2014 Kia Soul: fire, smoke or burning smell

Filed Jul 17, 2026 · Electrical, Engine · 107,000 miles · NY · fire · 1 injury

The contact owned a 2014 Kia Soul. The contact stated that while stopped at a traffic light, the contact became aware of a burning rubber odor and observed grey and brown smoke coming from underneath the front end of the vehicle. The contact stated that a fire had started underneath the front of the vehicle. The local Fire Department arrived on scene and extinguished the fire. A fire report was not filed. A Police report was filed. The vehicle was deemed a total loss. While exiting the vehicle, the vehicle continued rolling and the rear driver’s side tire ran over both feet. The contact had two severely bruised feet; however, medical assistance was not sought. The vehicle was not towed or taken to a dealer or an independent mechanic to be inspected. The dealer was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was 107,000.

Filed Jun 16, 2025 · Engine · NY

In 2023 I had my car repaired at a Kia dealership due to the federal safety agency Recall Number: 19V120, KIA Customer Care Case Number: [XXX]. It mentioned in recall that the engines may need to be replaced. Even though the engine had made grinding noises when I brought the vehicle in for repair on that recall, the Kia dealership told me my engine did not need to be replaced. However, on [XXX] as I was driving, the car began making loud grinding noises, the check engine & oil light came on and white smoke was coming out of the back. I immediately pulled into a gas station & shut the engine off. After waiting several minutes, I tried to restart the engine and it would not start. The battery had gotten weak. I got a jumpstart from a customer at the gas station, and when the engine turned over a large cloud of white smoke came out of the back, so I turned it off again and called for roadside assistance who towed the car to my home. I had the vehicle towed to a local garage on 6/14/2025. I believe this engine failure is part of the ongoing issues with defective Kia engines. And also stems from the issues from the recall mentioned above because when I took the car to the service center for that recall, it was vibrating and making a lot of noise at that time, and I believe damage had already started to happen to the engine. I contacted Kia 6/16/2025 and they claimed that I was out of warranty and that everything would be out of my pocket, but I think this engine should be covered under all the recalls and the class action lawsuits because it’s a safety hazard when your car shuts down in the middle of a highway. I never received any letters from Kia except when I contacted them about the federal safety agency Recall Number: 19V120. The case number for that issue is Case Number: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) Vehicle is at local garage.

Filed Feb 28, 2025 · Brakes, Driver assistance · 96,806 miles · OK

The contact owns a 2014 Kia Soul. The contact stated while driving approximately 30 MPH, the ESC warning light illuminated and turned off and on. The contact was concerned that the vehicle might catch on fire while parked or while driving. The contact stated that the failure was related to the federal safety agency Campaign Number: 23V652000 (Service Brakes, Hydraulic). The vehicle was taken to the local dealer, where it was diagnosed that the hydraulic electronic control unit needed to be replaced. The part was ordered, but the vehicle was not yet repaired. The manufacturer was not contacted. The failure mileage was approximately 96,806.

Filed Oct 22, 2024 · Engine · MI · fire · 1 injury

On [XXX] my 2014 Kia Soul caught on fire while I was at a gas station. There had been no warning lights, however when I first started it that day it acted like it didn't want to start. A man ran in the gas station and got their fire extinguisher and put the engine fire out. I called 911 , and when the fire department inspected it they said the fire was completely out. They filed a report and I had my car towed to Glassman Kia Southfield Michigan. It's been there since August 31st, and they still haven't told me what caused my fire. I've been in contact with KIA America in California and have been getting nothing but what seems like a snow job. The car is available at the car dealership for inspection, but only God knows if they have inspected it yet. I am [XXX] with no transportation for almost two months. This is just wrong. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 3, 2024 · Engine · NC · fire

While driving, the engine failed and began to smoke then was on fire.

Filed Jan 2, 2024 · Engine, Steering · CA

i received notice in the mail that there are recalls on my car prior to receiving the notice i had recently got an oil change and i was informed that there is a little leaking and in recall number 20V750 the car can possible catch on fire so i waited for my appointment with the dealer it was inspected and they did not fix leak i had paperwork however i dont know what this [XXX] means what i do know is when i got my car back i was not operating correctly and the check engine light is on and it was not on when i dropped my car off to them i have made at least 5 phone calls reaching out to the dealer and i have not talked to anyone. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 27, 2023 · Engine · 118,006 miles · OH · fire

