2018 Freightliner 122SD technical service bulletins
461 technical service bulletins and manufacturer communications cover the 2018 Freightliner 122SD, including one warranty extension.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Warranty Information letter for Detroit Line or Line Seal, High Pressure Fuel Injector Standard Repair...
- Fleet Communications for NFD Lower Oil Plug Location
- CX Advocate for NOx conversion low faults
- CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test...
- Technical Service Bulletin for Detroit New Final Drive Standard Performance Forward Carrier Change to Top...
- Revised Technical Service Bulletin for Detroit New Final Drive Standard Performance Forward Carrier Change...
- Service Solution for Detroit Successful Regen Reference for GHG17 DD Engines
- CX Advocate for NFD fill plugs
- Revised Technical Service Bulletin for Detroit New Final Drive Standard Performance Forward Carrier Change...
- Important Campaign Information letter for DDC D23M3
- CX Advocate for NOx conversion low faults
- CX Advocate communication for NOx conversion low faults
- Customer letter regarding variable speed water pump.
- Revised Emissions Recall: Cummins DEF Sensor Shortage
- Important Campaign Information letter for FL974
- Emissions Recall: Cummins DEF Sensor Shortage
- Freightliner Service Bulletin for DEF Connector Reinforcement Caps.
- Updated Service Bulletin for upgrading BHM software for switch expansion module fault SPN 698 FMI 7.
- Tech Talk discussion on Damaged low pressure pump and SPN code 520268 FMI 16 DD13 GHG17.
- Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown
- Detroit Technical Service Letter for DD13 Cylinder Head and Cylinder Head Gasket Change.
- Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown
- Warranty Policy Letter for battery tags
- Revised Freightliner Service Bulletin for netized Fill Neck for Six-Gallon DEF Tanks
- Revised Customer Advisory Letter for Cascadia, New Cascadia, and 122SD Vehicles with Cracked Fifth Wheel...
- Freightliner Service Bulletin for Programming Chassis Electronic Control Units (ECUs) With DiagnosticLink.
- Customer Advisory Letter for Cascadia, New Cascadia, and 122SD Vehicles with Cracked Fifth Wheel Angles
- Starting on November 23, 2020, DiagnosticLink 8.13 (Build 4527) was made available
- Warranty Information Letter for Detroit NOx Sensor Circuit Fault Codes
- Superseding Letter to an Important Campaign Information Letter to announce a reimbursement available to...
- Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance
- Warranty Information Letter for Detroit Resources: Exploded View DD Platform and DT12 Posters
- Warranty Information Letter for Detroit Bearing Failures
- Technical Service Letter for GHG17 1-Box Inlet and Outlet Exhaust Clamps
- Technical Service Letter for Detroit Bearing Failures
- Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring
- Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing
- Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing
- Technical Service Letter for SPN 3711 FMI 31 on GHG17 DD15 Trucks.
- Special Publication letter for Two-Filter Fuel System KM59 GEN1 DD15 DD16 Severe Duty High Pressure Fuel...
- Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide
- Revised Technical Service Letter for Detroit DT12 TCM GHG17 Only; Bootloader Update
- DDC Technical Service Letter for GHG17 DD Platform Heavy Duty Oil Pan Drain Plug Inserts
- Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring
- Detroit Diesel Special Publication informing about Heavy Duty Friction Style Belt Tensioner Kit. This...
- Revised Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change
- Tech Talk discussion about power steering fluid.
- Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
- Detroit Diesel Field Service Campaign for Engine Emission Label Replacement
- Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2. On Thursday, September 3,...
- Revised letter is to announce a reimbursement available to dealers for travel to a customer's location to...
- Warranty Information Letter informing that to ensure that DTNA policies and service network practices...
- Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance
- Important Campaign Information letter announcing Dealer Travel for Campaign Performance
- Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change
- Customer Service Announcement informing that Service Pack (SP) 1 for DiagnosticLinkÃÂÃÂÃÂî 8.12...
- OEM and distributor announcement for DiagnosticLink 8.12 (Build 4527) was made available
- Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility
- Customer Service Announcement for DiagnosticLink Software Update Reminder
- Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces
- Revised Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change
- Customer Service Announcement for Release of DiagnosticLink 8.12. On Wednesday, June 10, 2020,...
- Technical Service Letter for DD Heavy Duty Platform Belt Tensioner Change
- Warranty Information Letter for Warranty Training Online
- Warranty Policy Letter for Handling for Authorized Service Location Part Transfers
- Warranty Policy Letter for Chassis Progressive Damage Policy Change
- Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program
- Warranty Information Letter for Warranty Long Block Program Change
- Service Bulletin for Lengthening the Backup Light Harness
- Freightliner Service Bulletin for Front Axle Spacer Replacement
- Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLink® 8.11 Standard and...
- Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy,...
