2022 Jeep Gladiator technical service bulletins
458 technical service bulletins and manufacturer communications cover the 2022 Jeep Gladiator, including 21 warranty extensions.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- D-25-15
- ID-25-11
- Emission recall – north america
- Emissions Recall 16C
- D-25-15
- ID-25-11
- Warranty Newsletter – Volume 12, Issue 2
- FCA Caribbean Warranty Newsletter – Volume 12, Issue 2
- Emission recall – north america
- D-25-15
- ID-25-11
- FCA Caribbean Warranty Newsletter – Volume 11, Issue 4
- Warranty Newsletter – Volume 11, Issue 4
- Warranty Bulletin D-23-04 Rev. G 2018
- Warranty Bulletin ID-23-03 Rev. H 2018
- Warranty Bulletin D-23-04 Rev. F 2018
- Warranty Bulletin D-23--04 2018
- FCA Caribbean Warranty Bulletin ID-23-03 Rev. F 2018
- Warranty bulletin D-23-04 2018
- Warranty Newsletter – Volume 10, Issue 4
- Fca caribbean warranty operations newsletter volume 10, issue 4"
- The Customer May Complain About a Popping Noise, Grinding Noise, or an Intermittent No Reverse or Forward...
- Socket - drag link inner
- Passive Entry O/S Dr Handle Prior to replacing an inoperative passive entry door handle, perform Star...
- Core – heater
- Fuel Delivery Module Before replacing the fuel module for DTCs P0461 and P062A and other not start, long...
- Instrument Panel Cluster (IPC) and Radio Compass Display has Dashes (--)
- Motor - blower with wheel
- Bolt - hex flange head
- Heater - electric coolant
- Check Engine Light (CEL) Illuminated with Diagnostic Trouble Code (DTC) P0106 Manifold Absolute Pressure...
- Prior to replacing an inoperative passive entry door handle, perform Star Online S2623000040.
- Passive Entry Exterior Door Handle Inoperative When Touched To Lock And Or Unlock.
- Motor and linkage - windshield wiper
- Radio Message "Power Surge On USB Detected" Customers may comment on the following: ● The radio displays...
- Sensor – knock
- Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp...
- Wind Noise From Hard Top Freedom Panels Near Rear View Mirror While Driving.
- Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp...
- Active Diagnostic Trouble Code (DTC) B1A10-00, B1A11-00, B1A12- 00, B1A13-00-, B1A14-00, B1A15-00,...
- Lamp - tail
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Handle - inside release
- Service transmission/check engine warning indicator for the 850RE, 8HP50, 8HP70, 8HP75, 8HP75-PHEV...
- A suspected leak may be noticed on the front or rear axle pinion seal.
- Door Hem Aluminum Body Panel Corrosion Repair Customers may experience the following: SYMPTOM: ● Filifom...
- Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp...
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Washer Fluid Warning Lamp Illuminated When Reservoir Is Full
- Do not replace multiple shocks unless all are verified to be defective.
- Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp...
- Do not replace multiple shocks unless all are verified to be defective.
- Before replacing bluetooth speaker for not charging or battery is dead, please refer to SOL #S248A000019
- Center stack – none
- Bezel - instrument panel
- Door - passenger air bag
- Telematics Box Module (TBM) Backup Battery Replacement When DTC B1E21 Is Present Technicians may...
- Check Engine/Malfunction Indicator Lamp 16C
- Verify "Z" part number availability
- If the DTC B1E21-96: Backup Battery-Component Internal Failure is active and
- Telematics Box Module (TBM) Backup Battery Replacement When DTC B1E21 Is Present echnicians may experience...
- Switch - power window
- Intermittent Uconnect Box Requires Service Message
- ESC Light Illuminated
- Engine Oil Leak
- Module - steering control & column
- Flash: Radio Frequency Hub Module (RFHM) Updates Customers must experience the following: ● Customers may...
- Not applicable to vehicles built for US market
- Data collection required for all 2020-2026MY vehicles with 3.6L PSU engines during any of their first 3...
- Customer complaint may include a Mil On/Check Engine Lamp On and Electronic Throttle Control (ETC) Lamp...
- Exterior Front Lamps Condensation Clearing Procedure Some customers may report that on occasion vehicle...
