2019 Jeep Wrangler: engine overheating

Filed Jun 11, 2026 · Transmission · CO

In June 2025, I had the clutch recall (the federal safety agency 23V‑116) performed on my 2019 Jeep Wrangler at AutoNation Jeep Southwest in Littleton Colorado. Prior to this recall repair, the vehicle had no transmission faults or warning lights. Following the recall work, I began experiencing a recurring 'Service Transmission' warning. On a return visit, the dealership discovered they had incorrectly reinstalled the shifter cables during the recall repair, making it difficult to shift into first gear. The cables were redone. The 'Service Transmission' warning continued after the cable rework. The dealership performed a software flash on a subsequent visit, which did not resolve the issue. The vehicle later experienced a 'Service Transmission' warning accompanied by a clutch overheat alert and limp mode activation. The dealership has since diagnosed fault codes P082C and P082F (gear lever position sensor circuit high) and is recommending a transmission range sensor replacement at my expense. The dealership has acknowledged they cannot confirm the root cause of these codes. When I contacted Jeep Customer Care, they called the dealership and accepted their assessment that the issue is unrelated to the recall repair. I believe the ongoing fault codes are a direct result of the defective recall remedy, specifically the incorrect shifter cable installation and subsequent cable disturbance during rework. I am requesting the federal safety agency investigate whether the recall remedy as performed at this dealership is defective.

Filed Mar 4, 2026 · Engine · 61,000 miles · UT

The contact owns a 2019 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, there was a misfire coming from the engine, and there was a backfire coming from the exhaust system. Additionally, there was a coolant intrusion in cylinder #3 and a burning in the head gasket. The contact stated that the engine overheated and the vehicle failed to restart after it was turned off. The catastrophic engine failure was attributed to coolant intrusion into the combustion chamber, which caused severe internal damage. The vehicle was towed to an independent mechanic, where the engine was being replaced. The vehicle was not yet repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 61,000.

Filed Jul 8, 2025 · Electrical, Transmission · NY

I have had the recall completed but now my car to give a “service transmission “ message and that there is a problem with my clutch getting hot. There is no burning smells. are no issues such as rough gear changes or engine issues. It states the clutch is overheating and I’ve barely left the driveway. And this is after sitting still overnight Didn’t the recall fix this issue? It’s terrifying as it comes up stating that the transmission needs to be service then all information as to what gear you are in disappears while you are driving. This isn’t a recall fix it’s a nightmare. It wasn’t having a problem before but now it warning messages act like it’s going to burn up. There is NO burning smells no rough gear changes. Afraid to drive it.

Filed Jul 7, 2025 · MD

Immediate Attention Required – Vehicle Left in Dangerous, Inoperable Condition by Krietz Auto Dealership in Frederick, MD. I am writing with extreme urgency to request your immediate attention and intervention regarding a critical issue involving Krietz Auto Dealership. I have been a loyal customer of Krietz Auto since I purchased my vehicle from them in 2020. Recently, I brought my truck in due to a loud noise coming from under the hood. I was told the rear differential needed to be replaced. To my knowledge, there were no other major issues at the time. After the dealership had my vehicle in their possession for over a month, I was shocked to receive it back in far worse condition. Upon picking up the vehicle, it could not idle without overheating. I attempted to drive home with my young child in the vehicle, only to realize it could not travel over 30 miles per hour without the temperature spiking dangerously high. Tragically, the vehicle has now completely broken down and is no longer drivable. I am being forced to have it towed to another repair shop at my own expense. What was originally a routine service appointment has now escalated into a situation that has left me without transportation and has put the safety of both myself and my child in serious jeopardy. This level of negligence is unacceptable. I trusted Krietz Auto with my vehicle and my family’s safety. I now fear the damage was either worsened or created during the time the vehicle was in their care. I am respectfully requesting that this situation be thoroughly investigated and immediately rectified. This is no longer just a service complaint — it is a matter of public safety and accountability.

Filed May 14, 2025 · Engine · FL

The contact owns a 2019 Jeep Wrangler. The contact stated while driving approximately 35 MPH, the water temperature gauge rose and failed to return to a normal engine temperature. The contact pulled over to the side of the road and became aware that the third reservoir tank was empty. The contact waited until the engine had cooled down, added coolant, and then continued driving the vehicle. The contact became aware of coolant leaking around the water pump. The dealer was informed of the failure however, the contact had not heard from the dealer. The vehicle was not taken to the dealer to be diagnosed or repaired. The manufacturer was not informed of the failure. The failure mileage was unknown.

Filed Apr 14, 2025 · Brakes · CA

The vehicle started to have braking issues where the brakes would sometimes apply both front brakes or one one front brake causing the vehicle to swerve erratically when braking. Sometimes the right front brake would also stay applied for extended periods of time causing the vehicle to pull hard and the braking system to overheat so hot that I burned my fingers on the tire rim after parking the vehicle and inspecting. The Jeep has been at the dealership for repairs for over 7 months under warranty and they don't know how to fix the vehicle and are not willing to replace it! This is a massive safety concern that should make everyone think twice before buying a Jeep when the brand wont even take care of there customers!

Filed Oct 8, 2024 · Engine · GA

the federal safety agency has a bulletin about coolant leaks in Jeep Wranglers with 2.0L engines: Bulletin: 07-001-20 REV. A, dated April 9, 2020 Vehicles affected: Jeep Wranglers built before November 30, 2019 with a 2.0L I4 DOHC DI Turbo Engine or 2.0L I4 DOHC DI Turbo Etorque Engine Issue: The coolant inlet tube fasteners may become loose, causing a coolant leak Solution: Remove the coolant inlet tube fasteners, clean the threads, add Thread Loc, and reinstall Tightening torque: Tighten to 11N∙m (8ft. lbs.) A coolant leak can cause the engine to overheat and potentially lead to engine failure. Engine fan was not shutting off after leaving a covered parking garage and an engine alert appeared and displayed that the engine was overheating. Had my jeep towed home. We were able to see that the main coolant reservoir was empty and that there was dry coolant all around the engine. Our jeep has not been fixed and is not drivable. Need guidance as there isn’t a recall on this but a known issue, and you have a bulletin out about it.

Filed Mar 26, 2024 · Engine, Steering · FL

It started about 4 months ago and continues to get worse and more frequent but it starts shaking and wobbling violently at high speeds especially if you hit a bump it’s almost impossible to keep it in the road. It’s very scary and dangerous. After googling I heard about the death wobble which Chrysler has recalled some of the same models as mine. Any information or help you could give us would be appreciated. It also just started overheating when sitting idle probably not related but don’t understand why mine is having so many problems it’s not old enough

Filed Aug 2, 2023 · NE

I was notified of a recall for my 2019 Jeep wrangler unlimited Sahara back in 02-2023. This is a recall wherein my clutch could become overheated and lead the pressure plate to rapidly fracture which could lead to a fire and cause injuries. To date, there is no remedy. This is recall number 23V‑116 and manufacturer recall 19A. I have emailed them without response other then they would contact me in a few days.... My concern is growing as they dont seem to be taking this very serious and exactly what am i supposed to drive? If i drive the car, i put myself and others at risk. I have asked for a rental car until they come up with a fix. My pleas have gone unanswered. in any case, i believe that this recall should be addressed promptly.