2016 Freightliner Cascadia technical service bulletins
953 technical service bulletins and manufacturer communications cover the 2016 Freightliner Cascadia, including one warranty extension.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- Warranty Information letter for Detroit Line or Line Seal, High Pressure Fuel Injector Standard Repair...
- Fleet Communications for Power Steering Resevoir
- Fleet Communications for Power Steering Reservoir Fill Cap Venting
- Technical Service Bulletin for Load Dump Switch Inspection and Installation on Dometic Refrigerators
- CX Advocate for NOx conversion low faults
- CX Advocate for turbo oil drain cracking
- CX Advocate for CARB tightening the Readiness Criteria applied to On-Board Diagnostic (OBD) test...
- CX Advocate for DD13 Gen 5 engines operating at high altitude experience EGR slow response fault.
- CX Advocate for GATS2.4 being expanding to DD15
- Service Solution for Power Steering Reservoir Fill Cap Venting
- Important Campaign Information letter for DDC D24R4
- Important Campaign Information letter for DDC D24R4
- Emission Recall for DETROIT DD13 and DD16 ACM Software Reprogramming
- Detroit Emission recall for GHG14 DETROIT DD16 Software Reprogramming
- Important Campaign Information letter for DDC D23M3
- CX Advocate for clean idle label placement
- CX Advocate for NOx conversion low faults
- CX Advocate for Oil Suction manifolds
- CX Advocate communication for NOx conversion low faults
- Revised Emissions Recall: Cummins DEF Sensor Shortage
- Important Campaign Information letter for FL974
- Emissions Recall: Cummins DEF Sensor Shortage
- Revised Freightliner Service Bulletin for Converting CTP1 to CTP2. Description of Revisions:
- Freightliner Service Bulletin for Converting CTP1 to CTP2.
- Service Solution for DPF Harness Rub-Chafe onTrans-Wire Braided Air Hose.
- Service Solution for SSAM Fault 520197/31
- Important Campaign Information Letter for DDC D21M1 Termination Date Extended
- Revised Freightliner Service Bulletin for ParkSmart Eberspaecher Auxiliary Heater Service
- Freightliner Service Bulletin for DEF Connector Reinforcement Caps.
- End of Production for the Freightliner P3 Cascadia Sales Cabs
- TechTalk Discussion Reprogramming a used CPC4 without having the truck
- Tech Talk Discussion RAC Failure (Roll Advisor and Control System)
- Tech Talk Discussion Integrated Predictive Powertrain Control IPPC01T I...
- Tech Talk Discussion CPC Failure
- Tech Talk Discussion CPC Failure
- Tech Talk discussion on OnGuard Fault Code 516499_12 when park brake released.
- Tech Talk discussion on SPN 91 FMI 8, SPN 111 FMI 3, RAC System Failure HSA and Check Engine (amber) ON.
- Tech Talk discussion on Needing regen in same area every time.
- Tech Talk discussion on Wont crank.
- Service Solution for FTL DT12 Trans Control Harness Chaffing
- Tech Talk discussion on replacement surge tanks not relieving pressure.
- Warranty Information letter announcing that DTNA is increasing the Standard Diagnostic Times (SDTs) shown
- Detroit Technical Service Letter for DD13 Cylinder Head and Cylinder Head Gasket Change.
- Detroit Field Service Campaign for DT12 Transmission Drive Shaft Cover Plug Reseal
- Tech Talk discussion on fault codes SPN-5246 FMI-16, SPN-5246 FMI-15, SPN-4364 FMI-18, SPN-3364 FMI-2.
- Tech Talk discussion on being Stuck in Emergency Power Supply mode.
- Warranty Information Letter announcing DTNA is adjusting the Standard Repair Times (SRTs) shown
- Tech Talk discussion on EGR fail's to learn.
- Updated Freightliner Service Bulletin for Espar Service Information
- Warranty Policy Letter for battery tags
- DTNA received a field notification on multiple units regarding diagnostic fault codes that were found to...
- Freightliner Service Bulletin for Programming Chassis Electronic Control Units (ECUs) With DiagnosticLink.
- Starting on November 23, 2020, DiagnosticLink 8.13 (Build 4527) was made available
- Warranty Information Letter for Detroit NOx Sensor Circuit Fault Codes
- Superseding Letter to an Important Campaign Information Letter to announce a reimbursement available to...
- Service Solution for P3
- Revision for Field Service Campaign for pre-series Cascadia and New Cascadia Emission Label replacement
- Important Campaign Information Letter announcing that a revision for Detroit Diesel Field Service Campaign...
- Revised Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance
- Tech Talk discussion on lack of communication with ACM and MCM.
- Tech Talk discussion on DD13 GHG 17 long block dressed as a GHG14
- Warranty Information Letter for Detroit Resources: Exploded View DD Platform and DT12 Posters
- Warranty Information Letter for Detroit Bearing Failures
- Technical Service Letter for GHG17 1-Box Inlet and Outlet Exhaust Clamps
- Technical Service Letter for Detroit Bearing Failures
- Warranty Information Letter for Detroit New Service Replacement Engine SRT Update
- Tech Talk continued discussion on upper engine knock after head replacement.
- Tech Talk discussion on WILL NOT GO INTO DRIVE FROM NEUTRAL, WILL GO INTO DRIVE FROM REVERSE.
- Tech talk discussion on location of ambient air temperature location.
- Tech Talk discussion on vehicle WILL NOT GO INTO DRIVE FROM NEUTRAL, WILL GO INTO DRIVE FROM REVERSE.
- Revised Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring
- Revised Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing
- Warranty Policy Letter for Alliance/Mascot Aftermarket Warranty and Claim Filing
- Technical Service Letter for SPN 3711 FMI 31 on GHG17 DD15 Trucks.
- Tech Talk discussion on Upper engine knock after head replacement.
- Revised Service Bulletin for DT12 PTO Upfit
- Special Publication letter for Two-Filter Fuel System KM59 GEN1 DD15 DD16 Severe Duty High Pressure Fuel...
- Tech Talk discussion on DD13 HARDSTART with Starter faults 677-3.
- Tech Talk discussion on dt12 not going to reverse.
- Tech Talk discussion on 2016 Freightliner Blower Motor INOP.
