2013 Kia Sorento: engine failure

Filed Oct 23, 2026 · Engine · NJ

The engine failed due to a manufacturing defect that is well known in the company but they aren't calling it a recall, they are calling it an improvement and therefore my car isn't qualifying and isn't being repaired

Filed Jun 12, 2026 · Engine · PA

My vehicle experienced a dangerous incident involving smoke entering the passenger cabin followed by complete engine seizure. Prior to this failure, the vehicle had already undergone recall-related repairs through an authorized Kia dealership for known engine and fire-related safety concerns. The recall was marked as completed by the dealership. However, after the repair, the vehicle continued experiencing problems significant enough to require multiple return visits to the dealership. Despite the recall work being completed, the vehicle ultimately suffered the same type of dangerous condition the recall was intended to prevent. Smoke entering the cabin created a serious safety hazard for myself and anyone inside the vehicle. This was not a routine mechanical issue or ordinary wear and tear. This involved conditions directly connected to known Kia engine defect investigations involving engine failure and fire risks.

Filed Mar 12, 2026 · Engine · PA

On December 21, 2025, my vehicle experienced abnormal knocking/ticking sounds coming from the engine while driving on the interstate (60 mph), and it was difficult going up hills. The check engine light was intermittingly blinking, and there was a strong burning smell. The vehicle was taken to AutoZone and the code displayed P0304 indicating a cylinder 4 misfire. The spark plugs were replaced. However, the knocking sounds, blinking check engine light, and smell of burning happened again, and I took it PepBoys on December 26, 2025. After testing, they indicated that the fuel injector was cracked and fuel was found in the engine oil. I had AAA tow the vehicle to Cochran Kia [XXX] ). The dealership indicated that they would not be able to look at the vehicle until December 29, 2025. The dealership verified that the check engine light was still on and the motor was misfiring badly. They then checked cylinder #4 with a borescope and found that the valve had a crack in it and that the engine would need to be replaced. There was also damage/scoring to the piston and cylinder wall. The dealership corresponded with Kia (Case #25769914), Kia however indicated that there was no powertrain warranty and that this would not be covered under PI1803 and indicated that only applies to bearing failure, and that dealership should provide me with cost estimate to replace the engine. My vehicle has been properly maintained, and I provided the dealership with the additional requested maintenance records on February 14, 2026. I reached out to Kia Customer Care and they indicated to get the engine replaced under the warranty from the settlement, I had to work with the dealership. I contacted the dealership again on 3/12/26 and they said they can't do a warranty replacement because the warranty only covered if it was the rod bearing. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Dec 15, 2025 · Fuel system · ME

I am submitting a formal written complaint to supplement my existing the federal safety agency Safety Report ID 11702339 regarding a serious fuel system defect on my 2013 Kia Sorento. My car began experiencing sluggish starting, sputtering during acceleration, stalling at stop signs and traffic lights, and a strong fuel odor. A check engine light subsequently illuminated, and due to safety concerns, the vehicle was towed to a Kia dealership for diagnosis. The dealership confirmed and documented fuel leakage from the high-pressure fuel pressure regulator and fuel contamination in the engine oil. This defect presents a serious safety risks: increased risk of engine fire due to fuel leakage, unexpected loss of power while stopped or in traffic, and increased likelihood of a collision due to engine stalling. This vehicle previously had its engine replaced under a Kia recall in 2020, making this failure particularly concerning. Fuel system failures and post-recall engine-related defects have been the subject of multiple Kia recalls, service campaigns, and the federal safety agency investigations involving engine fires and fuel leaks. Despite the dealership's documented diagnosis and clear safety implications, Kia Consumer Affairs denied recall coverage and refused to assist with repair costs, stating this is not a recall-related issue. The estimated repair cost exceeds $1,700, and the vehicle remains unsafe and undrivable. Given the confirmed fuel leakage, fuel contamination of engine oil, prior recall engine replacement, repeated stalling events, and Kia's refusal to acknowledge responsibility, I respectfully request that the federal safety agency review this case as part of a potential defect trend, particularly involving high-pressure fuel system components on Kia Sorento vehicles with prior recall engine replacements. I am submitting this complaint to ensure this safety issue is formally documented, investigated, and considered for further action to protect consumers. Thank you for your attention to this serious safety matter

