2022 Ford F-150: check engine light

Filed Aug 27, 2026 · Engine, Fuel system · OH

While driving, my 2022 Ford F-150 equipped with the 2.7L EcoBoost experienced abnormal engine operation, a check-engine light, and reduced engine power. The unexpected reduction in available engine power created a safety concern because loss of acceleration or propulsion can be dangerous when merging, crossing traffic, passing, or traveling at highway speeds. The vehicle was inspected and diagnosed by an authorized Ford dealership. The PCM stored DTC P0332, Knock/Combustion Vibration Sensor “B” Circuit Low. The dealer performed Ford Pinpoint Test DG. Testing reportedly found no open circuit, short to ground, short to voltage, or intermittent circuit fault. The dealer determined that the knock-sensor assembly required replacement.The repair involves replacement of Ford knock-sensor assembly FT4Z-12A699-E, which contains both knock sensors. Access to the assembly requires extensive disassembly of engine fuel and cooling-system components. Ford’s service procedure includes removal of both direct-injection fuel rails, draining the cooling system, removal of the coolant pump, and removal of the coolant outlet connector.I am concerned about the possibility of coolant leakage or contamination affecting the knock-sensor assembly because of its location in relation to cooling-system components. I do not currently know whether coolant contamination caused this particular failure. I request that the federal safety agency investigate whether coolant leakage or contamination in this area contributes to premature knock-sensor failures on 2.7L EcoBoost engines. I have also identified another 2022 Ford F-150 with the 2.7L EcoBoost that was diagnosed by a Ford dealership with a similar knock-sensor circuit-low fault, P0327 also quoted replacement of the same FT4Z-12A699-E assembly. I request investigation knock-sensor failures on 2.7L EcoBoost F-150s, including Ford warranty/field data and whether coolant leakage or contamination contributes to failures capable of causing unexpected reduced engine powe

Filed Aug 10, 2026 · Electrical, Engine · 29,043 miles · MS

The contact owns a 2022 Ford F-150. The contact stated that while driving approximately 55-65 MPH, the vehicle stalled. The check engine and battery warning lights were illuminated. The contact associated the failure with the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline). The vehicle was towed to an independent mechanic, and the failure was associated with the recall and a diagnostic trouble code related to the ECM reprogramming for the fuel system. The vehicle was towed to the local Ford dealer, who diagnosed the vehicle with a fuel system failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 29,043.

Filed Jun 26, 2026 · Fuel system · 15,000 miles · AZ

The contact owns a 2022 Ford F-150. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the vehicle was idling rough. The dealer was contacted and informed the contact that it was a common failure associated with the recall, but parts were not yet available for the repair. The contact was advised to keep the fuel tank more than half full and to not drive the vehicle in extremely hot weather. Additionally, the contact stated that while driving 55 MPH and hauling a loaded 12 ft. trailer in the desert, the check engine warning light illuminated, and the vehicle stalled. The contact was able to pull over to the side of the road. The vehicle was towed to the residence. The vehicle was then towed to a second dealer, Jones Ford Casa Grande (2425 E Florence Blvd Ste A, Casa Grande, AZ 85194), where it was diagnosed and determined that the fuel pump had failed and needed to be replaced at the owner's expense because parts for the recall repair was not yet available. The contact was informed that reimbursement would be provided once parts became available. The contact was waiting for the dealer to confirm whether the repair was covered under the extended warranty. The vehicle was not yet repaired. Additionally, the contact stated that the fuel economy rate failed to match the advertised rate. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not contacted. The failure mileage was approximately 15,000.

Filed Feb 5, 2026 · Engine, Fuel system · AZ

When driving the gas pedal will go dead or not work at all. I will be driving along then try to push the gas at a left hand turn and nothing will happen. I push the pedal to the floor many times and after a period of time it starts to work again. The issue never puts out a code or check engine light. This is a safety issue for not only me and my family but others on the road as well. If the gas pedal was to fully stop working the truck would be stuck and could cause an accident. The dealer told me they could not reproduce the concern, but they did suggest to replace a temp sensor and reprogram PCM which I paid for, the cost was $870.90

Filed Nov 21, 2025 · Transmission · CA

Loss of engine coolant resulted in overheating and need to pull off to side of highway. Issue is described in the SSM - 51485 described below 2021-2023 F-150 - 3.5L PowerBoost - Loss Of Engine Coolant Due To External Coolant Leak At The Heat Exchanger Coolant Spigots Some 2021-2023 F-150 vehicles equipped with a 3.5L PowerBoost engine may experience a loss of engine coolant with possible engine overheat and/or illuminated malfunction indicator (MIL). This may be due to a crack in the exhaust heat exchanger coolant spigots on the top of the exhaust heat exchanger. The exhaust heat exchanger coolant spigots are now released and should be serviced in pairs. It is no longer necessary to replace the muffler inlet pipe assembly for this type of concern. Workshop Manual, Section 309-00D has been updated to include a new service procedure. For claiming, use causal part 18663 and applicable labor operations in Section 05 of the Service Labor Time Standards (SLTS) Manual. Heat exchanger coolant spigots - NL3Z-18663-A (2 req).