- Updated Freightliner Service Bulletin for Powernet Troubleshooting Guide
- Tech Talk discussion on a Cranking issue
- DDC Technical Service Letter for GHG17 DD Platform Heavy Duty Oil Pan Drain Plug Inserts
- Freightliner Service Bulletin for Axle Flange Gasket Replaced with O-Ring
- Tech Talk discussion for wiring a solenoid and switch for a 2016 Cascadia with PTO on a DT12 transmission.
- Tech Talk discussion on FYI BELT TENSIONER UPDATE.
- Tech Talk discussion on DD ENGINES FAN RUNNING MORE IN THE COLD.
- Joyson Safety Systems letter informing DTNA about Hikone Webbing Investigation
- Tech Talk Discussion for DD15 GHG14 EGR linkage hex nuts.
- Tech Talk discussion about power steering fluid.
- Tech Talk discussion on repair verification for codes like 'low air flow' when a trailer is not available.
- Tech Talk discussion on A/C on 2016 Cascadia.
- Tech Talk discussion on slipping clutch and shifting into neutral while driving.
- Detroit Diesel Field Service Campaign for Engine Emission Label Replacement
- Customer Service Announcement for Release of DiagnosticLink 8.12 Service Pack 2. On Thursday, September 3,...
- Service Solution for P3
- Updated Service Bulletin for DT12 Transmission Cooler Retrofit
- Detroit Diesel Field Service Campaign for DETROIT Reman Built HDEP Engines
- Revised letter is to announce a reimbursement available to dealers for travel to a customer's location to...
- Warranty Information Letter informing that to ensure that DTNA policies and service network practices...
- Warranty Information Letter for OWL and Warranty Manual Improvement: Sublets and Travel Time/Distance
- Important Campaign Information letter announcing Dealer Travel for Campaign Performance
- Freightliner Service Bulletin for Meritor Steer Axle Drum Brake Squeal
- Freightliner Service Bulletin for Non-Airliner Rear Suspension Crossmember Fastener Change
- Customer Service Announcement informing that Service Pack (SP) 1 for DiagnosticLinkÃÂÃÂÃÂî 8.12...
- OEM and distributor announcement for DiagnosticLink 8.12 (Build 4527) was made available
- Technical Service Letter for EPA10, GHG14, GHG17 Diesel Particulate Filter (DPF) Compatibility
- Service Bulletin for Reflective Tape Installation
- Customer Service Announcement for DiagnosticLink Software Update Reminder
- Service Bulletin for Guidelines for Cleaning and Disinfecting Cab Surfaces
- Service Bulletin for Chassis Side-Fairing Kickplate Magnet Replacement
- Customer Service Announcement for Release of DiagnosticLink 8.12. On Wednesday, June 10, 2020,...
- Service Bulletin for Marker Light Gasket Leaks, Cascadia
- Warranty Information Letter for Warranty Training Online
- Warranty Policy Letter for Handling for Authorized Service Location Part Transfers
- Warranty Policy Letter for Chassis Progressive Damage Policy Change
- Warranty Policy Letter for Handling Change: Over the Counter Aftermarket Parts Replacement Program
- Service Bulletin for Draining Water Trapped in the Upper A-Pillar
- Warranty Information Letter for Warranty Long Block Program Change
- Service Bulletin for Lengthening the Backup Light Harness
- Service Bulletin for Replacing Windshield Gasket
- Freightliner Service Bulletin for Front Axle Spacer Replacement
- Customer Service Announcement saying that Service Pack (SP) 3 for DiagnosticLink® 8.11 Standard and...
- Warranty Policy Letter explaining the Warranty Department is aligning with the frame rail repair policy,...
- Freightliner Service Bulletin for vibration troubleshooting
- Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and...
- Open recall and Field service Campaigns report send out to Dealers, General Managers, Service managers and...
- Customer Advisory Letter that an inspection to determine if the high current breaker has been bypassed.
- Service Bulletin for Guidelines for Repairing or Replacing an Electrical Harness
- Revision for Field Service Campaign for pre-series Cascadia and New Cascadia Emission Label replacement
- Important Campaign Information Letter announcing that a revision for Detroit Diesel Field Service Campaign...
- Customer Service Announcement for a policy change regarding Detroit Service Information Bulletins (SIBs)...
- Service Solution for Meritor Wabco OnGuard Radar Service Alignment
- Service Bulletin on guidelines for repairing or replacing an electrical harness.
- Service Bulletin for A/C system receiver-drier replacement guidelines.
- Warranty Information Letter announcing Detroit NOx Sensor Circuit Improvements for GHG17 After Treatment...
- Field Service Campaign for pre-series Cascadia and New Cascadia Emission Label Replacement
- Service Solution for Legacy Cascadia, where trailer turn signals or 4-way flashers used in applications...
- Technical Service Letter for GHG17 Heavy Duty Engine Platform 1-BOX Aftertreatment System (ATS) Wire...
- Service Bulletin for Water Leak at the Top of a Cab Door, Cascadia Day Cab with FE13 Roof Fairing
- Service Bulletin for Cascadia Cabin CAN ECU Compatibility
- Service Bulletin revision to an earlier submission of SB54-308 for October 2019 (19MC2968)
- Service Bulletin describing Cascadia cabin CAN ECU compatibility
- Service Solution to fix switch malfunction
- Service bulletin describing that the DiagnoticLink screen images for Chassis ECU programming have ben updated.
- Field Service Campaign for GHG17 Detroit DD16 software reprogramming.
- Technical Service Letter communicating that information on DD Heavy Duty Platform Belt and Belt Tensioner...
- Tool Letter for updating Cascadia and Western Star 5700 oil-to-air coolers
- Service Solution to fix radio issues
- Service Solution to fix coolant level wiring damage.
- Service Bulletin for DT12 Transmission Cooler Retrofit
- Service Bulletin for DT12 PTO Upfit
- Service Bulletin for Equiflo Fuel System Breather Tube Inspection
- Service Bulletin for Windshield Wiper Repair and Programming on Model Year 2015 Vehicles with 125-inch...
