2014 Ford F-150: stuck in gear or won't shift

Filed Sep 15, 2026 · Transmission · NC

Keeps going into limp mode, codes are pointing to lead frame, a lot of sensor A codes. Rough shifting from 1st to 2nd as well as sudden down shiffting.

Filed Aug 24, 2026 · Transmission · 160,000 miles · OR

The contact owns a 2014 Ford F-150. The contact stated that while driving 50 MPH, the RPM increased with the transmission stuck in second gear. There was an abnormal sound coming from the transmission. The vehicle was pulled over, the ignition was turned off, and the vehicle was restarted, and the vehicle operated as intended. No warning light was illuminated. The vehicle was taken to the dealer to be diagnosed, and the contact was provided an estimate for the diagnostic test. The vehicle was then taken to an independent mechanic to be diagnosed, and the contact was informed that the output shaft speed sensor and the valve body needed to be replaced. The vehicle was not repaired. The vehicle was serviced under the federal safety agency Campaign Number: 24V444000 (POWER TRAIN) by the owner of the vehicle, but the remedy failed to prevent the failure. The contact stated that the failure had occurred after receiving the recall repair. The manufacturer was notified of the failure and informed the contact that, since the recall was already performed, the additional repair would be an out-of-pocket expense. The failure mileage was 160,000.

Filed Aug 20, 2026 · Transmission · IN

The contact owns a 2014 Ford F-150. The contact stated that while driving at an undisclosed speed, the wrench warning light illuminated, and the transmission unexpectedly downshifted to third gear. Additionally, the vehicle immediately went into LIMP Mode and failed to accelerate as needed. The contact associated the failure with the federal safety agency Campaign Number: 24V444000 (Power Train); however, the VIN was not included. The dealer was contacted and diagnosed the vehicle with molded leadframe failure. The vehicle was repaired. The manufacturer was made aware of the failure. The failure mileage was unknown.

Filed Aug 6, 2026 · Transmission · SC

While driving, the malfunction indicator light (yellow wrench) will illuminate, followed by a complete loss of communication between the instrument cluster and the transmission. The speedometer immediately drops to zero even though the truck is still moving, and other information, such as the fuel range, goes blank. The truck will also struggle to accelerate from a stop, almost as if it is starting in second gear. If I shut the truck off and restart it, everything returns to normal. Before the malfunction light comes on, the transmission will often make a very hard downshift or remain stuck in first gear and refuse to shift as speed increases. After a few seconds, the warning light appears, communication is lost, and the transmission shifts again, often very harshly. This seems to happen more often at lower speeds. This creates a serious safety risk because I lose all knowledge of my speed while driving, and the transmission may not respond properly when pulling into traffic or trying to reach a safe place to pull over. The dealer is aware of the problem. Recall 24S37 was supposed to correct it, but it did not. Recall 26S45 acknowledges that the original repair was not effective for all vehicles, but my VIN is not included even though I am experiencing the same failure. I have reported the issue to the dealer multiple times by phone and through their online service system. A dealership representative told me I am not the only customer experiencing this problem, but the dealer has not inspected the truck since completing Recall 24S37 and has not taken action or returned my calls. The malfunction indicator light consistently appears about four seconds after the transmission begins acting abnormally and immediately before the instrument cluster loses communication with the transmission. I am now nervous to drive the truck, especially from a stop or at lower speeds, because I never know when the problem will occur.