- Switch - clutch starter interlock & master cylinder assembly - clutch
- Shock And Strut Diagnosis And Replacement Guidelines Leaking, noisy, or weak shocks or struts.
- Shock absorber – suspension & shocks - rear
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Engine Rattle Noise
- Not applicable to vehicles built for US market
- Tire Pressure Monitor (TPM) Service Information
- Module - engine controller
- To inform dealers about the 850RE valve body PN: R8348504A connector: the original 16-pin connector...
- Verify Reman part number availability
- Decreased Remote Start And RKE Range
- 850RE d
- When replacing a camshaft and parts kit (P/N 68661146xx and/or 68661147xx), it is NOT necessary to order...
- Frequent Repairs Of Fuel System Components Such As Fuel Filters Numerous Stellantis vehicles having fuel...
- Adjuster
- Spark Knock/Engine Symptoms Customers may experience the following: ● Knocking or pinging noise coming...
- Frequent Repairs Of Fuel System Components Such As Fuel Filters Numerous Stellantis vehicles having fuel...
- Shim
- Frequent Repairs Of Fuel Line Components Such As Fuel Filters Numerous Stellantis vehicles having fuel...
- Bezel & indicator- gear shift indicator
- Shock And Strut Diagnosis And Replacement Guidelines Leaking, noisy, or weak shocks or struts
- Misfire Diagnostic Trouble Codes (DTCs), Rough Idle, Valvetrain Noise Customers may experience a...
- Universal Garage Door Opener (UGDO) Inoperative, LED Indicator Lamps Not Illuminating
- Washer Light On And Will Not Turn Off After Adding Washer Solvent."
- Tube - fuel injector supply & gasket - none
- 3.6L psu
- Transmission "Transmission For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00,...
- Transmission Fluid Please note fluid color/condition/odor is NOT an indicator of transmission health and...
- Drag Link Long Socket FOR STEERING SHIMMY DIAGNOSIS, PLEASE REFERENCE S1819000004 Rev. Q AND 19
- Telematics Box Module Verify Z part number availability
- 850RE d
- Rear Defogger Solder Terminals Detached.
- Camshaft Sensor DTC Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the...
- Remote Keyless Entry (RKE) Functions Do Not Work, Intermittent Vehicle Response When Using the RKE, Key...
- Tank - fuel
- Exterior Rear View Mirror Stained And Will Not Clean.
- Replacement Exterior Mirror Glass Connector Does Not Match For Blind Spot."
- Misfire DTCs, Rough Idle, Valvetrain Noise
- Flash: Transmission Control Module (TCM) Updates Customers must experience a Malfunction Indicator Lamp...
- Transmission For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00, a repair is...
- Canister
- D Clutch Repair Kit For transmission concerns related to DTCs P0733-00, P1DA8-00, and/or P1D92-00, a...
- Flash: Transmission Control Module (TCM) Updates Customers must experience a Malfunction Indicator Lamp...
- D-23-04
- ID-23-03
- Engine Noise
- Apple CarPlay Does Not Complete The First Initial Wireless Connection.
- Replacement Exterior Mirror Glass Connector Does Not Match For Blind Spot.
- 3.6L psu
- Uconnect Box Require Service Message
- Oil Leaking From Oil Filter Area Customers may experience a Malfunction Indicator Lamp (MIL) illumination...
- Defogger Is Not Working
- Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head...
- Cluster Warning Lamp is on, Service 4WD Message
- Uconnect Box Error Message, With Active or Stored Cellular Antenna Open or Short Diagnostic Trouble Codes...
- 3.6L psu
- Clutch Overheat, And/Or Service Transmission Illuminated
- Hinge - door
- D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle...
- Evaporator - air conditioning
- Drag Link Long Socket FOR STEERING SHIMMY DIAGNOSIS, PLEASE REFERENCE S1819000004 Rev. Q AND 19
- Fuel vapor canister filter evap
- D Clutch Repair Customers must experience a Malfunction Indicator Lamp (MIL) illumination and the vehicle...
- B-Pillar Water Leak When Vehicle Is Parked On A Hill Customers may experience one or more of the...
- Filter - air
- Jeep Bluetooth Speaker Does Not Charge
- Buzz Squeak Rattle (BSR) From Sound Bar Or Sport Bar Area.
