2022 Ford F-150: engine stalls while driving

Filed Oct 29, 2026 · Fuel system · PA

I first experienced an issue on this truck in XXX while vacationing in [XXX]. While attempting to cross a 4 lane highway with a median, the truck almost stalled and .was almost T boned. Upon returning to [XXX] the vehicle was taken to my servicing dealer and diagnosed with a fuel pump issue which within a few days was determined in a recall. I have been in constant contact with Ford only to be told no fix is available at this time and to keep the fuel level above a half tank. This hesitation / stalling has occurred many times since this first occurrence. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Oct 28, 2026 · Transmission · WA

My transmission hard shifts and stalls out. It was also low on fluid in January 2026, but it was not leaking. When pulling out from intersections with oncoming cars the transmission stalled. It has also stalled on the freeway. Yes, a ford dealership confirmed it. No warning lamps. I was told ford probably won’t cover the whole cost of this repair even though it’s a known issue

Filed Sep 3, 2026 · Fuel system · 78,500 miles · MS

The contact owns a 2022 Ford F-150. While the contact’s daughter was driving 5 MPH and turning left from a four-way stop sign, the vehicle stalled. The accelerator pedal was continuously depressed to drive the vehicle to the residence. The contact notified the dealer of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline). The vehicle was towed to the dealer, and the vehicle was diagnosed with transmission failure pending the repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was contacted via e-mail and was made aware of the failure. The failure mileage was approximately 78,500.

Filed Aug 17, 2026 · Fuel system · FL

Failure by Ford to fix a fuel pump issue that has been known since Feb 2025. Should a vehicle stall while being operated due to this issue it could lead to a crash. I would think such a serious safety issue would be addressed and fixed to prevent unnecessary accidents/injuries/death.

Filed Aug 14, 2026 · Engine, Fuel system · TX

My 2022 Ford F-150 has experienced intermittent delayed starting, uneven idle, and hesitation during acceleration. At times, the engine sounds and feels as though it may shut off. I began noticing these symptoms several months ago, and the most recent occurrence was approximately August 2026. I do not recall seeing any warning lamps or warning messages when these symptoms occurred. The vehicle has not yet been inspected or diagnosed by a Ford dealer or independent repair facility for these specific symptoms, and the cause has not been confirmed. The vehicle is available for inspection upon request. I am concerned because my vehicle is affected by Ford Recall 25S75 / the federal safety agency Recall 25V455 involving potential fuel pump failure and loss of fuel pressure, which may result in poor engine performance and engine stalling. I am concerned that the symptoms I am experiencing could create a safety risk if the engine loses power or shuts off while driving.

Filed Aug 10, 2026 · Electrical, Engine · 29,043 miles · MS

The contact owns a 2022 Ford F-150. The contact stated that while driving approximately 55-65 MPH, the vehicle stalled. The check engine and battery warning lights were illuminated. The contact associated the failure with the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline). The vehicle was towed to an independent mechanic, and the failure was associated with the recall and a diagnostic trouble code related to the ECM reprogramming for the fuel system. The vehicle was towed to the local Ford dealer, who diagnosed the vehicle with a fuel system failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted and opened a case. The failure mileage was approximately 29,043.

Filed Aug 3, 2026 · Engine, Fuel system · LA

I purchased a 2022 Ford F150 in September 2024. I began to notice occasional sluggishness when accelerating as the weather warmed up around March 2025. I contacted my local Ford dealership sharing the issue. The service manager suggested I consistently use a high octane fuel, which I consistently do, explaining I may just have "bad gas". The problem continued primarily when I was in heavy traffic with high temperatures. The truck acted as if it had a clogged fuel injector, sluggishness from start, low idle reducing below 1,000 RPM. I contacted a privately owned mechanic shop advising of my idle issues. The mechanic stated he doesn't believe a fuel injector would clog at 50,000 miles. In June 2025 received notification of a recall for my vehicle which I confirmed by VIN. The recall (#25V455) summarized the vehicle could sustain a loss of fuel pressure and flow from the fuel tank due to fuel pump failure. The letter continued, I may experience poor engine performance, rough idle or reduction in power, the same issues I had been complaining about. I contacted the Ford dealership and they explained Ford had not determined how to remedy the problem. Fast forwarding to present, 3 August 2026, over a year since the recall letter and Ford has yet to remedy the problem. What's the hold up? Will Ford finally determine the remedy when my family is killed on the interstate because the vehicles fuel pump fails and it stalls? It appears to be apparent Ford does not want to take the financial hit of such a recall. This is unacceptable and needs to be looked into by the NTSB.