Filed Aug 3, 2026 · Transmission · KS

Vehicle Information: Year: 2014 Make: Ford Model: F-150 Component: Power Train (Transmission / Powertrain Control Module) Dealership Involved:Midway Motors Ford, 2075 E Kansas Ave, McPherson, KS 67460 Complaint Description:I am filing a formal safety complaint against Ford Motor Company and Midway Motors Ford in McPherson, KS, for failing to provide a free remedy under active federal safety recall 24S37 (the federal safety agency Campaign 24V444).My 2014 Ford F-150 was brought to the dealership to complete safety recall 24S37, which addresses severe, sudden transmission downshifts. The dealership performed a software update to the Powertrain Control Module (PCM). Immediately following this update, the truck's drivability severely deteriorated, and the transmission began violently slamming into 3rd gear, locking itself into a dangerous transmission fault "limp mode." The diagnostic scans post-update indicate a failure of the molded lead frame/speed sensor. According to Ford's official technical service bulletin for recall 24S37, physical replacement of the molded lead frame is an explicitly authorized remedy when diagnostic codes appear following the software flash. However, both the local servicing dealership (Midway Motors Ford) and Ford Corporate Customer Service are actively refusing to perform this physical safety repair free of charge. They are wrongfully claiming that because my vehicle has over 200,000 miles, it is disqualified from financial assistance. They are confusing a federal, non-expiring safety recall with an older, expired warranty extension program (19N01).By refusing to replace the defective lead frame that their own software update triggered into an active failure state, the manufacturer and dealer are leaving my vehicle in an unsafe, undrivable condition and violating federal recall mandates. I request that the federal safety agency intervene to compel Ford to complete the mandatory safety recall remedy at zero cost to me.

Filed Jul 21, 2026 · Transmission · NC

I brought my 2014 Ford F-150 to Gentilini Ford in Woodbine NJ in response to recall notice number 24S37 on XXX for an issue with the molded leadframe on the 6R80 transmission. The recall gave the option of reprogramming the existing leadframe or replacing the leadframe. My leadframe was reprogrammed and not replaced. Shortly after the recall while driving back to [XXX] from NC, the transmission dropped into first gear while cruising down a narrow road causing the back tires to chirp. Several dash lights then came on and the transmission went into limp mode which included rough shifting, sluggish starts, no speedometer or several gauges. When I made it to a point where it was safe to pull over, I immediately turned off the truck and did a visual inspection to make sure there was no damage. I returned to my truck began researching the issue online and quickly realized that it was caused by the actions taken during the recall. I placed several calls to Ford with no recourse. In late May of 2026, I learned of a new recall aimed at the correction of the recall and Ford was replacing the leadframes that were reprogrammed. Upon further research, I learned that late year 2014 f-150's with the 6R80 transmission were not included in the recall. I am reaching out for help in forcing Ford to include my truck in the recall. The issue happens almost every time I drive now and will eventually reset back to normal mode after several stops and restarts. It is a very dangerous situation when my speed drops dramatically on the narrow roads of North Carolina. There are no shoulders on the roads and the only place to pull over in the majority of situations is into a drainage ditch. Please help!!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 24, 2026 · Transmission · SC

I am filing a safety complaint regarding my 2014 Ford F-150 XLT equipped with the 6R80 transmission. My vehicle previously received Recall 24S37 in 2024 for the known transmission downshift safety defect involving Output Shaft Speed (OSS) sensor signal loss. Despite completion of the recall repair, my vehicle is now exhibiting the same dangerous symptoms associated with the recall condition, including: • Sudden erratic transmission behavior• Speedometer intermittently dropping to zero while driving• Wrench warning light activation• Check engine warning light• Airbag warning light• Unsafe drivability conditions and intermittent limp mode operation These symptoms create a serious safety concern because the vehicle unexpectedly changes driving behavior and loses speed signal information while operating on public roads. I presented the vehicle to Dick Smith Ford in Columbia, South Carolina for evaluation and was informed the truck requires a complete transmission replacement estimated at approximately $11,000. After extensive research, I discovered many Ford truck owners nationwide reporting nearly identical symptoms involving the 6R80 transmission, molded lead frame failures, OSS sensor failures, and unintended downshifting conditions. Ford previously acknowledged similar issues in Recall 24S37 and Customer Satisfaction Program 19N01. I am concerned the original recall remedy may not fully address the underlying hardware failure associated with this transmission system. My vehicle is demonstrating the same safety-related symptoms after the recall repair was already completed. Vehicle Information:2014 Ford F-150 XLTVIN: [XXX] I respectfully request the federal safety agency review this issue for continued safety concerns involving the Ford 6R80 transmission system and post-recall failures associated with Recall 24S37. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 5, 2026 · Engine, Transmission · OH