- Freightliner Service Bulletin for Midship Bearing Replacement for built vehicles with driveshafts SPL140,...
- Freightliner Service Bulletin for vibration troubleshooting
- Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and...
- Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and...
- Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness
- Customer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs)...
- Service Bulletin on guidelines for repairing or replacing an electrical harness.
- Service Bulletin for A/C system receiver-drier replacement guidelines.
- Warranty Information Letter announcing Detroit NOx Sensor Circuit Improvements for GHG17 After Treatment...
- Service Bulletin revision for window regular refit
- Service Bulletin for upgrading BHM software for switch expansion module fault SPN 698 FMI 7.
- Service Bulletin describing changes made to the Powernet Distribution Box (PNDB) for better fuse retention.
- Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner...
- Service Bulletin for Hendrickson HaulMaax Rear Suspension Transverse Torque Rod Tower Bracket Replacement
- Service Bulletin for Equiflo Fuel System Breather Tube Inspection
- Service Bulletin for Window Regulator Retrofit
- Tool Letter for ICC5 Programming Cable
- PowerNet Assessment Tool Repair Procedure
- Communication to assist the field with service vibration issues on DTNA vehicles
- Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
- Service Systems Development provided document to service locations on price list reflects current charges...
- Service Bulletin to fix vehicles which may have an incorrect transverse torque rod tower bracket installed...
- Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized...
- Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
- Warranty Policy Letter to communicate Detroit Return Changes
- Warranty Information Letter updated to communicate warranty system updates.
- This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting...
- Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
- Service Information Bulletin was released, to add new procedures to address diagnostics near the high...
- DTNA Special Tools Group has approved the use of Haweka Axis4000 aftermarket alignment system for use on...
- Updates to troubleshooting guides in Diagnostic Link with newest version
- The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17...
- HDEP GHG17 engines are not equipped with turbo wastegates
- Service Bulletin to testing of EGR Cooler Water Manifold Assembly in DD13 engines.
- Warranty Information Letter
- Training Solution created by DTNA to provide guidance to customers when searching for service information...
- Forward Chassis Wiring Harness
- Steering Intermediate Shaft Replacement
- Sb54311 ICU Odometer Programming
- Reminder: Paper Service Bulletin Mailings Are Discontinued
- Sb54268 122SD and Coronado Virtual Technician Retrofit
- Ss 1034171
- Brake Caliper Mounting Bolts
- D18M7 ? Replaced by Recall D18R7 (FL802)
- FL783 Dealer Bulletin Brake Caliper Mounting Bolts
- FL783
- Chassis ECU Programming
- Sb0006 Freightliner Courtesy Engineering Policy
- Field Service Campaign-D18M2 ? REVISION 1 GHG17 Detroit? DD13® Software Reprogramming and Emission Label...
- Letter to customer on Coverage Extension GHG17 After Treatment
- 18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
- Field Service Campaign D18M2 GHG17 GHG17 Detroit? DD13® Software Reprogramming and Emission Label...
- Field Service Campaign-D18M2
- Field Service Campaign D18M2 GHG17 GHG17 Detroit DD13® Software Reprogramming and Emission Label...
- Engine Replacement Procedures
- Service Bulletin 9815- Paint Finish Standards
- Recall FL783- Brake Caliper Mounting Bolts
- Emission Recall D18R5 GHG17 DD Platform Model Years 2016-2018 Software Reprogramming For California...
- Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
- Service Information Bulletin for Aftertreamtent Failure Guide
- DD13, DD15, DD16
- Important Warranty Information on AutoMeter BCT-460DTNA Powernet Assessment Tool: Warranty Requirement and...
- Release of DiagnosticLink® 8.08 Service Pack 2
- Service Information Bulletin
- Ts 1033699: DT12
- AirLiner Suspension Six-Piece Bolted Service Crossmember
- Operating Hours for the Customer Assistance Center
- Ss 1033638
- 0508-18
- 0505-18 spn 3563 hdep
- 0504-18
- 0503-18
- 0502-18
- If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label
- With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension...
- The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing...