Filed Nov 13, 2025 · Engine, Fuel system · 60,000 miles · MN

The contact owns a 2022 Ford F-150. The contact stated that while driving at 55 MPH, the vehicle lost power and stalled on several occasions, but the vehicle was restarted. The check engine warning light was illuminated. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline). The vehicle was taken to the local dealer, who confirmed the parts were on back order. The dealer informed the contact about a diagnostic test. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 60,000.

Filed Oct 10, 2025 · Transmission · FL

Transmission malfunctioned leaving me with stuck in an intersection with no power, has down shifted unexpectedly on the highway causing the truck to slow down out of nowhere, also very rough shifts at low speed. No warning lights on the dash, problem appeared intermittently but was confirmed by AutoNation Ford St Petersburg location by Ford tech. Took it to an independent transmission specialist and they also confirmed the failure and found large metal chunks in the transmission oil pan. I am out of warranty and even though it was still drive able and not giving a check engine light, I opted to replace the transmission out of pocket due to safety concerns.

Filed Aug 4, 2025 · Fuel system · TX

We were told, our truck had a loss of fuel pressure and flow from the fuel tank due to fuel pump failure. This can cause a lack of fuel delivery to the engine and result in an engine stall while driving. That’s what happened to us. Prior to fuel pump failure, we experienced poor engine performance (misfiring or running rough), a check engine light, and a reduction in engine power. The engine stalled while driving on the highway and increased the risk of a crash being stuck on the side of the road up a hill like we were. I was reaching out to see if we are able to get a refund.

Filed Aug 1, 2025 · Fuel system · CA

My truck is/has been experiencing engine power issues on occasions when its hot. There are no engine light warnings. I believe issues is the fuel pump and there is a recall about this exact issue. I spoke to dealership and they said they have no remedy. I chatted with a Ford company customer service associate and he would not help either despite this is a major safety issue. We are afraid to drive the vehicle and no one at Ford will help us.

Filed Jul 21, 2025 · Brakes, Engine · 47,000 miles · PA

The contact owns a 2022 Ford F-150. The contact stated the parking brake was intermittently illuminated. The contact stated that the vehicle was shaking and vibrating abnormally while depressing the brake pedal. The contact stated that the VIN was included in the federal safety agency Campaign Number: 23V509000 (Parking Brake), which stated that the wiring harness needed to be replaced. The dealer determined that the failure was caused by the recall. The dealer also determined that the rotors needed to be replaced. The rotors were replaced. The contact stated that the rear brake rotors were replaced three times. The dealer informed the contact that the recall was considered completed and had not replaced the harness but secured the existing harness with a zip tie. The contact stated that approximately one year later, the parking brake light started to illuminate intermittently. The dealer was informed; however, the vehicle was not repaired. The contact stated that the check engine warning light illuminated while the fuel tank was full. The contact stated that the check engine warning light was intermittently illuminated. The vehicle was taken to a certified mechanic, who diagnosed that the knock sensor had failed and needed to be replaced. The vehicle was not repaired. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was contacted. The manufacturer was made aware of the issue. The failure mileage was approximately 47,000. VIN tool confirms parts not available.

Filed Mar 12, 2025 · Acceleration, Driver assistance · GA

There are several issues with the truck, the worst being misfire issues while driving at highway speeds. Several times now I have been on the interstate at speeds and the truck will all of a sudden lose speed and shutter. The engine light will blink, and this will happen for a couple miles and then it goes back to normal. If you pull the codes on the truck, you get P0300, P0301, and P0305. This is in the dealership again now. The previous two times the dealership has done nothing because they can not duplicate the issue, but they do pull the codes.

Filed Aug 26, 2024 · Transmission · 70,000 miles · MI

The contact owns a 2022 Ford F-150. The contact stated while operating the vehicle, the check engine warning light had remained illuminated, and the vehicle would not properly accelerate while depressing the accelerator pedal. Additionally, while driving at various speeds, the transmission unexpectedly downshifted. The vehicle was taken to the local dealer who reprogrammed the PCM, but the failure persisted. The contact also stated that while the vehicle was parked, the vehicle rolled. The failure had occurred with the engine running and with the vehicle turned off. The cause of the failure was not yet determined. The local dealer and manufacturer were not yet notified of the failure. The failure mileage was 70,000.