Assist Fault’ flashed on dash. The steering immediately became extremely difficult to operate, requiring both hands and excessive physical force just to turn the wheel. It felt less like driving a passenger car and more like wrestling a fully loaded dump truck with flat tires. This created a serious safety concern because the failure occurred without warning and fundamentally affected our ability to steer the vehicle safely. Fortunately, my wife was not driving at the time. The amount of force suddenly required to turn the wheel could easily be overwhelming, particularly during an emergency maneuver, in traffic, or while entering an intersection. After the failure occurred, we discovered vehicle had previously been subject to recall 15V340000 and Ford Safety Recall 15S18, both involving the exact electric Power Steering Control Module (“PSCM”) that has now failed. Under that recall, a Ford dealer performed only a software update on 10/17/2016. We opened a case with Ford, brought the vehicle to a local dealer & paid for a diagnostic inspection. Using Ford IDS equipment, dealer confirmed the condition and documented ‘NO COMMUNICATION WITH PSCM’. The dealer report quoted “Steering Gear Assembly - Rack & Pinion Assembly Replace: $3,215.81.” The diagnosis was reported directly to Ford under the active case number. Despite the recall history and confirmed failure of the same steering system covered by the prior recall, Ford denied assistance because the earlier software reprogramming had already been completed. Our position is that this is clearly a hardware failure involving the recalled electric power steering system itself — the precise condition the recall was intended to address. Ford’s own recall communications dated May 17, 2019 specifically instructed owners to retain recall documentation in the event this exact situation later occurred.

Filed Apr 8, 2026 · Steering · 56,000 miles · AK

The contact owns a 2012 Ford Fusion. The contact stated that while driving at 20 MPH, the vehicle lost power steering functionality. There was no warning light illuminated. The contact was able to continue driving, but the steering wheel was difficult to turn. The vehicle was driven to an independent mechanic, where it was diagnosed, and determined that the steering gear had failed and needed to be replaced. The vehicle was not repaired due to the cost. The contact related the failure to the federal safety agency Campaign Number: 15V340000 (Steering); however, the VIN was not included in the recall. The manufacturer was notified of the failure but denied assistance due the manufacturing date of the vehicle. The failure mileage was approximately 56,000.

Filed Mar 8, 2026 · Electrical, Steering · SC

The Power Steering Assist Fault notice keeps popping up on the dashboard screen. When this happens, the power steering is inoperable leaving me stranded. I've had my mechanic fix it several times (after the Ford Recall on steering didn't properly repair the issue) costing an insane price. It's very unsafe to be on the road & have the power steering go out. It is unsafe not only for me & my family but also for the vehicles traveling around my vehicle. It causes mental distress & anxiety as I never know when I'm going to be left stranded. This time, I'm stranded at the laundromat, on a Sunday. Not knowing how I'm going to get home or to work tomorrow. My receipts for repairs are at home. Until Ford makes this right, I'll never see the Ford brand as a reliable manufacturer nor will I ever purchase or recommend the Ford brand.