- 18SP734 18SP734?GHG14 DD15AT Turbocharger
- 0501-18
- Aeo18M4 Field Service Campaign D18M4
- MY18M4-Bulletin-02-MAY-2018 Field Service Campaign D18M4
- SS1033446
- Fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
- MY18M4_Bulletin_02-MAY-2018 Field Service Campaign D18M4
- Vehicles with Meritor drivelines bene from a softer durometer center bearing support
- Ss 1033423 : J-1939
- 0405-18
- 0404-18 GHG17 DD8
- 0402-18 spn 625 (CPC) (GHG14)
- 0401-18 spn 1231 (MCM) (EPA10 GHG14)
- 0312-18
- 0311-18
- MY18M1a_05-MAR-2018_Vocational
- Aeo18M1 GHG14 Heavy Duty Engine Platform Vocational Application Programming
- MY18M1a 05-MAR-2018 Vocational
- Sb00042 Flood Damage Repair GuidelinesB
- Sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
- Sb31034 Towing ProceduresB
- Sb42072 Air Leak DiagnosticsB
- Sb49040 Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser ConnectionB
- Sb54278 Powernet Troubleshooting Guide Batteries, Path, Alternator, and Starter
- Sb54296 Fuel Level Sending Unit RetrofitB
- Sb54298 GHG17 Heavy Duty Engine Platform Vehicle Dash Oil Pressure GaugeB
- Sb54300 ICU4Me Low Air Pressure Warning ChangeB
- Sb98020 Axalta Paint Finish CareB
- Ssb42072 Diagnóstico de fugas de aire
- Fp46907 Steering Intermediate Shaft ReplacementB
- Fsb42072 Diagnostic de fuite d'air
- Fsb49040 Conduite sous pression de fluide pour échappement diesel (DEF) débranchée au niveau du...
- Sb0006 Freightliner Courtesy Engineering PolicyB
- Computer Hook-Up Standard Diagnostic Time Update
- 17CSA25
- 17CSA24
- OWL Enhancement Service Model Field
- 17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am
- Warranty Classroom Training in 2018
- 17-026
- 17TL25
- Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
- Ss 1033219
- Exhaust and Exhaust Gas Recirculation
- EPA10, GHG14 and GHG17 Diesel Particulate Filters
- Spn 157 (MCM) (GHG17)
- Symptom Diagnostics
- 14CSA23 csc
- Service Solution SS 1033219 Eaton Transmission Fault Code 25 Persi...
- Towing Procedures
- ICU4Me Low Air Pressure Warning Change
- FL742 Freightliner and Western Star Tow Hooks
- Aftertreatment Systems
- 17CSA16
- 17TS12Rev1 GHG17 Heavy Duty Engine Platform 1-BOX? Aftertreatment System ATS Wire Harness
- 0806-17 spn 101 (MCM)(GHG17)
- 0803-17 spn 411 (MCM) (GHG17)
- Sb54298 GHG17 Heavy Duty Engine Platform Vehicle Dash Oil
- Ss 1032974
- Spn 168 (CPC3) (GHG17)
- Fuel Level Sending Unit Retrofit
- Technical Publications Ordering
- Spn 3226 (ACM) (GHG17)
- Diagnostic tests
- Spn 96 (MCM) (GHG17)
- Spn 712 (CPC) (GHG17)
- Fuel System Integrity Check Routine
- Heavy Duty Engine Wastegate Repair Kit DKI470E16019
- Detroit? DT12? Transmission Proper Moving Procedure
- Vehicle Interface Module
- Spn 3556 fmi 0, 1, 18
- Spn 5741 (ACM) (GHG17)
- Symptom Diagnostics
- Detroit? DT12? Split Rod Bushing Repair
- Spn 1663 (CPC) (EPA07 10 GHG14 GHG17)
- Fmi 2
- GHG17 Heavy Duty- Exhaust & EGR
- Spn 521221 (TCM)
- Spn 521222 (TCM)
- Spn 677 fmi 2
- Spn 1322 (MCM) (GHG17)
- Spn 4765 fmi 0
- Symptom Diagnostics
- (ACM) (GHG17)
- (MCM) (GHG17)
- (MCM)(GHG17)
- GHG14 Intake Manifold Pressure Too Low
- (MCM) GHG17
- Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines
- Diagnostic Tests
- Contaminated Fluids Diagnostic Tests
- (CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
- GHG17 Heavy Duty Engine Platform Vehicle Dash Oil Pressure Gauge
- 0301-17
- (CPC) (GHG17)
- (CPC)(GHG17)
- 0208-17 spn 412 (MCM) (GHG17)
- 0206-17_ spn 521049 (MCM) (GHG17)
- 0205-17 spn 521052 (MCM) (GHG17)
- 0204-17 spn 521050 (MCM) (GHG17)
- 0203-17 spn 5741 fmi 13 (GHG17) (MCM)
- Replacing or Upgrading Airliner 40K Transverse Torque Rods
- 18SP733 GHG17
- 0131-17 spn 521054 (CPC3) (GHG17)
- 0132-17 spn 521005 (CPC3) (GHG17)
- 0133-17 spn 625 (CPC) (GHG17)
- 0134-17
- 0135-17
- 0136-17 GHG17 DD5
- 0137-17 spn 3361 fmi 5 (ACM) (GHG17) spn 3361 fmi 5 (ACM) (GHG14)