- Tool Letter for ICC5 Programming Cable
- PowerNet Assessment Tool Repair Procedure
- Communication to assist the field with service vibration issues on DTNA vehicles
- Tool Letter for New Tool Kit Replacement Components DDE DKICHA018006 Components 1, 2 and 3
- Tool Letter for DT12 Seal Protector Sleeve
- Tool Letter for New Final Drive Pinion Cover Install Tool
- Tool Letter for New Final Drive Driver Controlled Differential Lock Spring Compressor
- Customer Service Announcement Letter Revision for Dealers/Distributors Accessing DDEC Backdoor Passwords
- Service Solution to fix incorrect ICUC Fuel Economy Reading
- Technical Service Letter for Incorrect ICUC Fuel Economy Reading for New Cascadia units built or updated...
- Field Service Campaign for Remanufactured Detroit DT12 Transmissions
- Service Systems Development provided document to service locations on price list reflects current charges...
- Service Bulletin to fix wiper motor issue
- Service Bulletin to fix issue related to fuel gauge
- Service Bulletin to replace the white drip shield and secondary SAM cover on the SAM Cabin, with a new...
- Service Bulletin to provide instructions to replace Ignition Control System.The ICU3 is no longer...
- Service Bulletin to address wiper issue
- Warranty Information Letter to announce addition of Thomas Built Bus as a brand with an Authorized...
- Warranty Policy Letter to communicate remarketing handling cap for Detroit DT12 Transmission.
- Warranty Policy Letter to communicate Detroit Return Changes
- Warranty Information Letter updated to communicate warranty system updates.
- This service kit includes all necessary parts to replace the high pressure fuel rail feed lines, mounting...
- Warranty Information Letter sent to customers regarding new refrigerator supplier for returning parts.
- Service Information Bulletin was released, to add new procedures to address diagnostics near the high...
- DTNA Special Tools Group has approved the use of Haweka Axis4000 aftermarket alignment system for use on...
- Updates to troubleshooting guides in Diagnostic Link with newest version
- The modified parked regeneration strategy has been standard on GHG17 units since the start of GHG17...
- HDEP GHG17 engines are not equipped with turbo wastegates
- Service Bulletin to testing of EGR Cooler Water Manifold Assembly in DD13 engines.
- Service Information Bulletin to updated the Fuel Injector Harness sections and relocated to Engine...
- Service Information Bulletin for Communication Loss with a Common Powertrain Controller (CPC) Module (CPC...
- Service Information Bulletin regarding PTO Dosing
- Service Information Bulletin for Symptom Diagnostics
- Warranty Information Letter
- Service Solution to customers regarding Steering wheel switches inoperative, AM/FM radio reception...
- Training Solution created by DTNA to provide guidance to customers when searching for service information...
- Service Bulletin provided to customers regarding ICU3 to ICU3S Replacement
- Service Bulletin sent out customers describing procedure is to replace the white drip shield and secondary...
- Marker Light Gasket Leaks, New Cascadia
- Marker Light Gasket Leaks, Cascadia
- Service Solution: 1034298
- Enabling the Radio Mute Feature for Lane Departure Warning on New Cascadia Vehicles
- Replacing Halogen Headlamps on New Cascadia Vehicles
- Service Solution 1034226 New Cascadia Adding Daytime Running Lights (DRL) Or Adding Low Speed DRL Interrupt
- Marker Light Leaks, New Cascadia
- Accent / Park Light Function Disable Accent / Park Light Function Disable
- Ss 1034231
- Installation of Vortex Generators
- SS1034234
- Hendrickson 5 Inch Drop Axle Tie Rods
- Cascadia ICUC Bulb Check Function
- Revised Bulletin
- Reactivation and revision
- Rear PTO Pump Support CA
- Ss 1034220 ssi
- Sb54311 ICU Odometer Programming
- Steer Axle Brake Chatter
- Sb42077 Steer Axle Brake Chatter
- Sb54308 Chassis ECU Programming
- Sb60165 Exhauster Splash Covers Do Not Fully Latch
- Fp00024 Cable-Tie Reference
- Sb83160 HVAC Blend Door Retrofit
- ABS Light illuminating in the ICU.
- ABS Light Illuminating in the ICU, ABS Solenoids Not Self Checking
- Reminder: Paper Service Bulletin Mailings Are Discontinued
- DT12 pto
- Ss 1034171
- ICUC Bulb check function.
- Detroit DT12 Split Rod Bushing Repair letter to customer
- Service Information Bulletin- Input Shaft Pilot Bearing Measurement Specification
- Ss 1034139
- Ss 1034028
- Service Bulletin New "Natural Gas Vehicle Information" Webpage
- Service Bulletin Steer Axle Brake Chatter
- SF567C & SF567D ?Temporarily Suspended
- Service Information Bulletin- Oil Present at the Turbocharger Compressor Housing
- Service Information Bulletin
- Service Information Bulletin- Exhaust Gas Recirculation Crossover Pipe
- Chassis ECU Programming
- Important Campaign Information on FL614 Recall
- Pre-Delivery Inspection Oil Fill for New Final Drive (NFD) Axles
- Ss 469068
- Letter to customer on Coverage Extension GHG17 After Treatment
- Ss 1033628
- 18TS4Rev DD Heavy Duty Platform Accessory Drive Belt
- Service Solution: 1033995, SPN 523005 FMI 7 and 524042 FMI 19 Fault Codes
- Service Bulletin DT12 PTO Upfit
- Field Service-New Cascadia Cab Air Shocks
- Ss 1033951
- Engine Replacement Procedures
- Important Campaign Information- Cascadia Windshield Improvements
- DT12 Exhaust Port Splash Shield
- Service Bulletin 9818- Repainting Plastic Bumper Components
- Service Bulletin 9815- Paint Finish Standards
- Service Solution 1033911- After Reprogramming CPC04T, Fault Code (VRDU) 232/524000/9-ECU CPC Timeout Comes...
- Emission Recall D18R5 GHG17 DD Platform Model Years 2016-2018 Software Reprogramming For California...
- Service information Bulletin -HDEP PLV Return Line Tool DSN470E17006
- Ss 1033121
- Field Service Campaign D18M2 GHG17 Detroit? DD13® Software Reprogramming and Emission Label Replacement...
- Service Information Bulletin for Aftertreamtent Failure Guide
- D12 Transmission issue communication on Cascadia
- Eaton 1800-Watt Inverter With Low Voltage communication
- DD13, DD15, DD16
- Important Warranty Information on AutoMeter BCT-460DTNA Powernet Assessment Tool: Warranty Requirement and...
