2019 Freightliner 108SD technical service bulletins
257 technical service bulletins and manufacturer communications cover the 2019 Freightliner 108SD, including one warranty extension.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Warranty Information letter for Detroit Line or Line Seal, High Pressure Fuel Injector Standard Repair...
- Service Solution for Legacy M2 Bulkhead Module (BHM) Replacement and DiagnosticLink Issues
- Fleet Communications for NFD Lower Oil Plug Location
- Service Solution for Legacy M2 Bulkhead Module (BHM) Replacement and Diagnosticlink Issue
- CX Advocate for NOx conversion low faults
- CX Advocate for turbo oil drain cracking
- CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test...
- CX Advocate for DD13 Gen 5 engines operating at high altitude experience EGR slow response fault.
- CX Advocate for repairing seat occupancy sensor (TSB 91-016-FTL)
- Technical Service Bulletin for Detroit New Final Drive Standard Performance Forward Carrier Change to Top...
- CX Advocate for M2 and SD Vehicles Transfer Case Failures Due to Excessive Vehicle Speed (SS 3155-FTL)
- Technical Service Bulletin for Repairing Seat Occupancy Sensor for ISRI, SEARS and National Truck Seats
- Revised Technical Service Bulletin for Detroit New Final Drive Standard Performance Forward Carrier Change...
- Service Solution for M2 mirror wind noise
- Parts Bulletin for Powertrain Power Distribution Module (PTPDM) Kit Replacement
- Service Solution for M2 and SD Vehicles Transfer Case Failures Due to Excessive Vehicle Speed
- Service Solution for Detroit Successful Regen Reference for GHG17 DD Engines
- CX Advocate for MDEG Updates
- CX Advocate for NFD fill plugs
- Revised Technical Service Bulletin for Detroit New Final Drive Standard Performance Forward Carrier Change...
- CX Advocate for NOx conversion low faults
- CX Advocate communication for NOx conversion low faults
- CX Advocate communication for clutch bolts
- Technical Service Bulletin for New Final Drive Over Heat Diagnostic
- Field Service Campaign Owner Reminder Postcard small population
- Field Service Campaign Owner Reminder Postcard large population
- Customer letter regarding variable speed water pump.
- My Communications for SSI DEF Header Warranty Policy Extension for B6 7 Engines Model Years 2017-2021
- Extended Warranty Policy for certain Cummins B6.7 engines with SSI DEF headers for EPA and CARB Emissions...
- Revised Emissions Recall: Cummins DEF Sensor Shortage
- Important Campaign Information letter for FL974
- Emissions Recall: Cummins DEF Sensor Shortage
- Revised Field Service Campaign for Common Telematics Platform Software Update
- Field Service Campaign for Common Telematics Platform Software Update
- Important Campaign Information letter communicating that SF660 Field Service Campaign is Replaced by FL967.
- Revised Field Service Campaign for Drag Link Tapered Joint
- Field Service Campaign for Drag Link Tapered Joint
- Revised Freightliner Service Bulletin for Replacing an Auto Baud Rate Detecting Bulkhead Module with a...
- Freightliner Service Bulletin for DEF Connector Reinforcement Caps.
- Freightliner Service Bulletin for Insulated Automatic Transmission Cover Plate
- Tech Talk Discussion Elite Support
- Service Solution for M2,108SD, 114SD Coolant Level Sensor P/N 06-93316-002
- Updated Service Bulletin for upgrading BHM software for switch expansion module fault SPN 698 FMI 7.
- Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown
- Updated Freightliner Service Bulletin for Rerouting Wiring Harness to Reduce Chafing
- Updated Freightliner Service Bulletin for Espar Service Information
- Warranty Policy Letter for battery tags
- Revised Freightliner Service Bulletin for netized Fill Neck for Six-Gallon DEF Tanks
- Freightliner Service Bulletin for Programming Chassis Electronic Control Units (ECUs) With DiagnosticLink.
- Revised Technical Service Letter for Fault Code SPN 2629 FMI 10 on GHG21 936.917 DD8 Dual Stage Turbo with...
- Starting on November 23, 2020, DiagnosticLink 8.13 (Build 4527) was made available
- Warranty Information Letter for Detroit NOx Sensor Circuit Fault Codes
- Superseding Letter to an Important Campaign Information Letter to announce a reimbursement available to...
- Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance
- Warranty Information Letter for Detroit Resources: Exploded View DD Platform and DT12 Posters
- Service Solution for M2 108SD 114SD Coolant Level Sensor PN 06-93316-002
- Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring
- Freightliner Service Bulletin for Access to Front Brake Zerk Fittings
- Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing
- Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing
- Technical Service Letter for Fault Code SPN 2629 FMI 10 on GHG21 936.917 DD8 Dual Stage Turbo with MCM...
- Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide
- Revised Technical Service Letter for Detroit DT12 TCM GHG17 Only; Bootloader Update
- Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring
- Tech Talk discussion about power steering fluid.
- Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
- Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2. On Thursday, September 3,...