Filed Jun 26, 2026 · Fuel system · 15,000 miles · AZ

The contact owns a 2022 Ford F-150. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the vehicle was idling rough. The dealer was contacted and informed the contact that it was a common failure associated with the recall, but parts were not yet available for the repair. The contact was advised to keep the fuel tank more than half full and to not drive the vehicle in extremely hot weather. Additionally, the contact stated that while driving 55 MPH and hauling a loaded 12 ft. trailer in the desert, the check engine warning light illuminated, and the vehicle stalled. The contact was able to pull over to the side of the road. The vehicle was towed to the residence. The vehicle was then towed to a second dealer, Jones Ford Casa Grande (2425 E Florence Blvd Ste A, Casa Grande, AZ 85194), where it was diagnosed and determined that the fuel pump had failed and needed to be replaced at the owner's expense because parts for the recall repair was not yet available. The contact was informed that reimbursement would be provided once parts became available. The contact was waiting for the dealer to confirm whether the repair was covered under the extended warranty. The vehicle was not yet repaired. Additionally, the contact stated that the fuel economy rate failed to match the advertised rate. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not contacted. The failure mileage was approximately 15,000.

Filed May 1, 2026 · Fuel system · 25,000 miles · TX

The contact owns a 2022 Ford F-150. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The local dealer was contacted but the vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated that the vehicle experienced an engine stall. The approximate failure mileage was 25,000.

Filed Apr 23, 2026 · Fuel system · OH

See attached document for complaint. I have received several notices concerning this recall, dating back a little over a year. I have called the customer service department several times in the past year. To date, no "fix" is available on a defect that can cause a loss of fuel pressure and flow resulting in a possible engine stall while driving. "An engine stall while driving increases the risk of a crash" unquote from the recall notice. HOW IS A "FIX" NOT AVAILABLE AFTER OVER A YEAR OF NOTICE OF DEFECT! Between my husband and myself, we have bought dozens (no exaggeration) of Ford vehicles (mostly new), but we are seriously doubting our purchase of my 2022 F-150 after this recall. I am continuously driving my [XXX] mother (who walks with a walker) to doctor appointments and errands in my truck. How would I safely assist my [XXX] mother, with a walker, off the middle of a highway if my truck stalls out??? We also tow a trailer with my truck at times. How would we safely pull off a highway with a loaded trailer??? I also had called the Customer Relations Center (1‑800‑392‑3673) on February 23, 2026 and was told the Engineering Department has not determined a repair as of that date. My dealer, Sarchione Ford of Randolph, again checked on the recall "fix" while my truck was in for an oil change on March 6, 2026. No "fix" date was available. Fords' inability to "fix" a serious defect as this, is very troublesome and totally unacceptable. Please contact me concerning this potentially life-threatening, possible accident-causing defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 23, 2026 · Visibility · MT

Issue 1: During snow conditions, the windshield wiper arms have detached from the linkage pivot on two separate occasions while in operation. This creates an immediate loss of visibility and a significant safety hazard while driving. In both instances, the detached wiper arm had to be retrieved and manually reinstalled. On one occasion, the arm could not be reinstalled in the field, leaving the vehicle without functional wipers. The component should be available for inspection upon request. The first occurrence happened on Jan 3, 2025. The most recent was Feb 2026. Issue 2: The windshield wipers are currently inoperable. When activated, the wipers move slightly upward (approximately 4–6 inches from the bottom of the windshield), then stall and begin to stutter/twitch repeatedly before stopping completely. There is no visible external damage to the linkage. This condition renders the wipers ineffective and unusable. The issue has occurred during active snowfall, making the vehicle unsafe to operate due to loss of visibility. No prior warning lights or messages were observed before the failure. The issue began suddenly, and was not a slow failure. It also occurred the day after a software update, which I noted because of the changed radio and alarm settings in the vehicle. I believe this was April 14th or 15th. By proximity of the app update, this raises the concern of the issue being related to the app. Based on research, there are multiple current and prior recalls involving similar Ford truck wiper system failures related to linkage lubrication, motor sealing, and sensor faults. The described failures appear to be functionally related and represent a significant safety concern.

Filed Apr 13, 2026 · Fuel system · 75,000 miles · TX

The contact owns a 2022 Ford F-150. The contact stated that while driving approximately 35 MPH up an incline, the vehicle unexpectedly stalled. There were several unknown warning lights illuminated with a message to stop the vehicle displayed. The vehicle was restarted, and a Police escort was provided to safely park the vehicle due to the persistent failure. The vehicle was parked in a residential area. The vehicle was towed to the dealer; however, the vehicle was not diagnosed or repaired. The contact received notification of the federal safety agency Campaign Number: 25V455000 (Fuel System, Gasoline); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure. The approximate failure mileage was 75,000.