- Ss 1033833
- Revised Field Service Document : Detroit Assurance 2.0 Update
- Release of DiagnosticLink® 8.08 Service Pack 2
- Technical Service Note: Airliner Rear Suspension Main Crossmember Fastener Replacement.
- Ts 1033699: DT12
- Customer Advisory Letter- Telematics Connections
- AirLiner Suspension Six-Piece Bolted Service Crossmember
- Field Service Campaign: Remanufactured Detroit? DT12? Transmission
- Field Service Campaign: GHG17 DD15 Model Year 2016 Diesel Particulate Filter (DPF)
- Marker Light Leaks
- TCM update
- Operating Hours for the Customer Assistance Center
- Indel B Refrigerator Loose Circuit Board
- Ss 1033638
- 18CSA9
- Trucks were flooded
- 0505-18 spn 3563 hdep
- 0503-18
- 0502-18
- If a GVWR certification label is lost or damaged, Freightliner will supply a duplicate label
- With the start of production on February 12, 2018, the fasteners used to assemble Airliner rear suspension...
- The right-hand cab panel on New Cascadia can come into contact with the right-hand chassis-side fairing...
- 18SP734 18SP734?GHG14 DD15AT Turbocharger
- SS1033446
- Fp00020 Replacing Gross Vehicle Weight Rating (GVWR) Certification Labels
- Sb54299 ICU3 to ICU3S Replacement Guidelines
- Vehicles with Meritor drivelines bene from a softer durometer center bearing support
- ICI18-014
- 0405-18
- 0404-18 GHG17 DD8
- 0402-18 spn 625 (CPC) (GHG14)
- FL756 Brake Light Pressure Switches
- 0401-18 spn 1231 (MCM) (EPA10 GHG14)
- Ss 1033354
- 0312-18
- Letter to customers- Indel B Refrigerator
- 0311-18
- Ss 1033334 ICU3S
- D17M1 17M1 GHG17 DD15
- D17M2 17M2-REV GHG17
- D17M2-REV GHG17
- FL751 Dana Front Steer Axles
- MY18M1a_05-MAR-2018_Vocational
- Aeo18M1 GHG14 Heavy Duty Engine Platform Vocational Application Programming
- SS 1033322 ABS light illuminating in ICU, ABS solenoids will not self-check
- MY18M1a 05-MAR-2018 Vocational
- Sb00042 Flood Damage Repair GuidelinesB
- Sb2066 Gentech Low Coolant Level Sensor
- Sb2074 Kysor Fan Clutch Rocking Runout Inspection
- Sb2083 FluidXchange Tool and FittingsB
- Sb2084 OAT Coolant Replaces NOAT Coolant in Detroit Engines
- Sb2652 DT12 PTO UpfitB
- Sb3251 Replacing or Upgrading Airliner 40K Transverse Torque RodsB
- Sb3329 Caster Angle Specifications, Cascadia vs. New CascadiaB
- Sb4012 Tire Pressure Monitoring System (TPMS) Display Firmware Update
- Sb4641 Adjusting Tilt Lock Force on TRW Steering ColumnsB
- Sb9815 Paint Finish StandardsB
- Sb31034 Towing ProceduresB
- Sb49040 Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser ConnectionB
- Sb54148 Radio and Integrated Thin-Film Antenna Troubleshooting, and Field Service UpdatesB
- Sb54239 Cascadia Cabin CAN ECU CompatibilityB
- Sb54278 Powernet Troubleshooting Guide Batteries, Path, Alternator, and Starter
- Sb54296 Fuel Level Sending Unit RetrofitB
- Sb60159 Shifter Adapter Plate for Replacement Cab or Cab FloorB
- Sb83158 ParkSmart Control Module Cover Modification for a New Phase HarnessB
- Sb98020 Axalta Paint Finish CareB
- Fp31028 Cascadia 14.5-Inch Hendrickson Aero-Clad Stainless-Steel Bumpers
- Fp54031 Ordering Service Wiring Harnesses for Cascadia
- Fsb4269 Humidité excessive dans le système d'air
- Fsb42072 Diagnostic de fuite d'air
- Fsb42073 Inspection d'absence de fuites d'air par les transporteurs concessionnaires
- Fsb49040 Conduite sous pression de fluide pour échappement diesel (DEF) débranchée au niveau du...
- Sb0006 Freightliner Courtesy Engineering PolicyB
- Sb0039 New Natural Gas Vehicle Information WebpageB
- Computer Hook-Up Standard Diagnostic Time Update
- 17CSA25
- 17TL26
- 17TL27
- 17TL28
- On Cascadia vehicles built from November 25, 2013, the drain holes at the bottom of the cab doors were...
- 17CSA24
- SF551 ? Revised Bulletin
- OWL Enhancement Service Model Field
- 17CSA23r Detroit CSC closed December 14, 2017 from 11:15 am
- FL751 ? Interim Recall Notice
- Warranty Classroom Training in 2018
- 17-026
- Cascadia 2020 DRM Air Tank Mounting Brackets
- 17TL25
- Transport Dealer Air Leak Inspection
- Diesel Exhaust Fluid (DEF) Pressure Line Disconnected at the Doser Connection
- Installation of the Transmission
- Removal of the Transmission
- Exhaust and Exhaust Gas Recirculation
- Power Take-Off
- EPA10, GHG14 and GHG17 Diesel Particulate Filters
- Spn 520960 (TCM)
- Diagnostic Tests
- Spn 157 (MCM) (GHG17)
- Symptom Diagnostics
- 14CSA23 csc
- Instructions for CSC Diagnostic Support
- Cascadia
- New Detroit Diesel Cylinder Liner Upper O-Ring Leak Test Standard Repair Time
- Towing Procedures
- ICU4Me Low Air Pressure Warning Change
- Aftertreatment Systems
- Engine Manufacturer Diagnostics
- Spn 3556 (ACM) (GHG14)
- 17TS12Rev1 GHG17 Heavy Duty Engine Platform 1-BOX? Aftertreatment System ATS Wire Harness
- 0806-17 spn 101 (MCM)(GHG17)
- 0803-17 spn 411 (MCM) (GHG17)
- Sb54298 GHG17 Heavy Duty Engine Platform Vehicle Dash Oil
- FL721 cng
- FL721 Fifth Revised Bulletin
- Adjusting Tilt Lock Force on TRW Steering Columns
- Cascadia Radiator Strut Rod Rubbing on Upper Radiator Hose
- Cascadia Fault codes 6.0
- Ss 1032974
- SAM Cab & SAM Chassis Wall Charts
- Bulletin_Revised_09May17 GHG17 DD15 Model Year 2016 Diesel Particulate Filter (DPF)
- GHG17 DD15
- Spn 168 (CPC3) (GHG17)
- Technical Publications Ordering
- Fuel Level Sending Unit Retrofit
- Spn 3226 (ACM) (GHG17)
- Diagnostic tests
- Spn 96 (MCM) (GHG17)
- Spn 712 (CPC) (GHG17)
- Fuel System Integrity Check Routine
- Cylinder Liner
- Service Solution SS 1033094 KUS Float Tube Fuel Level Sensor Inform...