- Revised letter is to announce a reimbursement available to dealers for travel to a customer's location to...
- Service Bulletin for Powertrain PDM and Main PDM Bracket Modiï¬cation
- Warranty Information Letter informing that to ensure that DTNA policies and service network practices...
- Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance
- Important Campaign Information letter announcing Dealer Travel for Campaign Performance
- Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change
- Customer Service Announcement informing that Service Pack (SP) 1 for DiagnosticLinkÃÂÃÂÃÂî 8.12...
- OEM and distributor announcement for DiagnosticLink 8.12 (Build 4527) was made available
- Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility
- Service Bulletin for Front Lighting Ground Splice Pack Failure
- Customer Service Announcement for DiagnosticLink Software Update Reminder
- Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces
- Freightliner Service Bulletin for Rerouting Wiring Harness to Reduce Chafing
- Customer Service Announcement for Release of DiagnosticLink 8.12. On Wednesday, June 10, 2020,...
- Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change
- Warranty Information Letter for Warranty Training Online
- Warranty Policy Letter for Handling for Authorized Service Location Part Transfers
- Warranty Policy Letter for Chassis Progressive Damage Policy Change
- Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program
- Warranty Information Letter for Warranty Long Block Program Change
- Service Bulletin for Lengthening the Backup Light Harness
- Freightliner Service Bulletin for Front Axle Spacer Replacement
- Service Information Bulletin for Cylinder Block Porosity Repair for DD5 and DD8 egnines
- Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLink® 8.11 Standard and...
- Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy,...
- Freightliner Service Bulletin for vibration troubleshooting
- Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and...
- Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and...
- Service Solution for OBD16 M2, C2, 108SD & 114SD Allison transmission not shifting due to harness chafing.
- Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness
- Customer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs)...
- Important Campaign Information announcing that a revised bulletin for SF588 Medium Duty DD8 Engine Updates...
- DDC Emission Recall for GHG17 MDEG Platform DD8 â Software Reprogramming For California Inspection...
- Important Campaign Information Letter announcing that revisions to DDC bulletins D19M5 and D19R2 are...
- Service Bulletin on guidelines for repairing or replacing an electrical harness.
- Service Bulletin for A/C system receiver-drier replacement guidelines.
- Field Service Campaign for Medium Duty DD8 Engine Updates
- Warranty Information Letter announcing Detroit NOx Sensor Circuit Improvements for GHG17 After Treatment...
- Service Bulletin for M2 Surge Tank Shunt Line Clamp Replacement
- Service Bulletin for severe duty main PDM installation for vehicles operating in severe moisture and/or...
- Service Bulletin for upgrading BHM software for switch expansion module fault SPN 698 FMI 7.
- Service Bulletin revision to an earlier submission of SB54-308 for October 2019 (19MC2968)
- Service Bulletin about the powertrain PDM and Main PDM bracket being modified to reduce stress and...
- Service bulletin describing that the DiagnoticLink screen images for Chassis ECU programming have ben updated.
- Service Bulletin describing changes made to the Powernet Distribution Box (PNDB) for better fuse retention.
- Warranty Policy Letter- To assist customers and the service network regarding the Aftermarket Parts...
- DDC Emission Recall for GHG17 MDEG Platform DD8 Software Reprogramming For California Inspection and...
- Service Bulletin on Dealer Product Report
- Service Bulletin for Air Cleaner Modifications for Dusty Environments
- Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement
- Service Bulletin for Equiflo Fuel System Breather Tube Inspection
- Warranty Policy Change for Delivery-Related Changes: Electronic Proof of Delivery and Loose Component...
- PowerNet Assessment Tool Repair Procedure
- Communication to assist the field with service vibration issues on DTNA vehicles
- Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
- Document sent out by Service Systems Development to fix issue related to DD13 engines built between June 5...
- Service Systems Development provided document to service locations on price list reflects current charges...
- Service Bulletin to provide instructions to replace Ignition Control System.The ICU3 is no longer...
- Service Bulletin to fix vehicles which may have an incorrect transverse torque rod tower bracket installed...
- Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized...
- Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
- Warranty Policy Letter to communicate Detroit Return Changes
- Warranty Information Letter updated to communicate warranty system updates.
- Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
- DTNA Special Tools Group has approved the use of Haweka Axis4000 aftermarket alignment system for use on...
- Updates to troubleshooting guides in Diagnostic Link with newest version
- The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17...
- HDEP GHG17 engines are not equipped with turbo wastegates
- Service Information Bulletin to updated the Fuel Injector Harness sections and relocated to Engine...
- Service Information Bulletin for Communication Loss with a Common Powertrain Controller (CPC) Module (CPC...
- Service Information Bulletin regarding PTO Dosing
- Service Information Bulletin for Symptom Diagnostics
- Warranty Information Letter
- Training Solution created by DTNA to provide guidance to customers when searching for service information...
