2015 Freightliner 108SD technical service bulletins
322 technical service bulletins and manufacturer communications cover the 2015 Freightliner 108SD.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Service Solution for M2, 108SD, 114SD
- Service Solution for Legacy M2 Bulkhead Module (BHM) Replacement and DiagnosticLink Issues
- Service Solution for Legacy M2 Bulkhead Module (BHM) Replacement and Diagnosticlink Issue
- CX Advocate for NOx conversion low faults
- CX Advocate for turbo oil drain cracking
- CX Advocate for DD13 Gen 5 engines operating at high altitude experience EGR slow response fault.
- Parts Bulletin for Powertrain Power Distribution Module (PTPDM) Kit Replacement
- CX Advocate for bulkhead module reprogramming (SS 3146-FTL)
- CX Advocate for NOx conversion low faults
- CX Advocate communication for NOx conversion low faults
- Freightliner Service Bulletin for DEF Connector Reinforcement Caps.
- Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown
- Updated Freightliner Service Bulletin for Espar Service Information
- Warranty Policy Letter for battery tags
- Freightliner Service Bulletin for Programming Chassis Electronic Control Units (ECUs) With DiagnosticLink.
- Starting on November 23, 2020, DiagnosticLink 8.13 (Build 4527) was made available
- Warranty Information Letter for Detroit NOx Sensor Circuit Fault Codes
- Superseding Letter to an Important Campaign Information Letter to announce a reimbursement available to...
- Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance
- Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring
- Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing
- Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing
- This SKU is a DEF Injector
- Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide
- Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring
- Joyson Safety Systems letter informing DTNA about Hikone Webbing Investigation
- Tech Talk discussion about power steering fluid.
- Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
- Revised letter is to announce a reimbursement available to dealers for travel to a customer's location to...
- Service Bulletin for Powertrain PDM and Main PDM Bracket Modiï¬cation
- Warranty Information Letter informing that to ensure that DTNA policies and service network practices...
- Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance
- Important Campaign Information letter announcing Dealer Travel for Campaign Performance
- Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change
- Customer Service Announcement informing that Service Pack (SP) 1 for DiagnosticLinkÃÂÃÂÃÂî 8.12...
- OEM and distributor announcement for DiagnosticLink 8.12 (Build 4527) was made available
- Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility
- Service Bulletin for Front Lighting Ground Splice Pack Failure
- Customer Service Announcement for DiagnosticLink Software Update Reminder
- Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces
- Customer Service Announcement for Release of DiagnosticLink 8.12. On Wednesday, June 10, 2020,...
- Warranty Information Letter for Warranty Training Online
- Warranty Policy Letter for Handling for Authorized Service Location Part Transfers
- Warranty Policy Letter for Chassis Progressive Damage Policy Change
- Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program
- Warranty Information Letter for Warranty Long Block Program Change
- Service Bulletin for Lengthening the Backup Light Harness
- Freightliner Service Bulletin for Front Axle Spacer Replacement
- Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLink® 8.11 Standard and...
- Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy,...
- Freightliner Service Bulletin for vibration troubleshooting
- Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and...
- Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and...
- Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness
- Customer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs)...
- Service Bulletin on guidelines for repairing or replacing an electrical harness.
- Service Bulletin for A/C system receiver-drier replacement guidelines.
- Warranty Information Letter announcing Detroit NOx Sensor Circuit Improvements for GHG17 After Treatment...
- Service Bulletin for severe duty main PDM installation for vehicles operating in severe moisture and/or...
- Service Bulletin revision to an earlier submission of SB54-308 for October 2019 (19MC2968)
- Service Bulletin about the powertrain PDM and Main PDM bracket being modified to reduce stress and...
- Service bulletin describing that the DiagnoticLink screen images for Chassis ECU programming have ben updated.
- Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement
- Service Bulletin for Equiflo Fuel System Breather Tube Inspection
- PowerNet Assessment Tool Repair Procedure
- Communication to assist the field with service vibration issues on DTNA vehicles
- Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
- Service Bulletin to provide instructions to replace Ignition Control System.The ICU3 is no longer...
- Service Bulletin to fix vehicles which may have an incorrect transverse torque rod tower bracket installed...
- Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized...
- Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
- Warranty Policy Letter to communicate Detroit Return Changes
- Warranty Information Letter updated to communicate warranty system updates.
- Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
- DTNA Special Tools Group has approved the use of Haweka Axis4000 aftermarket alignment system for use on...
- Updates to troubleshooting guides in Diagnostic Link with newest version
- The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17...
- HDEP GHG17 engines are not equipped with turbo wastegates
- Service Information Bulletin to updated the Fuel Injector Harness sections and relocated to Engine...
- Service Information Bulletin for Communication Loss with a Common Powertrain Controller (CPC) Module (CPC...
- Service Information Bulletin regarding PTO Dosing
- Service Information Bulletin for Symptom Diagnostics
- Warranty Information Letter
- Training Solution created by DTNA to provide guidance to customers when searching for service information...