- Heavy Duty Engine Wastegate Repair Kit DKI470E16019
- Detroit? DT12? Transmission Proper Moving Procedure
- Vehicle Interface Module
- FL721 Second Revised Bulletin
- CNG Fuel Tank and CPDM Mounting Location
- Spn 3556 fmi 0, 1, 18
- Spn 5741 (ACM) (GHG17)
- Cascadia Windshield Improvements
- Symptom Diagnostics
- DD Heavy Duty Platform Belt and Belt Tensioner
- Detroit? DT12? Split Rod Bushing Repair
- Spn 1663 (CPC) (EPA07 10 GHG14 GHG17)
- Fmi 2
- GHG17 Heavy Duty- Exhaust & EGR
- Spn 521221 (TCM)
- Spn 521222 (TCM)
- Spn 677 fmi 2
- Spn 1322 (MCM) (GHG17)
- Spn 4765 fmi 0
- Service Solution SS 1033047 M2 Battery Drain Problem – Mismatched I...
- Symptom Diagnostics
- (ACM) (GHG17)
- (MCM) (GHG17)
- (MCM)(GHG17)
- GHG14
- GHG14 Intake Manifold Pressure Too Low
- (MCM) GHG17
- Training Solutions for Fuel Leak Found at High Pressure Fuel Pump Weep Hole for Heavy Duty DD Engines
- Diagnostic Tests
- Contaminated Fluids Diagnostic Tests
- (CPC)(EPA10-GHG14) and SPN 98 (CPC)(GHG17)
- Cascadia Cabin CAN ECU Compatibility
- GHG17 Heavy Duty Engine Platform Vehicle Dash Oil Pressure Gauge
- 0301-17
- (CPC) (GHG17)
- (CPC)(GHG17)
- 0208-17 spn 412 (MCM) (GHG17)
- FL721 Interim Recall Ending ? Final Recall to Begin
- 0206-17_ spn 521049 (MCM) (GHG17)
- 0205-17 spn 521052 (MCM) (GHG17)
- 0204-17 spn 521050 (MCM) (GHG17)
- 0203-17 spn 5741 fmi 13 (GHG17) (MCM)
- 0202-17 DD13, DD15, and DD16 Cylinder Head Assembly Removal and Installation
- Replacing or Upgrading Airliner 40K Transverse Torque Rods
- 18SP733 GHG17
- 0131-17 spn 521054 (CPC3) (GHG17)
- 0132-17 spn 521005 (CPC3) (GHG17)
- 0133-17 spn 625 (CPC) (GHG17)
- 0134-17
- 0135-17
- 0136-17 GHG17 DD5
- 0137-17 spn 3361 fmi 5 (ACM) (GHG17) spn 3361 fmi 5 (ACM) (GHG14)
- 0138-17 GHG17 DD5
- 0139-17
- 0140-17
- 0130-17 spn 520211 (IPPC) (GHG14) spn 520211 (IPPC) (GHG17)
- 0129-17 spn 102 (MCM) (GHG17)
- 0127-17 spn 1077 fmi 14 (GHG14) (GHG17) (MCM)
- 0126-17 spn 520295 (MCM) (GHG17)
- 0125-17 spn 4817 (MCM) (GHG17)
- 0124-17 spn 3720 fmi 14 - (MCM) (GHG17)
- 0123-17 spn 1483 (CPC3) (GHG17)
- 0122-17 spn 521058 (CPC3) (GHG17)
- 0121-17 spn 521050 (CPC3) (GHG17)
- 0120-17
- 0119-17 spn 3217 (MCM) (GHG17)
- 0118-17
- 0117-17 spn 5928 (MCM) (GHG17) - EGR h
- 0116-17 spn 4752 (MCM) (GHG17) - EGR
- 0115-17 spn 3226 (ACM) (EPA10;GHG14)
- 0111-17 spn 1077 (MCM)(GHG17)
- 0107-17
- 0106-17 SPN 520296 (MCM) (GHG14) and SPN 520296 (MCM) (GHG17)
- Odometer racks up mileage when the vehicle is stationary
- 1213-16 spn 3480 (MCM) (EPA07;EPA10 GHG14)
- 1207-16 spn 4363 (ACM) (EPA10 GHG14)
- 16TS24 GHG14 dd
- 16M3_bulletin Motor Control Module (MCM)
- Aeo16M3 Field Service Campaign
- 18SP714Rev EPA10 DD1516 Three-Filter Fuel System to Two-Filter KM59 GEN1 Fuel
- 18SP719Rev EPA10 DD13 Three-Filter ESOC Fuel System to Two-Filter KM59 GEN1 Fuel
- 16TL20 heavy duty engine valve stem seal installing drift and sleeve
- 1021-16 spn 110 (MCM)(EPA07EPA07;GHG14), spn 110 (CPC)(GHG14)
- 16TS21 GHG17 dd platform engines with code spn: 3217 fmi: 2, SCR inlet nox sensor lambda drift low or code...
- 1020-16 chassis fuel system isolation test
- 16TL18 GHG17 medium duty (MD) test electronic control units (ECUS)
- 1018-16 symptom diagnostics - noise
- 1017-16 engine model and serial number designation
- 1016-16 diagnostic test - engine oil leaks
- 16TL17 label update for GHG14 test aftertreatment control module (ACM)
- 16TL14REV GHG17 camshaft timing tool set W470589062300
- 1005-16 spn 4364 (ACM) (GHG17)
- 1004-16 spn 3511 (ACM) (GHG17)
- Spn 3509 (ACM) (GHG17)
- 1002-16 spn 3512 (ACM) (GHG17)
- 18SP713REV 18SP713 EPA10 DD13 three-filter fuel system to two-filter KM59 GEN1 fuel system conversion...