- Service Bulletin provided to customers regarding ICU3 to ICU3S Replacement
- Recall Bulletin- Brake Caliper Mounting Bolts
- Forward Chassis Wiring Harness
- Sb54311 ICU Odometer Programming
- Sb54308 Chassis ECU Programming
- Fp00024 Cable-Tie Reference
- Ready Mix Bolts
- Reminder: Paper Service Bulletin Mailings Are Discontinued
- Customer Advisory Letter on Powertrain PDM and Main PDM Bracket Modification
- Ss 1034171
- Brake Caliper Mounting Bolts
- Service Bulletin New "Natural Gas Vehicle Information" Webpage
- D18M7 ? Replaced by Recall D18R7 (FL802)
- FL783 Dealer Bulletin Brake Caliper Mounting Bolts
- FL783
- FL794 Recall Campaign- Brake Caliper Mounting Bolts
- FL794
- 30mm Air Disc Brake Caliper Bolt Torque Adapter DSNCHA018005
- Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
- Service Information Bulletin
- Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
- Chassis ECU Programming
- Sb0006 Freightliner Courtesy Engineering Policy
- FL794 Brake Caliper Mounting Bolts Dealer Bulletin
- Technical Bulletin fp54076 Commodity Harness Ordering
- Engine Replacement Procedures
- Service Bulletin 9815- Paint Finish Standards
- Recall FL783- Brake Caliper Mounting Bolts
- Important Warranty Information- Delivery-Related Claims: Low DEF, Low/No Fuel, Lost Prime, Gelled Fuel
- Important Warranty Information to Freightliner and Western Star dealers on Transporter Photo Requirement...
- FL772-Dealer bulletin for Brake Caliper Mounting Bolts recall
- Release of DiagnosticLink® 8.08 Service Pack 2
- Operating Hours for the Customer Assistance Center
- Indel B Refrigerator Loose Circuit Board
- If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label
- Fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
- Sb54299 ICU3 to ICU3S Replacement Guidelines
- Sb4725 DAVCO Preheater Fault Code SA 33 SPN 6897 FMI 6B
- Sb4937 2013 OBD GHG14, 6-Gallon DEF Header Suction Line Connection Broken by Ice PressureB
- Sb9815 Paint Finish StandardsB
- Sb15020 Alternator Remote Sense WiringB
- Sb31034 Towing ProceduresB
- Sb49038 Magnetized Fill Neck for Six-Gallon DEF TanksB
- Sb49039 Cleaning DEF Line ConnectorsB
- Sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
- Sb54296 Fuel Level Sending Unit RetrofitB
- Sb54298 GHG17 Heavy Duty Engine Platform Vehicle Dash Oil Pressure GaugeB
- Sb60157 Roof Noise, M2 and 108SD 114SD Day CabsB
- Sb98020 Axalta Paint Finish CareB
- FL758 Brake Mounting Caliper Bolts
- Freightliner Action Bulletin FAB248 FRONT FRAME EXTENSION TOW HOOKS 10.30.17
- Aftertreatment Systems
- Service Solution SS 1033180 BHM Fault Code SPN 524251 FMI 7
- Ss 1032974
- Fuel Level Sending Unit Retrofit
- Technical Publications Ordering
- Freightliner Action Bulletin FAB210 USB Charging Ports
- Been incorrectly shimmed at the factory, and may lean slightly to the right or left
- Inspection of the DD13 Turbocharger
- Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
- 15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
- Rear Brake Calipers and Anchor Plates.
- Sb54290 Guidelines for Repairing or Replacing an Electrical Harness
- Sb83114 Approved Leak Detection Methods for Air Conditioning
- 15-017
- 15-015
- 15-016-DLR
- 15CSA9
- 15CSA10
- 15CSA4
- 15TS10Rev DD Engine Platform Coolant Filter
- 14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
- 15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
- Sb3133 Step Clamps Are Not Reusable
- 15-010-DLR
- 15-009_Detroit_New_SDTs
- 15TL5 davco
- 15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
- Sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
- Sb9815 Paint Finish Standards
- Sb83155 Espar Service Information
- Freightliner Action Bulletin FAB160 Rock Guard
- Freightliner Action Bulletin FAB161 Watson and Chalin Suspension
- Freightliner Action Bulletin FAB162 Remote Stop Start
- 0237-14
- DEF Tank Coolant Valve O-Ring Kit
- Freightliner Action Bulletin FAB155 Polished stainless steel steps
- Freightliner Action Bulletin FAB152 Chassis Module Relocation
- Freightliner Action Bulletin FAB147 Vehicle Data Recorder and Seat Belt Display
- Freightliner Action Bulletin FAB149 heated seats
- Freightliner Action Bulletin FAB150 Bumper guide lights
- 54-280
- 35-30
- 33-28
- Sb3529 Axle Alignment Specifications
- Sb4932 DEF Gauge Reading Incorrectly
- Sb2074 Kysor Fan Clutch Rocking Runout Inspection
- Sb3131 Huck-Spin 2 Changeover
- 12-022-DLR
- Sb4267 Brake Shimmy
VIN decoder
See the problems and recalls for an exact car
Buying a used 2019 Freightliner 108SD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history