2013 Ford Fusion fuel system problems

Filed Nov 4, 2026 · Fuel system · OH

Fuel leaking under hood fuel hose completely popped off causing gas pouring under hood.

Filed Jul 11, 2026 · Electrical, Engine · WA

My 2013 Ford Fusion equipped with the 1.6L EcoBoost engine started blowing thick white smoke (Burning Coolant) while I was driving on the freeway. Engine coolant was leaking and my card died right there, that had blown the head gasket. I received no warning, no message. This was an incredibly dangerous situation because I was on the freeway and was forced to stop immediately. Ford Motor Company has refused to include my vehicle’s VIN in the applicable recall programs despite my vehicle experiencing the same issues described in the federal safety agency recalls 12V551000 (Ford Campaign 12S41) and 17V209 (Ford Campaign 17S09) The recalls identify issues involving coolant loss, overheating, insufficient warning of coolant loss, potential engine damage, cylinder head damage, and the risk of engine compartment fire. My vehicle exhibited these same symptoms and consequences which can be confirmed by the autobody shop where it was evaluated. The purpose of these recalls was to address a known safety concern involving the 1.6L EcoBoost engine cooling system. Despite this, when I contacted Ford and requested assistance and asked that my VIN be added to the recall population, Ford denied my request and stated that my vehicle was not included. I believe this decision fails to address the fact that my vehicle experienced the same defect and safety risk identified in the recall documents. The safety issue is not limited to the VINs currently listed in the recall population; rather, my vehicle demonstrates the same failure mode that prompted the recalls. My concern is that vehicles equipped with the same engine and experiencing the same defect may continue to pose a safety risk to drivers and passengers. A coolant loss event and overheating condition can result in significant engine damage, sudden loss of vehicle operation, costly repairs, and the potential for an engine compartment fire. respectfully request that this matter be reviewed and that Ford be required to re-evaluate their decision.

Filed Jul 9, 2026 · Engine, Fuel system · MI

Vehicle makes strange sounds from the fuel fill inlet and proceeds to stall shortly after while driving and most of the times fails to restart based on my own research it looks like purge valve issues My safety was put at risk by almost being rear ended multiple times from stalling on the expressway and red lights The problem has not been reproduced yet by the dealer it will be looked at on 07/15/26 The component has not been inspected yet The check engine light illuminated when the issue started

Filed Aug 25, 2025 · Electrical, Fuel system · TN

1. After vehicle is given gas it won’t crank. 2. Tire sensors won’t turn off. Even with brand new tires and mounts. 3. Random electrical malfunctions. (Flickering dash lights, delayed engine start after turning the key, light bouncing back and forth between gears, etc.)

Filed Jun 9, 2025 · Fuel system · 160,000 miles · NC

The contact owns a 2013 Ford Fusion. The contact stated that while operating the vehicle, the odor of fuel was present inside the vehicle. Upon inspection, the contact discovered fuel leaking underneath the engine compartment. The vehicle was taken to a local mechanic who diagnosed the vehicle and determined that the fuel delivery module was cracked and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure, but no assistance was offered. The contact was informed that the VIN was not included in the federal safety agency Campaign Number: 13V227000 (FUEL SYSTEM, GASOLINE). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 160,000.

Filed Apr 15, 2025 · Engine, Fuel system · MN

I had coolant leaking in my 2013 Ford Fusion SE 1.6L causing a misfire in cylinder 3 from diagnostics code P0303. After going to a repair shop on 3 seperate occasions and paying to fix issues thought to remedy the issue, I had the Ford dealership in Hudson WI look at it while they took care of a recall. They quoted me $9,900 to replace the engine due to a cracked block. It was hard to get a response from the technician and they were really unprofessional towards me when I requested the part numbers. So much time has been spent on this not to mention that I have been without a vehicle for 1.5 years because my inability to cover additional repairs or the cost of a new car. I also lost my job due to my transportation issues, and paid over $19,000 for this vehicle. I wish Ford would issue a recall because this is a very common issue for this make and model. 2013 Ford Fusion SE L4 1.6L (102K miles)

Filed Dec 18, 2024 · Body, Engine · NJ

Two recalls for this make year and model car had been recalled previously but not for my VIN specifically and the issues are appearing. The first is “doors may open driving” recall on your website and the second is “engine cylinder head may leaks oil” which is also on ur website. Both were recalled for this make and year of the ford fusion but not for my VIN so ford is stating they cannot fix it and want to charge me even for a diagnostic.

Filed Nov 5, 2024 · Fuel system · 162,037 miles · MA

The contact owns a 2013 Ford Fusion. The contact stated that while the vehicle was parked, there was a strong fuel odor coming from the front and rear of the vehicle. The vehicle was not taken to an independent mechanic or dealer to be diagnosed or repaired. The VIN was not included in the federal safety agency Campaign Number: 13V227000 (FUEL SYSTEM, GASOLINE). The manufacturer was notified of the failure and advised the contact to call the federal safety agency Hotline for further assistance. The failure mileage was 162,037.

Filed Oct 9, 2024 · Fuel system · 85,000 miles · NH

The contact owns a 2013 Ford Fusion. The contact stated while entering the vehicle to start the vehicle, the contact smelled the odor of gasoline. The contact checked the vehicle underneath the gas tank and observed that the tank was soaked by gasoline. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The manufacturer was not informed of the failure. The contact researched online and related the failure to the federal safety agency Campaign Number: 13V227000 (Fuel System, Gasoline); however, the VIN was not included. The failure mileage was approximately 85,000.

Filed Aug 30, 2024 · Engine, Fuel system · IL

The purge valve is likely malfunctioning, which affects the fuel system. Yes, it is available for inspection upon request. The malfunction caused the vehicle not to start after pumping gas, potentially leaving me stranded in unsafe locations, which could be hazardous, especially in high-traffic areas or remote locations. The issue has not yet been officially reproduced or confirmed by a dealer or independent service center. No, the vehicle or component has not been inspected by the manufacturer, police, or insurance representatives. There were no warning lamps or messages before the failure. The issue first appeared when the vehicle failed to start immediately after refueling.