2016 Ford Explorer: steering wheel locks up

Filed Sep 9, 2025 · Steering · IN

The car had ongoing issues with a warning sensor that stated Steering Fault - Service Now. There was also a clinking noise when driving straight and then turning right. Took car to dealer repair show and they ran a diagnosis report (I assume they did). It was reported that it was an internal fault with strut bearings and installed a bracket that was suppose to remedy the issue. Since then I would get the Steering Fault warning but it would happen and then not show up for several months. Recently 8/2025 the error message showed up again while driving about 30 mph. At that time my steering locked. I turned off the car and started it again and it seemed fine. My husband and I test drove it short distances and there was no issues. Then I drove it down the road that I was on when it happened a couple days earlier (since it was a hilly road I thought it caused something to come loose thence the warning). I stopped at a vegetable stand and when restarting the car I received the steering warning again. I turned the car off and then on and proceeded down the road. Within a few feet the warning flashed on and also warning that said Service Advance Trac and Hill Start Assist Not Available and Terrain warnings. I took the vehicle back to the dealership again 9/4/2025 at this time I had 93,300 miles on it. They ran a diagnosis report on it and said I needed to replace the Steering Rack at a cost of over $4000.00 plus fees for alignment, etc. FIRST OF ALL - I think this should have been diagnosed when the car was in for steering issues in 2022 - Especially since Ford was aware of issue with the Steering Rack and it is a serious safety issue. SECOND - There should have been a safety recall for Steering Racks on these vehicles. I'm only fortunate that this did not happed when driving on a highway higher speed.

Filed Jun 7, 2025 · TX

Was driving on the highway at an high speed and abruptly received a message “power steering failure” the steering wheel locked up. After a few seconds I was able to find a way to safely maneuver lanes but it was very difficult to maintain control Of vehicle. Upon re starting car the error popped up again and the wheel is now completely locked. Upon conversation with a family member about the occurrence we found out this happened to their car as well. Same make year and model. Upon research this sounds to be a problem in the 2016 Explorers and is a major safety concern. This could have ended extremely badly.

Filed Oct 4, 2024 · Steering · 189,000 miles · TX

The contact owns a 2016 Ford Explorer. The contact stated that while driving 75 MPH, the steering wheel locked inadvertently. The message "MultiTaction Failure" was displayed. The vehicle was towed to an independent mechanic. The vehicle was not diagnosed or repaired. The local dealer was not contacted. The manufacturer was notified of the failure and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 189,000.

Filed Sep 26, 2024 · Steering · 110,000 miles · TX

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the steering wheel seized with the power steering warning light illuminated. The contact stated that the steering wheel became difficult to turn. The vehicle was taken to the dealer where it was diagnosed that the power steering had failed, and the steering wheel needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 110,000.

Filed Aug 1, 2024 · Transmission · MI

While driving vehicle down the road, steering locked up. Vehicle was taken to the dealer and diagnosed as a bad rack and pinion. This vehicle has 84,000 miles and should not already have issues with the rack and pinion. This incident, could have put my family and many other people's lives/vehicles at risk.

Filed Jul 17, 2024 · Steering · MO

July 17, 2024 A little over a week ago steering system on my 2016 Ford Explore started making grinding noises when turning steering wheel. Steering started to feel " tighter " or stiffer when turning. There were no warning lamps or messages or other symptoms prior to the failure. Took it to the dealership where vehicle was purchased. Service advisor came out and verified there " seems " to be a problem but can't get the vehicle in until August 5. I am concerned about the danger of the steering system locking up while driving and asked him about it and advisor only said " just have it towed in " . In my opinion this is an extremely dangerous defect !!! If the steering locks up it certainly could cause the vehicle to veer into on coming traffic resulting injury or death. Who then is responsible for this defect and it IS a defect in the rack and pinion. I have been doing research about this problem and have found not just a few but many, many, customers with the same problems with repair costs ranging from $2,500.00 - $5,000.00 and apparently a huge shortage of parts 2016 Explorers.

Filed Jul 12, 2024 · Steering · 136,000 miles · MI

The contact owns a 2016 Ford Explorer. The contact stated while driving at an undisclosed speed, the power steering failed to function as intended. The contact heard a squeaking sound while steering the vehicle. In addition, the contact stated that several unknown warning lights were illuminated. The contact stated that the steering wheel seized, and the vehicle became undrivable. The contact stated that the failure had occurred twice. The vehicle was taken to an independent mechanic where it was diagnosed with power steering assist assembly failure. The contact was informed that the power steering assist assembly needed to be replaced. The vehicle was not repaired. The contact was informed that the parts were on back order. The manufacturer was made aware of the failure. The failure mileage was approximately 136,000.

Filed May 21, 2024 · Steering · 147,000 miles · KY

The contact owns a 2016 Ford Explorer. The contact stated that while driving at an undisclosed speed, and making a turn, the steering wheel seized, and the contact struggled to regain control of the steering wheel. In addition, the contact noticed a grinding sound while making a turn. The vehicle was taken to the dealer where it was diagnosed with a failed rack and pinion. The contact was informed that the rack and pinion needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and the contact was advised to report the failure to the federal safety agency Hotline. The failure mileage was approximately 147,000.

Filed Mar 9, 2024 · Steering · CA

Our 2016 Ford Explorer suddenly the steering started making a loud grinding noise while rotating the steering wheel. The noise is anytime you move the steering wheel left or right parked or moving. The steering wheel locks up without warning while driving making it momentarily impossible to move and dangerous while driving. The explorer was diagnosed as a faulty steering rack and pinion assembly with is electronic assisted. No warning lights are illuminated on the dash.

Filed Sep 12, 2023 · Steering · MI

Steering locks up at high way speeds, cannot turn wheel on any direction. I have had a close call to a head on collision on the road way because I could not turn my wheel. Previous years of this model and have the reported issues, multiple online threads of this same model or newer with this issue also. I pay monthly for a car I can’t safely drive, it will get me or someone else killed. It’s a $3000+ repair and ford refused any financial assistance for something they know is a common issue! This car is going to kill someone!!!!

Filed Sep 6, 2023 · Steering · NE

The steering began making a rubbing noise for a day and the next day the rack and pinion steering completely froze up, not able to turn steering wheel at all. The vehicle was in my driveway when the steering froze so there was no accident however this could have been fatal had this happened on a street or highway, there would have been no way to avoid another vehicle or object. My vehicle was towed to C&C Auto who replaced the steering unit with an original Ford part.

Filed Aug 21, 2023 · Seat belts, Steering · NC

#1-My rear passenger seatbelt is being cut by some thing down inside of the back seat where the belt is retrieved. This belt is getting more cuts as it is being used since that is where my Grandson now sits. It was not used prior to me having to pickup my Grandson. This is very concerning !!! #2 My drivers side front windshield weather stripping keep popping out and is now blown off, very scary. #3 Just last week I started to hear some popping noise in the front suspension, but could not tell what it was coming from. Just yesterday while making a right hand turn the front suspension and the steering locked up. I was able to turn it back straight after a few seconds as the steering wheel had locked to the right. Praise God there were 3 lanes and I was able to make the correction with out incident.