- 18SP720REV 18SP720 EPA10 DD15/16 three-filter esoc fuel system to two-filter KM59 GEN1 fuel system...
- 1001-16 spn 3719 (ACM) (GHG17)
- FL718 front axle hub rating
- SB0006 freightliner courtesy engineering policy
- SB54291 detroit assurance lane departure warning camera installation
- SB54297 loose ignition switch on cascadia vehicles
- 16-032_DETROIT standard diagnostic time for GHG14 aftertreatment device checklist updated
- 16TS18 EPA10 and later dd auto-elevate feature
- 0910-16 spn 3251 (ACM) (GHG17)
- 0909-16 excessive oil consumption
- 0906-16 low pressure fuel pump
- 0905-16 spn 100 (MCM) (GHG17)
- 0902-16 symptom diagnostics - belt coming off, shredding or misalignment
- GHG17 medium duty oil filter kit special notice
- 0901-16 spn 5927 (MCM) (GHG17)
- FP26050 DT-12 brake piston seals
- Important Update for Parked HVAC System Options
- 16TL15 GHG17 heavy duty (HD) test electronic control units (ECUS)
- 16TS17 GHG17 dd platform ambient air temperature sensor and fault codes
- 0814-16 spn 5016 (ACM) (GHG17)
- 0813-16 spn 3251 (ACM) (GHG17)
- 0811-16 camshaft and idler gear
- 16TS16 detroit DT12 transmission oil and oil fill/drain plug washers
- 0810-16 symptom diagnostic noise
- 0809-16 symptom diagnostics : noisy 1- box aftertreatment
- 16TS14 EPA10 and GHG14 service replacement 1-BOX doc inlet change
- 0807-16 spn 524279 (CPC) (GHG17)
- 0805-16 spn 100 (MCM)(GHG17)
- 0808-16 symptom diagnostics - engine brake
- 0804-16 spn 5444 (MCM) (GHG17)
- 0803-16 symptom diagnostics - coolant loss
- Allison tech tip #TT7831EN transmission programming
- 0612-16 spn 175 (MCM) (GHG17) and spn 175 (MCM); ( EPA07;EPA10;GHG14) diagnostic procedure
- 0611-16 spn 110 (MCM) (GHG17) and spn 110 (MCM); (EPA07;EPA10;GHG14) diagnostic procedure
- 0610-16 spn 111 (CPC) (GHG17) and spn 111 (CPC); (EPA07;EPA10;GHG14) diagnostic procedure
- 0609-16 spn 174 (MCM) (GHG17), spn 174 (MCM) (EPA07), spn 174; (MCM) (EPA10), and spn 174 diagnostic procedure
- 0608-16 spn 715 (CPC) (EPA07;EPA10); spn 715 (CPC) (GHG14); spn 715 (CPC) (GHG17) diagnostic procedure
- 0605-16 spn 625 (CPC)(GHG17) and spn 625 (CPC) (EPA10;GHG14) diagnostic procedure
- FL703 Revised Bulletin
- 0601-16 spn 103 (MCM) (GHG17) and spn 103 (MCM); (EPA07;EPA10;GHG14) diagnostic procedure
- Parksmart HVAC modules
- Cascadia virtual technician retrofit
- Marker light leaks
- Clutch Release Bearing Grease Hose
- Been incorrectly shimmed at the factory, and may lean slightly to the right or left
- 18SP726 ? EPA10 GHG14 Two-Filter Fuel System KM59 GEN1 DD13 High Pressure Fuel Fee
- Inspection of the DD13 Turbocharger
- Spn 524286 (TCM)
- Spn 3226 (ACM) (EPA10;GHG14)
- SPN 2623 (CPC)(GHG17), SPN 2623 (CPC)(GHG14), and SPN 2623 (CPC)(EPA07 EPA10 GHG14)
- Fmi 2, 3, 4
- Fmi 2 cpc
- Fmi 3,4,5
- Fmi 3,4,5
- Fmi 3,4,5
- Fmi 3,4,5
- FMI 3 Engine Oil Pressure Sensor Circuit Failed High
- FMI 5 Oil Pressure Sensor Stuck High
- Cleaning of the Exhaust Gas Recirculation Venturi Pipe Delta P Sensor Ports
- 15TS3 Detroit? Coolant Change From Nitrite Organic Acid Technology
- 16TS9 dd
- 16TL4 doc
- 16TS8 DD13
- 16TL5 dd
- Warranty Recognition Program Suspension
- 16-011
- 16TS7 Reman Diesel Particulate Filter Serial Number
- 16TL3 Pocket iQ? ABS Product Family Kit is Available at PDC
- New Detroit Bearing Failure Analysis Standard Diagnostic Time
- 16-009R_OWL Enhancements
- 16_TL-2 DD Platform Aftertreatment NOx Sensor Socket W470589060900
- TSN for all Cascadia vehicles equipped with plate mounted fifth wheels and outboard mounting angles
- 16TS6 Variable-Speed Fan Operation on Cascadia Vehicles
- 0308-16 TCM
- Canadian Warranty Parts Return Address Change
- 0307-16 spn 723 (MCM)
- 16TS5 Release of the DD Platform Bearing Failure Guide
- 0306-16 TCM spn 520970 fmi 7
- 0305-16 TCM spn 520999 fmi 7
- 0304-16 SPN 2791 (MCM) ( GHG14) and SPN 2791 (MCM) ( GHG17)
- Contaminated Fluids
- 18SP731 GHG17
- Hydrocarbon Doser Coolant Lines
- 0301-16 SPN 625 (CPC) (EPA07) and SPN 625 (CPC) (EPA10 GHG14)
- Vehicles built in model year 2016 use a bulkhead module (BHM) with a 500k auto baud rate
- TSN for all Cascadia vehicles equipped with Airliner 40K and 40K extra duty rear suspensions
- Early EPA07 QLD Radiator Replacement
- Powernet Troubleshooting Guide: Batteries, Path, Alternator, and Starter
- 1210-14
- 1207-15
- 1205-15
- 15TS4_Rev2_ EPA07 DD15 Piston Kits
- 15TL24 otc 1750
- 1202-15
- 15TS16Rev1 EPA10 Reman MCM Improvement for Fault Codes SPN 651 to 656
- 14TS16REV excessive overhead engine noise on GHG14 dd platform engines
- 15R3 detroit axle steering arm capscrew replacement
- 18SP718 EPA07 DD15/16 three-filter esoc fuel system to two-filter KM59 GEN1 fuel system conversion service kit
- 18SP720 EPA10 DD15/16 three-filter esoc fuel system to two-filter KM59 GEN1 fuel system conversion service...
