2015 Ford Edge: engine failure

Filed Oct 13, 2026 · Engine · CA

Vehicle: 2015 Ford Edge with 2.0 Liter EcoBoost engine. Ref: DP26008 While driving, the "Engine Coolant Over Temperature" warning came on and the temperature level spiked and the check engine lights came on. Engine began to run really rough. At the time, I was travelling on the highway with my children in the car and had to pull off on the side of the road. After being stranded for 4 hours while waiting for a tow, I towed it to a Ford Dealership. Dealer confirmed there is coolant intrusion into the engine and referenced TSB 22-2229. Per dealer, vehicle needs a new engine.

Filed Sep 25, 2026 · Engine · PA

Engine failure due to coolant intrusion. Engine required replacement.

Filed Sep 12, 2026 · Brakes, Electrical · MA

My 2015 Ford Edge Titanium (VIN provided) suffered a catastrophic engine failure at 85,475 miles requiring a Ford long block replacement. After driving only 53,000 miles on the new corporate engine component, the vehicle began shaking violently and suffered a sudden, dangerous loss of power while driving, rendering it completely inoperable (it is sitting in my driveway unable to be driven). The vehicle threw critical fault codes P050B (Cold Start Ignition Timing) and P061B (Internal Control Module Torque Calculation Performance). Diagnostics indicate a terminal internal failure of the timing chain or torque converter. This vehicle has a severe, documented history of manufacturing and safety defects, including catalyst monitor sensor failure 08/23/16, fan relay failure 11/20/18, purge valve failure 02/27/21, a total loss of brakes while driving on 02/15/22 due to a rear caliper failure, a faulty throttle body on 03/06/22, and an incorrectly installed engine wiring harness by the dealership when engine was replaced. This list is not all inclusive. I have a 1.5" binder of repairs and services dating back to purchase date which are too numerous to attach. This failure directly mirrors the engine defect patterns currently being evaluated under the federal safety agency Defect Petition DP26008 / ODI 11754989.

Filed Feb 3, 2026 · Engine · CA

2.0L EcoBoost engine and coolant intrusion. Coolant leaked into two of the cylinder heads, resulting in engine failure and the need for a full engine replacement.Initially, the vehicle would not start. A tow company technician was able to get the vehicle started, after which I was advised to drive directly to my mechanic. I was informed that the exhaust smelled like diesel fuel and that if the engine were shut off, it was highly unlikely to restart. At that point, the check engine light illuminated. The dealership confirmed the coolant instrusion and the need for a new engine.

Filed Nov 10, 2025 · Engine · IL

There was a constant burning smell off and on over the last year coming from under the hood. Some days it was stronger than others. Engine compartment was hot when hood was opened. Would the engine catch fire? The coolant level would drop/leak randomly causing car to sputter or vibrate while sitting at traffic lights, etc... Traffic behind me was ready to move, but my car wasn't moving at the normal rate. It wasn't safe. Warning lights would come on, but not always. Sometimes it would throw a code and sometimes it wouldn't. For the first several months, we didn't know what exactly was going on with the vehicle. Unfortunately these cars are still being sold with this problem. We bought one of them from a dealership and got stuck paying for a new engine. Clearly, someone ditched this car before the engine replacement became their problem. We aren't the only ones out there. Contacted Ford dealership for remedy or help with no luck. We went to our local mechanic for help and they gave a quote for engine replacement that was reasonable. Was told engine needed to be replaced for $6,500. Since, we had recently bought the car, we went ahead with replacement but were sick about it.

Filed Jul 29, 2025 · Engine · NE

Had a misfire when starting the vehicle so took it to a mechanic. There is a coolant leak in the engine block which appears to be a major problem with this year and make. Can cause engine failure and other problems.

Filed Jul 19, 2025 · Engine · LA

Recently my Check Engine Light came on and I had the vehicle diagnosed with a local repair shop. The code P0301:00-EC was pulled from the vehicles scan. Upon further research this code is linked to TSA 19-2208 issued 06/27/2019. Ford knew that the engine design was flawed and only issued a TSA bulletin. This issue could cause catastrophic engine failure and fire. This issue is not a maintenance issue but a serious flaw from the manufacturer. There is also a class action lawsuit, Miller, et al. vs. Ford Motor Company - Case No: [XXX] filed in the U.S. District Court for the Eastern District of California. I am hoping that you will take interest in this, as there are probably many 2nd or 3rd owners of these vehicles that are unaware of the severity of the engine flaw. My vehicle has been at the Robinson Ford in Baton Rouge LA since 06/17/2025, and the cost of the new engine is 9600.00. I'm thankful that driving the vehicle from NC to LA no incidents occurred and I was able to have the issue diagnosed before there was. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Feb 23, 2025 · Engine · CA

Kept up regular maintenance on car. The vehicle began to lose power while driving and took in to shop, was told the cylinders were misfiring. Had replaced twice and was told there were leaks. Engine failure.

Filed Jan 30, 2025 · Engine, Fuel system · MN

55,000 miles and start the car it shakes and engine light comes on. My plugin said misfired cylinder so we Take it to Apple ford in maplewood, mn and they say it has coolant in engine cylinders and need to replace the engine for about $7500 and it’s not drivable they said. Internet has many lists of this complaint for my engine but still no recall. I’ve had it parked since waiting.

Filed Jan 6, 2025 · Transmission · 136,064 miles · RI

The contact called on behalf of the dealer who owns a 2015 Ford Edge. The contact who is a Safety Emission Inspector for the dealer stated that the flex plate had fractured. The owner of the dealer was stopped at a traffic light when the engine seized, and the vehicle failed to move. After several attempts, the vehicle failed to start. The vehicle was towed to an independent mechanic where it was diagnosed and determined that the flex plate was fractured and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The vehicle was towed back to the dealer and had not been driven since the failure. The failure mileage was 136,064.

Filed Dec 4, 2024 · Engine · KS

Under normal driving conditions, engine had severe misfires, flashing check engine light, and vehicle had to be pulled to side of highway. Took several hours sitting on highway to get tow truck to tow to dealership. Dealership confirmed coolant in pistons and deemed it a catastrophic engine failure. Problem appears to be widespread with many reports of the same, and a known engine defect that causes the problem.

Filed Sep 5, 2024 · Engine · OH

My 2015 Ford Edge, with 95,000 miles, has a 2.0L EcoBoost engine that requires a new engine (Engine Long Block Kit) due to a coolant intrusion into the cylinder. Diagnostic trouble codes include PO302, PO217, and P0316 are consistent with TSB 19-2346 (See pic attached). There are also other Diagnostic trouble codes which include PO219, PO6E9, and P1026 (See pic attached) The service station that serviced my vehicle said this was the 4th Ford Edge they have seen this week with the same issue and Ford has recalled some of these vehicles but not my VIN#.