- Buzz Squeak Rattle (BSR) From Speaker Sound Bar At High Volume Level.
- Cover kit - hood
- Damper - none
- Heated Steering Wheel Inoperative And Or Not Hot Enough.
- FCA Caribbean Warranty Bulletin ID-23-03 Rev. G 2018
- Switch - headlamp
- Low Tire Pressure
- Battery Drain Suspected or "Identified" From USB or Media Hub
- Click Noise From Front End While Driving And Or Turning.
- Wheel - steel
- FCA Caribbean Warranty Bulletin ID-23-03 Rev. E adds 2024 model year vehicles and updates the Collision...
- Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head...
- Griding/Gear Clash From Transfer Case When Going Into 4WD, Above 5 mph (8 kph).
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Carrier – planetary & shaft kit - output
- D Clutch Repair Kit TSB 21-039-24 REV A
- No Reverse And/Or Forward Gear After D-Clutch Repair.
- Management Procedure for Customer Issues in Connected Services Customers may experience the following: ●...
- Flash: Powertrain Control Module (PCM) Updates Customers must experience a Malfunction Indicator Lamp...
- Water Leak From Front Door
- Drained Battery, Low System Voltage, Battery Not Charging, High System Voltage
- Engine Ticking Noise Customers may experience the following: ● Engine makes an abnormal ticking noise
- 12V Battery Low Level Charge Notification On Customer’s Mobile Application Vehicle's 12V battery Low Level...
- Start Stop Charging Warning Lamp Illuminated On, Intelligent Battery Sensor (IBS) State of Charge (SOC)...
- Switch
- Wiperunit - windshield wiper, blade - front wiper.
- Wiperunit - windshield wiper, blade - front wiper
- D Clutch Repair Customers may experience a Malfunction Indicator Lamp (MIL) illumination
- Freedom Panel Underside Rough And Or White Coating Flaking
- Water Leaking Near Front Bulkhead Or Cowl Area On Driver’s Side.
- Generator
- Axle Assembly Do not replace the Axle for Axle Locker Sensor failure
- Headlamp
- Suspected Engine Coolant Leak
- Loss Of Power Steering Assist
- Remote Keyless Entry (RKE) Button Functions Does Not Work, Intermittent Vehicle Response When Using the...
- Radio Over The Air Update from QR39.82F to QR40.12 Software Version
- Rear Cab Silencer Trim Panel Servicing.
- Radio Black Screen, Freezing, Reset, Cutting Out Or Inoperative Intermittently
- Radio Over The Air Update from QR39.5 to QR40.11 Software Version
- Radio Over The Air Updating to QR40.12 Software Version Customers may experience one or more of the...
- Front and Rear Axle Sensor Kit Customers may experience a Malfunction Indicator Lamp (MIL) illumination
- Thermostat Assy For 2022-2024MY 3.6L Pentastar Upgrade with P0128 failure code
- Tire Pressure Warning Lamp is on Steady, or Flashing
- Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head...
- Floor Console USB Inoperative Customers may comment on the following: ?
- Radio Over The Air Update to Q339.3 to QR39.62 Software Version Customers may experience one or more of...
- Spring Front Upr
- Verifying Camshaft Diagnosis
- Mil-On/Check Engine Lamp-On with DTC P06DD set in the powertrain control module (PCM).
- Hydraulic tensioner Before replacing any Front End Accessory Drive components, please check Accessory...
- PSU Oil Pump Assy
- Malfunction Indicator Lamp (MIL) Illumination
- Frt door hinge - door check
- 4.5 Inch Premium Bar Speaker Static, Rattles, Buzzing
- Inspecting And Disconnecting Negative Battery Cables On ESS Vehicles
- Radio Over The Air Updating From QR39.6 to QR40.12 Software Version Customers may experience one or more...
- Radio Reset After Clock Adjustment
- Engine oil leak
- Lifter
- 2nd Row Center Seat Lazy Or Slow When Folding.
- Exterior Mirror And Or Blind Spot Inoperative.
- Connector kit Before ordering this connector repair kit 68018957A$, check it in the Mopar Connector Repair...
- 8-Speed Transmission, Additional Transmission Fluid Leak Inspection/Repair Guidelines.
- Squeak Noise From Dash Area When Turning The Steering Wheel.