- 18SP720 EPA10 DD15/16 three-filter esoc fuel system to two-filter KM59 GEN1 fuel system conversion service kit
- 18SP722 DD13 KM59 GEN1 bus two-filter system amplifier, needle and plv return fuel line clearance package...
- 18SP725 two-filter fuel system KM63 GEN2 DD13 high pressure fuel feed lines, mounting bracket and p-clips...
- AEO15M1 GHG14 dd platform software reprogramming for auto elevate
- 15R2 detroit axle steering arm capscrew inspection
- FINAL_15M1_BULLETIN GHG14 dd platform software reprogramming for auto elevate
- 15TL21 GHG17
- Detroit Data Summaries Application and Kits Are No Longer Available Through PDC
- _NewDetroitCoolantLineSRTs
- _Warranty Recognition Program
- 15-028
- - Tire Pressure Monitoring System (TPMS) Display Firmware Update
- - Detroit Assurance Lane Departure Warning Camera Installation
- 805-15 fmi 0
- 803-15
- 802-15 spn 520970 fmi 7 (TCM)
- Freightliner: information provided regarding water intrusion and foreign debris CAN enter sam chassis and...
- Sb9815 Paint Finish Standards
- Sb54293 SAM Chassis Water Intrusion Prevention
- 801-15 spn 520999 fmi 7 (TCM)
- 15TS15Rev Detroit? DT12? Transmission Proper Towing Procedure
- 711-15
- 15TS14 GHG14 dd
- 708-15
- 706-15 spn 1323 (MCM) (GHG14) spn 1324 (MCM) (GHG14) spn 1325
- 703-15 GHG14 DD15 at
- 702-15 DD15 and DD16 Delphi © Exhaust Gas Recirculation Valve Actuator
- Sb54239 Cascadia Cabin CAN ECU Compatibility
- Sb3531 Differential Lubrication, Detroit Model 6 Axles
- Sb54292 Nexiq USB-Link Upgrade and Diagnostic Connector
- Sb54291 Detroit Assurance Lane Departure Warning Camera
- Sb83114 Approved Leak Detection Methods for Air Conditioning
- Sb54278 Powernet Troubleshooting Guide: Batteries, Path, Alternator
- 704-15 spn 4364 (ACM)(EPA10)
- TSN for all Cascadia vehicles equipped with the inverted U end of frame closing crossmember.- Customer...
- 15-017
- 15TS12 dd
- 15TS13 dd
- 512-15 GHG14 DD15 at
- 511-15 DD15 and DD16 Exhaust Gas Recirculation Valve Actuator Pull Rod
- 509-15
- 508-15 spn 625 (mcm)( EPA10;GHG14)
- 507-15 SPN 1590( CPC)(GHG14) and SPN 1590 (CPC)(EPA07;EPA10)
- 506-15
- 505-15 spn 3361 (ACM) (EPA10)
- 15-015
- 15-016-DLR
- 504-15 DD13
- 503-15 DD13
- 502-15
- Sb83137 ParkSmart?/Espar Auxiliary Heater Servic
- Sb2083 FluidXchange Tool and Fittings
- Sb4654 Rack and Pinion Steering Gear Retrofit Guide
- Sb8217 82-17
- 18SP716
- 501-15
- 15CSA9
- 15CSA10
- 15CSA4
- 15TS10Rev DD Engine Platform Coolant Filter
- 14TL-7Rev DD Platform Flywheel Housing Runout Tool W470589032100
- 406-15 spn 97 (MCM) (EPA10) / spn 97 (MCM) (GHG14)
- 405-15
- 404-15 spn 4364 (ACM) (EPA10)
- 403-15 spn 677 (MCM)(EPA07)
- 402-15 SPN 2630 (MCM)(EPA10) and SPN 2630 (MCM)(GHG14)
- 15TL6 W470589129100 ? HDEP HP Fuel Rail Test Caps
- Sb3133 Step Clamps Are Not Reusable
- 18SP717 DD13 EGR
- 401-15
- 15-010-DLR
- 15TS9 Hydrocarbon Doser Block Fuel Compensation Pressure Sensor
- 326-15
- 325-15
- 324-15
- 323-15
- 321-15 spn 4364 (ACM) (GHG14)
- 320-15 spn 4374 (ACM) (GHG14)
- 15-009_Detroit_New_SDTs
- 15TL5 davco
- 308-15
- 307-15 spn 3480 (MCM) (EPA07;EPA10;GHG14)
- 306-15 spn 3246 (ACM)(EPA10;GHG14)
- 304-15
- 15TL4 W470589050900 ? 3/8? Drive GEN2 Two-Stage Valve Socket
- 303-15
- 302-15
- Sb01101 Pilot Bearing Spacer for Detroit Engines with Eaton transmissions
- 18SP714 EPA10 DD15/16
- 18SP713 EPA10 DD13
- 18SP712 EPA07 DD15/16
- 18SP706
- 301-15 SPN 3251 (ACM) (EPA10) and (ACM) (GHG14), 3936 (ACM)
- 15TS8 EPA10 and GHG14 Diesel Particulate Filter (DPF) Compatibility
- 0204-15
- 15TS6 Replacement of the High Pressure Fuel Pump Camshaft Oil Seal
- 0203-15
- 15TS5Rev GHG14 DD Platform DEF Pump Leaks and Code 4374 FMI 0 Under Pressurized DEF System
- 0202-15 EPA10 and GHG14 Diesel Oxidation Catalyst Face Cleaning
- 0201-15 spn 3250 fmi 31 - GHG14
- 15TS4 EPA07 DD15
- 15TS2 EPA07 and EPA10 DD Platform Engines With Low Oil Pressure Codes
- 15TS1 GHG14 dd
- 0108-15 SPN 1323 through 1328 (MCM) (GHG14)
- 0107-15
- 0106-15 SPN 3251 (ACM) (EPA10) and (GHG14)
- 0105-15 spn 102 (MCM) (GHG14)
- 0104-15 spn 3464/ fmi 16, 18 (MCM) (GHG14)
- 102-15
- Sb83155 Espar Service Information
- 18SP687 DD15 16 EGR
- 0101-15 spn 4364 (ACM) (EPA10)
- 1110-14 EPA10 doc
- 1108-14 spn 636 (MCM) (EPA07;EPA10;GHG14)
- 1105-14
- 1104-14
- 1102-14 DD13
- 18SP711 DD15 and DD16 Axial Power Turbine Bracket Ki
- 18SP708Rev EPA07 10 Three-Filter Fuel
- 18SP707Rev EPA07/10 Three-Filter Fuel System DD13 High Pressure Fuel Feed Lines, Mounting Bracket and...