- 0138-17 GHG17 DD5
- 0139-17
- 0140-17
- 0130-17 spn 520211 (IPPC) (GHG14) spn 520211 (IPPC) (GHG17)
- 0129-17 spn 102 (MCM) (GHG17)
- 0127-17 spn 1077 fmi 14 (GHG14) (GHG17) (MCM)
- 0126-17 spn 520295 (MCM) (GHG17)
- 0125-17 spn 4817 (MCM) (GHG17)
- 0124-17 spn 3720 fmi 14 - (MCM) (GHG17)
- 0123-17 spn 1483 (CPC3) (GHG17)
- 0122-17 spn 521058 (CPC3) (GHG17)
- 0121-17 spn 521050 (CPC3) (GHG17)
- 0120-17
- 0119-17 spn 3217 (MCM) (GHG17)
- 0118-17
- 0117-17 spn 5928 (MCM) (GHG17) - EGR h
- 0116-17 spn 4752 (MCM) (GHG17) - EGR
- 0111-17 spn 1077 (MCM)(GHG17)
- 0107-17
- 0106-17 SPN 520296 (MCM) (GHG14) and SPN 520296 (MCM) (GHG17)
- Retrofitting Trelleborg Engine Mounts for EPA07 and Newer
- Been incorrectly shimmed at the factory, and may lean slightly to the right or left
- Inspection of the DD13 Turbocharger
- Fmi 2, 3, 4
- Fmi 3,4,5
- Fmi 3,4,5
- Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
- 15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
- Warranty Recognition Program Suspension
- 16-011
- 16TS7 Reman Diesel Particulate Filter Serial Number
- New Detroit Bearing Failure Analysis Standard Diagnostic Time
- 16-009R_OWL Enhancements
- Canadian Warranty Parts Return Address Change
- 15TL21 GHG17
- Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
- _NewDetroitCoolantLineSRTs
- _Warranty Recognition Program
- 15-028
- 901-15
- Sb54290 Guidelines for Repairing or Replacing an Electrical Harness
- Sb83114 Approved Leak Detection Methods for Air Conditioning
- 15-017
- 15-015
- 15-016-DLR
- 15CSA9
- 15CSA10
- 15CSA4
- 15TS10Rev DD Engine Platform Coolant Filter
- 14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
- 15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
- Sb3133 Step Clamps Are Not Reusable
- 15-010-DLR
- 15-009_Detroit_New_SDTs
- 15TL5 davco
- 15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
- Sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
- Sb9815 Paint Finish Standards
- 14TL8 TorcUP? Non-Impacting Torque Tool.
- 14-036-DLR dtna & jad
- 14-038
- 14-039
- 14-040
- 14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
- 14-039_additional_SDTs New Detroit Standard Diagnostic Times
- 14-038_New_SRTs Additional Detroit Standard Repair Times.
- 14CSA22 dtna
- 14WO-9_Warranty_Access Detroit New User Warranty Access Request
- 14TL9 Special Tool Warranty Program.
- 14TS30
- 14TL7 dd
- 14CSA21
- 14CSA20 EGR
- 1010-14 spn 2623 (CPC) (GHG14)
- 1009-14 spn 5016 (ACM) (GHG14)
- 1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
- 14TS28 dd
- 1007-14 spn 5016/fmi 3, 4 (ACM) (EPA10)
- 1006-14 spn 4374 (ACM) (GHG14)
- 1005-14
- 1003-14
- Sb2080 Australian CST M1400 Isolated Radiator Retrofit
- 18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
- 18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
- 14TS21 hdep
- 14-017R
- 810-14
- 809-14 fmi 3, 4, 5, 31
- 14TS20 GHG14
- 54-268
- Freightliner Action Bulletin FAB161 Watson and Chalin Suspension
- 14TL2 dd
- 14TL5 ABS
- 14-028
- 14TS19 dd
- 14-027
- 14-026-DLR
- 715-14
- 14-022
- 14-023
- 14-024-DLR dtna & jad
- 714-14
- 713-14
- 712-14
- 20-75 - canceled
- 20-73 - canceled
- 54-285
- 54-215 - ICU4M
- 14TS5 Replacing Damaged Aftertreatment Sensor Bosses
- 0228-14
- 14TS4 Valve and Liner Installation Tool Issue
- 13wo3rev2_final Actual Labor Hours on Detroit Claims
- 0224-14 spn 1590 fmi 9 - cpc
- 0219-14
- 0215-14
- 0210-14
- 0209-14
- 0202-14
- 72-39
- 0237-14
- 0233-14 spn 51 fmi 2
- 0229-14
- 0238-14
- 0239-14
- DEF Tank Coolant Valve O-Ring Kit
- 601-13
- 532-13
- 530-13
- 529-13
- 525-13 spn 2791-FMI 7 ? all years
- 12-039-DLR owl
- 12-040-DLR
- 12-041-DLR
- 12-038-DLR
- 12-022-DLR
VIN decoder
See the problems and recalls for an exact car
Buying a used 2018 Freightliner 122SD?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history