- Front Door Window Will Not Roll Down All The Way. Window Stops Part Way Down.
- PUMP Water For 2016-2024MY 3.6L Pentastar Upgrade with suspected coolant leak
- Suspected engine coolant leak.
- Media Hub USB Connection Drops, Or Apple CarPlay and Android Auto Inoperative.
- Warranty Bulletin D-16-03
- FCA Caribbean Warranty Bulletin ID-23-20 "Can / Am" Warranty Coverage
- U0131-00-LOST COMMUNICATION WITH POWER STEERING CONTROL MODULE ?A?. Service Electric Power Steering...
- A/C Diagnostic LOP Change
- Low Charging Voltage Displayed On Cluster
- Apple CarPlay Does Not Work Or Not Connecting
- Customer Satisfaction Notification 26A
- Lubrication and Maintenance Fluids If MOPAR fluids and chemicals are not readily available, please review...
- Electric hydraulic power steering pump
- USB Hub In-Operable
- Warranty Bulletin D-23-04
- Sunvisor Rocking or Loose One or both sunvisors rocking or are loose
- A/C Diagnostic LOP Change (Except Alfa Romeo Vehicles)
- Power wndow switch passenger
- Customer complaint may include a MIL-on or check engine lamp on condition.
- Water Leak (Drips) On Center Stack, Radio Or Shifter Lever From The Front Center LH Freedom Panel...
- MIL lamp-on. Engine noise, rattle
- Engine makes an abnormal ticking noise
- Water Quality When Mixed With Engine Coolant
- SOS, Assistance Calls Not Successful After Radio Replacement or Radio Software Update
- Engine Ticking Noise Engine makes an abnormal ticking noise
- Engine makes an abnormal ticking noise
- Clunk Noise From Front End Driving Between 15 And 35 MPH And When Decelerating
- Radio Display Screen Blank Or Screen Cuts In And Out
- Customer Satisfaction Notification ZE2 Tailgate Controller
- Engine Ticking Noise Engine makes an abnormal ticking noise
- Mirror
- WiTECH Small Leak Verification Test (SLVT)
- Re-Configure: Body Control Module (BCM) Customers may experience one or more of the following: ? Wi-Fi...
- Fca caribbean warranty operations newsletter
- Malfunction Indicator Lamp Illumination (MIL). Diagnostic Trouble Code (DTC) P203E ? Reductant Level...
- Radio Over The Air Updating to QR40.12 Software Version Mobile Wi-Fi inoperative upon start up. ? Hotspot...
- Headlamp Condensation Clearing Procedure Some customers may report that on occasion, vehicle exterior head...
- Adapter
- Customer Satisfaction Notification Z60 Powertrain Control Module Software
- Radio Remained On After Ignition Is Switched Off, Dead Battery From Excessive Radio Current Draw
- Warranty Bulletin D-23-04 2018
- International Warranty Bulletin ID-23-03 2018
- Rocker arm assy - roller rocker
- Adapter
- Engine assy - 3.6L auto trans
- Warranty Bulletin D-23-04 2018
- Corrosion on Door, Hood And/or Swing Gate Hinges Corrosion found on the door, hood and/or swing gate hinge(s).
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Customer Satisfaction Notification ZD2 Engine Misfire
- Corrosion on Door hood Swing Gate Hinges Corrosion found on the door, hood and/or swing gate hinge(s).
- No crank, Stop Start System Inoperative
- Malfunction Indicator Lamp (MIL) Illumination
- Radio Over The Air Updating to 40.12 Software Version Mobile Wi-Fi inoperative upon start up. Hotspot...
- Washer Light On And Will Not Turn Off After Adding Washer Solvent.
- UAQ and UCQ Radio Enhancements Customers may experience one or more of the following: ? Wi-Fi hotspot...
- Aluminum Body Panel Corrosion Repair Aluminum corrosion or bubbling along the leading edge of hood, hinges...
- Passenger Power Adjustable Mirror Does Not Operate, Service Blind Spot Message Displayed on Cluster
- Flash: Powertrain Control Module (PCM) Updates
- Customers may experience a Malfunction Indicator Lamp (MIL) illumination
- Engine Oil
- Sensor
- Seal, Sunroof
- Telematic box module 2
- Base Headlamp Bright, Base Headlamp Black
- Radio Remained On After Ignition Is Switched Off, Dead Battery from Excessive Radio Current Draw
- Flash: Powertrain Control Module (PCM) Updates
- Spark Knock/Engine Symptoms
- Includes Mil-on/check engine lamp-on.