The contact's neighbor owned a 2014 Kia Soul. The contact stated that while the vehicle was parked in his neighbor’s garage, another neighbor noticed smoke coming from the walls of the garage. The contact then stated that his neighbors were awakened by another neighbor alerting them of the fire. The contact’s neighbor was able to exit the home and notified the fire department that extinguished the fire. No injuries were sustained. No medical attention was required. A police and fire report was filed. The vehicle was towed to a tow lot and deemed a total loss by the insurance company. The vehicle was inspected by an investigator who determined that the fire was started in the engine compartment. Additionally, the contact stated that prior to the failure, on three separate occasions, while his neighbors were driving at undisclosed speeds, the vehicle stalled without warning. No warning lights were illuminated. The vehicle was towed to the dealer where it was diagnosed that oil had leaked profusely from an unknown location and the catalytic converter had failed and needed to be replaced. The vehicle was repaired three times. The contact stated that the vehicle was repaired however, the failure recurred. The contact then stated that upon research, the VIN was included in the federal safety agency Campaign Number: 20V750000 (Engine). Neither the dealer nor the manufacturer were notified of the failure. The failure mileage was approximately 118,006.

Filed Jul 19, 2023 · Engine, Locks · 132,000 miles · AR · fire

The contact owned a 2014 Kia Soul. The contact stated that while driving at approximately 60 MPH, a pinging-type noise was heard coming from the engine compartment along with gray smoke. The vehicle began to lose automotive power and reduced speed before the engine stalled. The contact exited the vehicle and flames and smoke were present coming from under the hood. The fire department was called to the scene and extinguished the flames. A fire and police report was taken at the scene and the vehicle was later towed away. During the incident, the vehicle was destroyed. The contact also indicated that during the incident the front driver's side door could not be manually opened from inside the vehicle and the key fob was used to open the door. The cause of the failures was not determined. The manufacturer was notified of the failure. The local dealer was not contacted. The failure mileage was 132,000.

Filed Apr 20, 2023 · Electrical, Engine · MI

Since I bought this car, I have experienced hesitation, stalling, high RPM idle, fluctuating idle, burning smell, lurching, running though gas very fast (not due to increased driving), engine noises, dash panel half lighting up, hard to accelerate when the headlights are on, or heat, or air con, odd noises..and through this entire time, check engine light comes on and off and on and off...along with my gas gauge saying empty when its full. I have reported ALL of this throughout the entire time since all bought it. Every single time they say "software update" and send me home with nothing ever fixed. EVER. Now again check engine and false fuel reading, hesitations, etc....again! This engine and fuel pump is bad and explains all of my complaints since 10kmiles. My car has under 80k mi on it, its been a lemon from the start. Hesitation with no pick-up at an intersection and noises....just beyond dangerous. I have not driven my car on the freeway in 5 years because itis not safe, but Kia NEVER checks out problems. They charge for inspection and say "software update". Its maddening.

Filed Apr 3, 2023 · Engine, Fuel system · IN · fire

check engine light came on the evening of 3/08/2023. Auto zone said it was a knock sensor code and was listed as a recall. Next morning while driving on highway to ft Wayne Kia dealership my car engine lost rpm while driving at 65 mph on i-69 chapel exit in ft Wayne indiana. The car engine compartment almost immediately ignited into flames with an explosion. Driver barely got out before fire was in the dash. The front interior dash and front seat areas were caught on fire. Shrapnel blown from car started a grass fire as well. The fire department arrived to get both fires under control. My car was still under warranty at 108 months and 89,000 miles. Never had any problem with my Soul until that next day after light came on. I was not notified of the recalls except only recently received an airbag recall on 3/30/2023. I have contacted Kia to file a claim with them.

Filed Jan 30, 2023 · Brakes, Transmission · NY · fire

Friday January 20th, 2023 while on the freeway my 2014 Kia Soul with less than 75,000 miles spontaneously caught on fire. While merging over to the side of the road the breaks and throttle were inoperable. I was very fortunate that I did not suffer any injuries though it was a very close call. My safety was put at risk as I was unable to maneuver the car over to the side of the road while maintaining the flow of traffic due to the accelerator failure. Once near the shoulder of the road I was unable to stop the car due to the breaks failure which increased the amount of time I was exposed to the burning car and smoke. The problem has not been reproduced or inspected by the dealer, police, and insurance. There were no warning light before or after the fire was identified. The car was professionally maintained and was in great condition prior to this event.

Filed Jan 27, 2023 · Acceleration, Engine · TX

I own a Kia Soul. The catylitic converters went out. The car won't accelerate and the car got extremely hot. When I looked up Kia Soul recalls it showed that there was a recall on the converters also that some Kia Souls had gotten hot an caught on fire. I called Parkway Family Kia. They told me that it wasn't an active recall and that they couldn't do anything. I then called Demontrond Kia and got the same answer. I talked with the service manager Brian. What can I do to resolve this?