- 1101-14 DD15 and DD16 Cylinder Head
- 14TS19Rev DD Platform High Pressure Fuel Lines
- 14TL8 TorcUP? Non-Impacting Torque Tool.
- 14-036-DLR dtna & jad
- 14-038
- 14-039
- 14-040
- 14-040_Additional_CLOs Additional Detroit CLOs for the Heavy Duty Engine Platform
- 14-039_additional_SDTs New Detroit Standard Diagnostic Times
- 14-038_New_SRTs Additional Detroit Standard Repair Times.
- 14CSA22 dtna
- 14WO-9_Warranty_Access Detroit New User Warranty Access Request
- 14TL9 Special Tool Warranty Program.
- 14TL7 dd
- 14CSA21
- 14-035
- 14-035_SRT_Update_for_Cascadia Detroit Standard Repair Time Updates for Cascadia Truck Models
- 14CSA20 EGR
- 1010-14 spn 2623 (CPC) (GHG14)
- 1009-14 spn 5016 (ACM) (GHG14)
- 1008-14 SPN 3510FMI 4,7, and 8 (CPC)(GHG14)
- 14TS28 dd
- 1007-14 spn 5016/fmi 3, 4 (ACM) (EPA10)
- 1006-14 spn 4374 (ACM) (GHG14)
- 1005-14
- 1003-14
- Sb0039 New "Natural Gas Vehicles Information" Webpage
- Sb2080 Australian CST M1400 Isolated Radiator Retrofit
- Sb3250 Incorrect ECAS Ride Height Sensor and Linkage Installation
- Sbw5460 Powernet Distribution Box Fuse Retention on the Keep-Alive
- Sb54287 Powernet Distribution Box Fuse Retention on the Keep-Alive
- 18SP705Rev5 18SP705Rev5 ? DD Platform Delta Pressure Sensor
- 18SP684Rev4 18SP684Rev4 ? EPA07 and EPA10 DD Platform EGR Delta Pressure Sensor Update
- The location of the EOF crossmsmber with respect to the centerline of the rear suspension is 1.0 inch...
- 14TS21 hdep
- 14-017R
- FL662.-DLR
- 14TL2 dd
- 14TL5 ABS
- 14-028
- 14TS19 dd
- 14-027
- 14-026-DLR
- 715-14
- 14-022
- 14-023
- 14-024-DLR dtna & jad
- 714-14
- 713-14
- 712-14
- 20-75 - canceled
- 20-73 - canceled
- 54-285
- 54-215 - ICU4M
- Freightliner Action Bulletin FAB158 Cummins Eaton SmartAdvantage
- Detroit approved priming tools for the KM63 GEN2 fuel systemdetroit approved priming
- Sb0038 00-38
- 14TS5 Replacing Damaged Aftertreatment Sensor Bosses
- 0228-14
- 14TS4 Valve and Liner Installation Tool Issue
- 13wo3rev2_final Actual Labor Hours on Detroit Claims
- 0224-14 spn 1590 fmi 9 - cpc
- 0219-14
- 0215-14
- 0210-14
- 0209-14
- 0202-14
- 54-281
- 0237-14
- 0233-14 spn 51 fmi 2
- 0229-14
- 0238-14
- 0239-14
- Freightliner Action Bulletin FAB154 New options for Cascadia
- Freightliner Action Bulletin FAB153 New Harness Highway for Cascadia
- 54-280
- 54-274
- 54-278
- 54-279
- 54-277
- 35-30
- 33-28
- 25-34
- 54-275
- 83-144
- Freightliner Action Bulletin FAB143 Load Transfer Suspension
- Freightliner Action Bulletin FAB145 New Cascadia Roof Fairing
- Freightliner Action Bulletin FAB146 Cascadia LED headlights
- Sb0935 Replacing the Engine Air Filter Element, Donaldson Air Cleaner (03-33648-001-002)
- Sb4269 Excessive Moisture in the Air System
- 532-13
- 530-13
- 529-13
- 525-13 spn 2791-FMI 7 ? all years
- Sb3529 Axle Alignment Specifications
- Sb4932 DEF Gauge Reading Incorrectly
- Sb4269 DEF Metering Unit Inlet Screen Clogging Due to Excessive Moisture in the Air System
- Sb54215 ICU4M Missing VORAD Information or Reporting Fault SA 42 SPN FMI 07
- Sb60144 New Cascadia Windshield Seal, Adhesive, and Preparation
- Sb83145 ParkSmart Refrigerant Loop Service Kits
- Sb3132 Cascadia Chassis Side Fairing Lower Air Deflector Retention
- 13TS2 Single-Speed Fan Operation on Cascadia Vehicles
- Sb8844 Braces for Cascadia Cab-Mounted Splash Shields
- 12-039-DLR owl
- 12-040-DLR
- 12-041-DLR
- ICI12-028-DLR FL632
- 12-038-DLR
- Sb4268 Brake S-Cam Tube Lubrication Interval Change
- Sb4724 Crank No Start, Loss of Engine Prime on Decked Vehicles
- Sb3131 Huck-Spin 2 Changeover
- 12CSA18
- 12-022-DLR
- 12C3
- 12C3bul-DocTrac
- Sb3130 Quarter Fender Reinforcement
- Sb4267 Brake Shimmy
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 Freightliner Cascadia?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history