- Guidelines For The Use Of Alternative Diesel Fuels.
- Error 715 ? Not A Valid Market Message Received In wiTECH When Trying To Program An Immobilizer Component
- Customer?s complaint includes Mil-on/check engine lampon.
- Ambient Temperature Sensor Servicing.
- Connected Service Requires Service Message
- No Start, Stop Start Inoperative, Battery or Check Engine Light (CEL) Illuminated
- Noise From The Front Axle Area Over Bumps
- MIL Lamp Is On, Multiple Glow Plug DTC?s
- Approved Use of Weld Through Primers
- Malfunction Indicator Lamp (MIL) Illumination
- Axle Assembly A parts kit (SENSOR KIT, Axle: 68544629A$) is available to repair the Axle Locker Sensor on...
- Left Headlight, Park Lamp Flickers Or Is Inoperative
- Washer Inoperative, Weak Or No Spray
- Front or Rear Axle Sensor Kit
- Panasonic VP4R Wi-Fi New Enrollment Pause
- While performing the PCM reprogramming portion of Recall Z37, the process fails at approximately 20% progress.
- Customer Satisfaction Notification Z37 Powertrain Control Module Software
- Headlamp Condensation Clearing Procedure
- Valve Cover Gasket It is advised to replace the full valve cover assembly if you are experiencing a valve...
- HVAC Blower Motor For concerns of intermittent or inoperative blower fan operation please contact FCA...
- Frame Bracket Attached To Right Front Frame Rail Behind Front Tire.
- Malfunction Indicator Lamp (MIL) Illumination, Diagnostic Trouble Code (DTC) P00F3 ? Humidity Sensor...
- Power Inverter Wiring Hanging Below the Instrument Panel Cowl on the Drivers Side
- Control - HVAC control
- Complete wiring harness Before replacing this harness, please check for an available connector repair kit...
- PUMP, Diesel Exhaust Fluid For repairs due to DTC P208B and low mileage, prior to pump replacement please...
- Malfunction Indicator Lamp (MIL) Illumination
- Valve Cover Gasket If you are experiencing a right valve cover leak and plan on replacing only the gasket, the
- Receiver
- Latch - front door
- Coolant Color Looks Lighter Than Service Procedure Coolant
- Damper - steering
- Receiver - hub
- Service 4WD Lamp On, Service 4WD System Message
- If a Mopar oil filter is not available, use a filter that meets or exceeds USCAR36 specification and is...
- ESC (Electronic Stability Control) Lamp On, DTC C121C-00-TORQUE REQUEST SIGNAL DENIED
- No Start, ABS Module Has No Communication, Stop/Start Inoperative
- (CEL) Check Engine Lamp, (ABS) Anti-Lock Brake System, And (TCS) Traction Control System Lamps On
- Malfunction Indicator Lamp (MIL) Illumination
- Rattle Noise From Door
- Lithium Ion Batteries Beginning April 1, 2022, a $5,000 penalty will be assessed to dealers who return any...
- The customer?s complaint may include a MIL or check engine lamp-on condition
- Check Engine Light Is On, No Start
- No Start, After Flash And Or PCM Replace, DTC P0513 Invalid Skim Key Setting
- Missing front license plate bracket
- Battery Drain Concern, Dual USB Port Normal Operational Draw, Extended Illumination Or Extended Operation...
- Yellow Warning Labels on the 3.0L Diesel Engines Cylinder Head Covers
- AXLE, Service Rear A new parts kit (SENSOR KIT, Axle: 68544629AA) is available to repair the Axle Locker...
- Media Device Connection Guidelines For Bluetooth, Apple CarPlay, Android Auto Or USB To The Radio Head Unit
- Issue involves overheating, running hot, coolant leaks and related symptoms after a Mopar replacement...
- Transmission Kit with Torque Converter 1. All Promaster (VF) 3.6L/62TE equipped vehicles
VIN decoder
See the problems and recalls for an exact car
Buying a used 2022 Jeep Gladiator?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history