My 2014 Ford F150 truck went into “limp mode” last week. A wrench showed up on my dashboard, my speedometer didn’t function, and it sounded like the transmission was “winding up” if I tried to accelerate. After hitting “ok” to remove the wrench and restarting the truck a couple of times, my check engine light illuminated. I was driving at about 40 MPH when this occurred and it was a scary moment. Luckily I was able to keep my truck under control and drove very slowly back home considering I was less than 4 miles from my home. The truck went into a Ford dealership in 2024 for the “transmission recall” in which the only thing I noticed different was that I couldn’t see the digital shifting of the transmission on the screen anymore and they “killed” my battery. I still had issues every so often with power loss or the transmission shifting down abruptly, but it wouldn’t throw a code. Last week it threw a code. P0720 to be exact, the reason for the transmission recall in the first place. There was no fix done with the recall and it made it so that I had to watch my RPM’s to track my transmission shifting. This is extremely concerning especially since I was having the issues prior to a computer reprogram and it wasn’t addressed. I have also seen that there’s yet another Ford transmission recall that could affect my truck considering it was assembled in June 2014 and fits the transmission 6R80 that needs fixed. Could someone please help? Thank you.

Filed Apr 6, 2026 · Transmission · 156,484 miles · HI

The contact owns a 2014 Ford F-150. The contact stated that while driving at an undisclosed speed, the vehicle unexpectedly went into LIMP Mode several times, with the powertrain warning light illuminated. The vehicle was restarted after each failure. The vehicle was taken to the dealer several times; however, it was not diagnosed or repaired. The contact stated that the failure started after the vehicle was repaired under the federal safety agency Campaign Number: 24V444000 (Power Train); and the software update was performed. The manufacturer was made aware of the failure. The approximate failure mileage was 156,484.

Filed Mar 14, 2026 · Steering · MI

I am aware this year f150 had issues with steering recall. My model did not come up as recall. However, I twice have had steering issues. On 04/26/24 I had the steering assembly repaired, car went into limp mode while driving. It cost $1,505.45 for the parts and it had to be reprogrammed at dealership $225.00. Total was $2,359.14. Now this week 03/10/2026 the steering is hanging up again and it is in shop. It seems odd my truck was not part of the recall. As longtime Ford buyer and relative of many Ford employees around Detroit, this is disturbing. Especially with STEERING !!!!! I will try to attach prior receipt.

Filed Feb 17, 2026 · Transmission · CO

My 2014 F-150 with the 5.0 is currently at the ford dealership getting the output speed sensor replaced in the transmission. This is already a recall item on the vehicle, however it is not showing up as a recall fix. This will send your truck into “limp mode” causing you to have to pull over in unsafe spots on the road in order to shut the vehicle off. And back on to get the truck to drive correctly. I am now responsible for paying for this replacement, when it’s clearly a manufactured error

Filed Oct 30, 2025 · Transmission · NY

Took in my vehicle to my local Ford Dealership after I experineced sudden downshift of the transmission and getting stuck in 1st gear. I asked for a reantal vehicle or a loaner to which they said, it would depend whether or not there would be any PCM related codes that came back after connecting the car. According to them no codes came back, and explained to me that, that being the case that they would just need to reprogram my PCM. The next day I went and picked up my truck, and after just about roughly 7 miles into driving, I started experiencing sudden downshift again and my truck started slowing down rapidly almost causing an accident and getting rear ended. I was able to pull over and noticed this time my truck had gotten stuck in 4th gear. I was able to drive it back to the dealership and left it parked in the their parking lot as it was after hours at this point. The very next morning by 7:30AM I was at their service desk explaining what had happened the night before after picking up my truck from them. They refused to give me any further service as they said that they had already completed the service related to the 24S37 recall, and that if I continued to experience issues, that it was a completly unrelated issue and if I wanted to get it diagnose and repaired that it would be out of pocket. After doing more reserach online, I came to find out that on some of this recall issues related to 24S37, in some cases the dealership would have to replace the entire Lead Frame which holds the Transmission output shaft speed sensor which goes bad and causes the transmission to go crazy and thus the downshifting, and in other cases they don't have to replace this part. In my case, while there were no other codes that showed, they determined that only a reprogramming was necessary. However, given that I continue to experience the same sudden downshift issues, I suspect that it is a bad output shaft speed sensor which should be replaced under the current safety recall.