2016 Ford Explorer electrical problems

Filed Oct 18, 2026 · Electrical · MA

2016 Ford Explorer, Falling pedal to the floor. acceleration of high speed. No physical obstuction. Noted that 2016 Ford Exployers have been highly documented for widw spread issue, which involves a defective EIB. Noted that automobile will be sent to dealership.

Filed Oct 5, 2026 · Electrical, Engine · IN

On approximately 09/02, I took my 2016 Ford Explorer to an authorized Ford dealership for recall-related PCM service. After the recall service was completed, I experienced additional problems with the vehicle and returned on 09/4 and I also called the same dealership that same day because I believed something was wrong following the repair. The dealership replaced the battery but did not perform additional diagnostics unless I paid out of pocket. I was unable to immediately afford those diagnostic charges, so I later sought additional diagnosis. The vehicle continued to experience drivability/electrical problems, including misfire symptoms and eventually a no-start condition. After further testing, another authorized Ford dealership diagnosed the PCM as faulty. I contacted Ford Motor Company because I am concerned that the recall service, programming, or work performed during the recall may have contributed to the PCM failure. Ford closed my case because the recall was marked completed and stated that my vehicle is outside its warranty period. I returned the vehicle two days after servicing dealership as the recall repair to report problems. I am requesting that this be reviewed as a possible recall-repair-related safety issue. The PCM failure and associated engine/electrical problems could affect drivability and the vehicle’s ability to operate safely. The vehicle and related repair records are available for inspection.

Filed Sep 29, 2026 · Body, Electrical · NC

1. What component or system failed or malfunctioned, and is it available for inspection upon request? The exterior B-pillar trim on the side of the vehicle became detached while the vehicle was being driven. After the trim became loose and was temporarily secured by a Ford dealership, the vehicle's security system malfunctioned, the tailgate would not open, and the vehicle would not shut off normally. The trim piece is currently taped in place. 2. How was your safety or the safety of others put at risk? The trim detached while I was driving and was flapping against the vehicle. There was a risk that the part could have completely separated from the vehicle and struck another vehicle, pedestrian, or object in the roadway. I was also distracted while attempting to manage the situation and find a safe place to stop. Operating a vehicle with components coming apart created an unsafe condition for me and other motorists. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. A Ford dealership observed the detached trim and temporarily secured it with tape. The trim was later repaired; however, the same component has detached again, demonstrating that the problem has recurred. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The component was inspected by a Ford dealership, which temporarily secured the trim and later repaired it. The vehicle has not been inspected by police or insurance representatives, to my knowledge. 5. Were there any warning lamps, messages, or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lamps or messages before the B-pillar trim detached. After the trim became loose and was temporarily secured, the vehicle began exhibiting additional symptoms, including a malfunctioning security system, inability to open the tailgate, and failure to shut off completely.

Filed Jul 27, 2026 · Electrical, Engine · TX

Truck turns off

Filed Jun 19, 2026 · Electrical · LA

I have a 2016 ford explorer limited and it has 2 separate recalls on it one being the exterior a pillar applique trim clip attachments are not properly engaged due to improper assembly which borders the right and left side of the windshield, may be loose missing or become detached. also, the driver and front passenger door b-pillar trim appliques may become partially or fully detached. which I can hear wind noise and a rattling noise with also water pouring inside my truck when it rains, which has now caused damage to my wiring in the seats where the heat and cold does not work, nor does my sunroof/moonroof work anymore bc the water comes in from the top also

Filed Jun 6, 2026 · Electrical · IL

I was driving on the highway and the driver side trim piece on the window flew off onto ongoing traffic. This is the second piece that flew off. The passenger side also flew off but was fixed. But now since this piece flew off I can’t even open my trunk. I did some research and it does say that the piece that flew off is connected to the trunk and a wire might have snapped when the piece flew off and now won’t allow the trunk to open. I took it to ford and they told me they can’t do anything about it until I get the recall paper and they get the piece in stock. This has been a year now that I’ve been having to drive around like this and with trunk not opening. Please help!

Filed May 20, 2026 · Electrical · 184,847 miles · NY

Odometer Fraud. The contact purchased a 2016 FORD Explorer. It was discovered that there was a mileage discrepancy. The vehicle was a dealer sale. At the time of purchase, the vehicle mileage was 93,000 and at the time of registration, it was discovered that the mileage was 184,847.

Filed Apr 2, 2026 · Electrical, Lights · DC

Vehicle equipped with red and blue emergency lights, excessive auxiliary lights prohibited by law, facilitates color of law violations, poses a risk to general public regarding harassment, impersonation of police officer, seller has actual knowledge, strictly liable upon a purchase agreement with buyer, and can be liable for crimes committed by others as a coconspirator.

Filed Apr 2, 2026 · Acceleration, Electrical · DC

Vehicle equipped with operational red and blue emergency lights prohibited by law, facilitates criminal activity such as impersonation of a police officer, civil regulatory laws regarding excess auxiliary lights, etc. Seller has actual knowledge and can be liable under color of law upon a purchase agreement with a buyer. Vehicle has open recalls and unresolved mechanical/electrical maintenance.

Filed Mar 24, 2026 · Driver assistance, Electrical · NJ · fire

Driving down the NJ Turnpike the dashboard started displaying lane assist no longer available along with a check engine light. Once stopped the front of the car had been burned with parts of the bumper melted. No visible fire at that time. Had the vehicle towed to Holman Ford. They assessed the damage to the Explorer and it was determined that the front facing camera had shorted causing an electrical fire that damaged the camera and front bumper writing harness along with the engine wiring harnesses. The car has been deemed a total loss due to the fire. The vehicle on has 67000 miles on it to date.