2022 Ford F-150: fuel pump failure

Filed Oct 29, 2026 · Fuel system · PA

I first experienced an issue on this truck in XXX while vacationing in [XXX]. While attempting to cross a 4 lane highway with a median, the truck almost stalled and .was almost T boned. Upon returning to [XXX] the vehicle was taken to my servicing dealer and diagnosed with a fuel pump issue which within a few days was determined in a recall. I have been in constant contact with Ford only to be told no fix is available at this time and to keep the fuel level above a half tank. This hesitation / stalling has occurred many times since this first occurrence. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Aug 23, 2026 · Fuel system · VA

Recall first fuel pump issue unresolved. It has been over a year since recall was issued

Filed Aug 17, 2026 · Fuel system · FL

Failure by Ford to fix a fuel pump issue that has been known since Feb 2025. Should a vehicle stall while being operated due to this issue it could lead to a crash. I would think such a serious safety issue would be addressed and fixed to prevent unnecessary accidents/injuries/death.

Filed Aug 14, 2026 · Engine, Fuel system · TX

My 2022 Ford F-150 has experienced intermittent delayed starting, uneven idle, and hesitation during acceleration. At times, the engine sounds and feels as though it may shut off. I began noticing these symptoms several months ago, and the most recent occurrence was approximately August 2026. I do not recall seeing any warning lamps or warning messages when these symptoms occurred. The vehicle has not yet been inspected or diagnosed by a Ford dealer or independent repair facility for these specific symptoms, and the cause has not been confirmed. The vehicle is available for inspection upon request. I am concerned because my vehicle is affected by Ford Recall 25S75 / the federal safety agency Recall 25V455 involving potential fuel pump failure and loss of fuel pressure, which may result in poor engine performance and engine stalling. I am concerned that the symptoms I am experiencing could create a safety risk if the engine loses power or shuts off while driving.

Filed Aug 3, 2026 · Engine, Fuel system · LA

I purchased a 2022 Ford F150 in September 2024. I began to notice occasional sluggishness when accelerating as the weather warmed up around March 2025. I contacted my local Ford dealership sharing the issue. The service manager suggested I consistently use a high octane fuel, which I consistently do, explaining I may just have "bad gas". The problem continued primarily when I was in heavy traffic with high temperatures. The truck acted as if it had a clogged fuel injector, sluggishness from start, low idle reducing below 1,000 RPM. I contacted a privately owned mechanic shop advising of my idle issues. The mechanic stated he doesn't believe a fuel injector would clog at 50,000 miles. In June 2025 received notification of a recall for my vehicle which I confirmed by VIN. The recall (#25V455) summarized the vehicle could sustain a loss of fuel pressure and flow from the fuel tank due to fuel pump failure. The letter continued, I may experience poor engine performance, rough idle or reduction in power, the same issues I had been complaining about. I contacted the Ford dealership and they explained Ford had not determined how to remedy the problem. Fast forwarding to present, 3 August 2026, over a year since the recall letter and Ford has yet to remedy the problem. What's the hold up? Will Ford finally determine the remedy when my family is killed on the interstate because the vehicles fuel pump fails and it stalls? It appears to be apparent Ford does not want to take the financial hit of such a recall. This is unacceptable and needs to be looked into by the NTSB.

Filed Jun 26, 2026 · Fuel system · 15,000 miles · AZ

The contact owns a 2022 Ford F-150. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the vehicle was idling rough. The dealer was contacted and informed the contact that it was a common failure associated with the recall, but parts were not yet available for the repair. The contact was advised to keep the fuel tank more than half full and to not drive the vehicle in extremely hot weather. Additionally, the contact stated that while driving 55 MPH and hauling a loaded 12 ft. trailer in the desert, the check engine warning light illuminated, and the vehicle stalled. The contact was able to pull over to the side of the road. The vehicle was towed to the residence. The vehicle was then towed to a second dealer, Jones Ford Casa Grande (2425 E Florence Blvd Ste A, Casa Grande, AZ 85194), where it was diagnosed and determined that the fuel pump had failed and needed to be replaced at the owner's expense because parts for the recall repair was not yet available. The contact was informed that reimbursement would be provided once parts became available. The contact was waiting for the dealer to confirm whether the repair was covered under the extended warranty. The vehicle was not yet repaired. Additionally, the contact stated that the fuel economy rate failed to match the advertised rate. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not contacted. The failure mileage was approximately 15,000.