- Service Bulletin provided to customers regarding ICU3 to ICU3S Replacement
- Sb54311 ICU Odometer Programming
- Sb54308 Chassis ECU Programming
- Fp00024 Cable-Tie Reference
- Ready Mix Bolts
- Reminder: Paper Service Bulletin Mailings Are Discontinued
- Customer Advisory Letter on Powertrain PDM and Main PDM Bracket Modification
- Ss 1034171
- Service Bulletin New "Natural Gas Vehicle Information" Webpage
- Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
- Service Information Bulletin
- Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
- Chassis ECU Programming
- Sb0006 Freightliner Courtesy Engineering Policy
- Warranty Bulletin for charge back exemtions
- Service Information Bulletin for Aftertreamtent Failure Guide
- DD13, DD15, DD16
- Release of DiagnosticLink® 8.08 Service Pack 2
- AirLiner Suspension Six-Piece Bolted Service Crossmember
- Operating Hours for the Customer Assistance Center
- Indel B Refrigerator Loose Circuit Board
- If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label
- Fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
- Sb54299 ICU3 to ICU3S Replacement Guidelines
- FL705 Bendix Rear Brake Calipers
- Sb00042 Flood Damage Repair GuidelinesB
- Sb2074 Kysor Fan Clutch Rocking Runout Inspection
- Sb2076 114SD Radiator Mounting, Update?EPA10
- Sb2081 Fan Shroud Fastener Retrofit, 114SD with DD13 Engine
- Sb2083 FluidXchange Tool and FittingsB
- Sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
- Sb2085 Isolated Radiator Mounting, Behr Mahle M80 FEPTO Radiator
- Sb4725 DAVCO Preheater Fault Code SA 33 SPN 6897 FMI 6B
- Sb9815 Paint Finish StandardsB
- Sb15020 Alternator Remote Sense WiringB
- Sb31034 Towing ProceduresB
- Sb49040 Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser ConnectionB
- Sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
- Sb54296 Fuel Level Sending Unit RetrofitB
- Sb60157 Roof Noise, M2 and 108SD 114SD Day CabsB
- Sb98020 Axalta Paint Finish CareB
- Fsb42072 Diagnostic de fuite d'air
- Fsb42073 Inspection d'absence de fuites d'air par les transporteurs concessionnaires
- Fsb49040 Conduite sous pression de fluide pour échappement diesel (DEF) débranchée au niveau du...
- Sb0006 Freightliner Courtesy Engineering PolicyB
- Sb0039 New Natural Gas Vehicle Information WebpageB
- Computer Hook-Up Standard Diagnostic Time Update
- 17CSA25
- 17CSA24
- OWL Enhancement Service Model Field
- 17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am
- Warranty Classroom Training in 2018
- 17-026
- 17TL25
- Roof Noise, M2 and 108SD 114SD Day Cabs
- Transport Dealer Air Leak Inspection
- Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
- Brake Check Valve
- 14CSA23 csc
- Alternator Remote Sense Wiring
- ICU3 to ICU3S Replacement Guidelines
- Towing Procedures
- Instrument Cluster Update
- Aftertreatment Systems
- FL740 Brake Check Valve
- Service Solution SS 1033180 BHM Fault Code SPN 524251 FMI 7
- Ss 1032974
- Fuel Level Sending Unit Retrofit
- Technical Publications Ordering
- Freightliner Action Bulletin FAB210 USB Charging Ports
- 16TS25
- 54-267
- SB0006 freightliner courtesy engineering policy
- 0612-16 spn 175 (MCM) (GHG17) and spn 175 (MCM); ( EPA07;EPA10;GHG14) diagnostic procedure
- 0611-16 spn 110 (MCM) (GHG17) and spn 110 (MCM); (EPA07;EPA10;GHG14) diagnostic procedure
- 0610-16 spn 111 (CPC) (GHG17) and spn 111 (CPC); (EPA07;EPA10;GHG14) diagnostic procedure
- 0609-16 spn 174 (MCM) (GHG17), spn 174 (MCM) (EPA07), spn 174; (MCM) (EPA10), and spn 174 diagnostic procedure
- New detroit diesel exhaust fluid awning standard repair time
- 0605-16 spn 625 (CPC)(GHG17) and spn 625 (CPC) (EPA10;GHG14) diagnostic procedure
- Bendix rear brake calipers
- 0601-16 spn 103 (MCM) (GHG17) and spn 103 (MCM); (EPA07;EPA10;GHG14) diagnostic procedure
- Clutch Release Bearing Grease Hose
- Been incorrectly shimmed at the factory, and may lean slightly to the right or left
- Inspection of the DD13 Turbocharger
- Spn 3226 (ACM) (EPA10;GHG14)
- SPN 2623 (CPC)(GHG17), SPN 2623 (CPC)(GHG14), and SPN 2623 (CPC)(EPA07 EPA10 GHG14)
- Fmi 2, 3, 4
- Fmi 2 cpc
- Fmi 3,4,5
- Fmi 3,4,5
- Fmi 3,4,5
- Fmi 3,4,5
- FMI 3 Engine Oil Pressure Sensor Circuit Failed High
- FMI 5 Oil Pressure Sensor Stuck High
- Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
- 15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
- Warranty Recognition Program Suspension
- 16-011
- 16TS7 Reman Diesel Particulate Filter Serial Number
- New Detroit Bearing Failure Analysis Standard Diagnostic Time
- 16-009R_OWL Enhancements
- FL676 Second Revised Bulletin
- Canadian Warranty Parts Return Address Change
- Haldex Life Seal Brake Chambers
- FL693 eaton fr transmission
- Rear Brake Calipers and Anchor Plates.
- Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
- _NewDetroitCoolantLineSRTs
- _Warranty Recognition Program
- 15-028
- Freightliner: information regarding the prevention of tire failures on auto haulers due to overloaded or...
- Sb54290 Guidelines for Repairing or Replacing an Electrical Harness
- Sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
- Sb83114 Approved Leak Detection Methods for Air Conditioning
- Sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
- 15-017
- 15-015
- 15-016-DLR
- Sb2083 FluidXchange Tool and Fittings
- 15CSA9
- 15CSA10
- 15CSA4
- 15TS10Rev DD Engine Platform Coolant Filter
- 14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
- 15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
- Sb3133 Step Clamps Are Not Reusable
- 15-010-DLR
- 15-009_Detroit_New_SDTs
- 15TL5 davco
- 15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
- Freightliner: truck parked and turned off for extended time will have ice expansion breaking DEF header,...
- Sb4937 2013 OBD GHG14, 6-Gallon DEF Header Suction Line
- Sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
- Sb60157 Roof Noise, M2 and 108SD/114SD Day Cabs
- ICI15-003-DLR FL676
- Sb9815 Paint Finish Standards
- Sb83155 Espar Service Information
- 14TL8 TorcUP? Non-Impacting Torque Tool.
- 14-036-DLR dtna & jad
- 14-038
- 14-039
- 14-040
- 14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
- 14-039_additional_SDTs New Detroit Standard Diagnostic Times
- 14-038_New_SRTs Additional Detroit Standard Repair Times.
- 14CSA22 dtna
- 14WO-9_Warranty_Access Detroit New User Warranty Access Request
- 14TL9 Special Tool Warranty Program.
- 14TL7 dd
- 14CSA21
- 14CSA20 EGR
- 1010-14 spn 2623 (CPC) (GHG14)
- 1009-14 spn 5016 (ACM) (GHG14)
- 1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
- 1007-14 spn 5016/fmi 3, 4 (ACM) (EPA10)
- 1006-14 spn 4374 (ACM) (GHG14)
- 1005-14
- 1003-14
- Freightliner: demand for natural gas is being responded to and a new resource was established where an...
- Freightliner: due to poor fuse retention for powernet distribution box (PNDB) modules on keep alive...
- Sb0039 New "Natural Gas Vehicles Information" Webpage
- Sb2080 Australian CST M1400 Isolated Radiator Retrofit
- Sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive
- Sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive
- 18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
- 18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
- 14-017R
- 14-029
- Freightliner Action Bulletin FAB160 Rock Guard
- Freightliner Action Bulletin FAB161 Watson and Chalin Suspension
- Freightliner Action Bulletin FAB162 Remote Stop Start
- 14TL2 dd
- 14TL5 ABS
- 14-028
- 14TS19 dd
- 14-027
- 14-026-DLR
- 715-14
- 14-022
- 14-023
- 14-024-DLR dtna & jad
- 714-14
- 713-14
- 712-14
- 20-75 - canceled
- 20-73 - canceled
- 54-285
- 54-218
- Detroit approved priming tools for the KM63 GEN2 fuel systemdetroit approved priming
- 14TS5 Replacing Damaged Aftertreatment Sensor Bosses
- 0228-14
- 14TS4 Valve and Liner Installation Tool Issue
- 13wo3rev2_final Actual Labor Hours on Detroit Claims
- 0224-14 spn 1590 fmi 9 - cpc
- 0219-14
- 0215-14
- 0210-14
- 0209-14
- 0202-14
- 54-281
- 0237-14
- 0233-14 spn 51 fmi 2
- 0229-14
- 0238-14
- 0239-14
- DEF Tank Coolant Valve O-Ring Kit
- Freightliner Action Bulletin FAB155 Polished stainless steel steps
- Freightliner Action Bulletin FAB152 Chassis Module Relocation
- Freightliner Action Bulletin FAB147 Vehicle Data Recorder and Seat Belt Display
- Freightliner Action Bulletin FAB149 heated seats
- Freightliner Action Bulletin FAB150 Bumper guide lights
- 54-280
- 35-30
- 33-28
- Sb3529 Axle Alignment Specifications
- Sb4932 DEF Gauge Reading Incorrectly
- 12-039-DLR owl
- 12-040-DLR
- 12-041-DLR
- 12-038-DLR
- Sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
- Sb3131 Huck-Spin 2 Changeover
- 12-022-DLR
- Sb4267 Brake Shimmy
VIN decoder
See the problems and recalls for an exact car
Buying a used 2015 Freightliner 108SD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history