Filed Apr 15, 2026 · Fuel system · TX

Manufacturer Recall Number: 25S75 the federal safety agency Recall Number: 25V455 This recall has been open since July 8th, 2025 with no updates from Ford or the federal safety agency. I am concerned because there is an increased risk of crash at failure, and the bulletin says that the risk is greater in high temperatures. I drive primarily in Texas and the Southwest United States. I have contacted my dealership every few months and they said they have no further information or ways to rectify the situation. I spoke to an the federal safety agency representative who said that I needed to file a report on this site to initiate an investigation since this recall has been open for so long. Reference #: XXX. It seems that Ford should have been able to access fuel pumps for replacement within the last 9 months. I just don't want to wait until it is too late to address. Thank you for your time and attention to this matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 7, 2026 · Engine, Fuel system · OK

Where is Ford at on the recall from like July 2025? the federal safety agency 25V455, safety recall notice 25S75. How long do they have to get a resolution? Seems like they have had plenty of time to resolve this issue. It seems more important than this last recall for a computer update. I can choose not to haul a trailer. I cannot choose for a stall due to loss of fuel pressure and flow from fuel pump failure. I am only curious of how long they are allowed to come up with a solution.

Filed Jan 30, 2026 · Fuel system · WA

See attached document for complaint. Almost 5 months ago I received a Safety Recall Notice from Ford about fuel pump failure on certain vehicles including my 2022 F-150. My vehicle suffers from insufficient fuel flow and I'm afraid of losing power or the motor stopping completely at freeway speeds in heavy traffic with little or no shoulder. The clear solution would be to replace the fuel pump. How can Ford be allowed after almost five months to have not fixed the problem? The fuel pump problem is beyond a reasonable amount of time to take corrective action. The local dealership has not seen a Ford remedy for the problem and I've complained twice about the pump on my vehicle. The dealership hopes to see a remedy each month. I would appreciate a response from the federal safety agency on this very serious safety recall. Almost 5 months surely must be beyond a reasonable time to correct a serious safety issue. Hope to hear from you soon and Thank You in advance.

Filed Jan 28, 2026 · Fuel system · AR

The contact owns a 2022 Ford F-150. The contact received notification of the federal safety agency Campaign Number: 25V455000 (FUEL SYSTEM, GASOLINE); however, the part to do the recall repair was not yet available. The contact stated that while the vehicle was parked, there was a large stain on the ground. The contact moved the vehicle and checked, and became aware that there was a new oil stain on the ground where the vehicle was parked. The vehicle was taken to the dealer, where it was diagnosed and determined that the low-pressure fuel pump had failed. The dealer advised the contact to no longer drive the vehicle due to safety concerns. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The failure mileage was unknown.

Filed Jan 27, 2026 · Fuel system, Transmission · LA

I have two recalls that I cannot get any assistance with Recall # 23S65 Rear Axle Bolt Breakage and new recall #25S75 which is Fuel Pump Riser. I have acquired services from four different dealerships and have taken photos and mileage to get repairs completed. I hear clicking noise in my truck and afraid of it causing serious damage and injury along with my fuel pump issue and bad gas mileage and noises when initial cranking my vehicle. I would like to know what dealership in Southwest Louisiana could I bring my vehicle in to resolve these issues that I have been dealing with close to a year. If not, what dealership will provide me courtesy like vehicle rental until completed. I currently of the Bubba Ostalet Ford 246 N. Broadway St. Jennings, La 70546.

Filed Dec 26, 2025 · Engine · MI

There is a recall for the low pressure fuel pump that has been active since July of 2025 and there is still not resolution. This truck is not usable due to the issue.