Filed Dec 4, 2025 · Brakes, Engine · 125,000 miles · CA

The contact owns a 2013 Kia Sorento. The contact received notifications of the federal safety agency Campaign Numbers: 17V224000 (ENGINE AND ENGINE COOLING) and 23V652000 (SERVICE BRAKES, HYDRAULIC). The contact stated that while his daughter was driving 45 MPH, there was an abnormal knocking sound coming from the engine. In addition, the vehicle failed to accelerate as intended while depressing the accelerator pedal. The contact's daughter stated that the engine had seized, and the vehicle had stalled. The contact's daughter was unable to coast to the side of the road. No warning lights were illuminated. The vehicle was towed to the residence. The following day, the vehicle was towed to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The contact was informed that since the first recall repair had not been completed, the manufacturer denied the recall repairs. The vehicle remained at the dealer unrepaired. The contact received a bill from the dealer. The manufacturer was not notified of the failure. The contact's daughter stated that before the engine failed, every time the vehicle was started, there was an abnormal knocking sound coming from the engine. However, after several minutes, the abnormal sound disappeared. The failure mileage was approximately 125,000.

Filed Dec 3, 2025 · Engine · CA

While driving, my vehicle developed engine knocking, lost power, overheated, and produced smoke from the engine compartment. Shortly after, the engine seized and the vehicle will not start. An authorized dealership diagnosed the failure and recommended a complete engine (long-block) replacement, indicating catastrophic internal engine damage. This failure appears consistent with known Theta II engine bearing defects. The manufacturer is refusing coverage by stating the owner did not bring in the car for the recalls. The recall was preventive monitoring software (KSDS) and did not repair or prevent the underlying mechanical defect that caused the failure. This is a safety concern, as the failure caused loss of power and overheating, creating risk of fire or accident.

Filed Dec 1, 2025 · Engine, Fuel system · ME

I am reporting a safety defect on my 2013 Kia Sorento (VIN: [XXX] ). Before the failure, the vehicle began experiencing sluggish starting, sputtering during acceleration, stalling when stopped at traffic lights or stop signs, a noticeable fuel odor, and eventually a check engine light. These symptoms increased over several days, and once the check engine light illuminated, we had the vehicle towed to a Kia dealership for diagnosis. At the dealership, the problem was confirmed and reproduced by their technicians. They diagnosed: •Fuel leakage from the high-pressure fuel pressure regulator •Fuel contamination in the engine oil These components and diagnostic findings are available for inspection upon request. This issue poses a significant safety risk. Fuel leakage and fuel-in-oil contamination increase the potential for an engine fire, and the hesitation, sputtering, and stalling at intersections present a risk of unexpected loss of power in traffic, which could result in a collision. The vehicle previously had its engine replaced under a Kia recall in 2020, and the current symptoms are consistent with known Kia engine and fuel system defects addressed in past recalls and technical service bulletins. The vehicle has been inspected only by the dealership so far; it has not yet been inspected by the manufacturer, police, or insurance representatives. Kia Consumer Affairs has been contacted and is reviewing the case. I am requesting that the federal safety agency review this issue as a potential defect trend involving the high-pressure fuel system on this model, especially in vehicles with prior recall-related engine replacements. Documentation from the dealership, including the diagnostic report and repair estimate, is available upon request. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 21, 2025 · Engine · MN

In 2017, our 2013 Kia Sorento was brought in for recall work associated with SC147. The work was completed, and the Kia service department stated that even though we have a branded/salvage title, we would receive the extended warranty associated with SC147. Recently, while driving down a busy highway, the engine started knocking, at which point the check engine light came on, and the vehicle would no longer accelerate. The car had to be pulled off to the side of the road, and towed to a repair shop. Upon inspection, the repair shop indicated the issue was related to SC147, and would need to be taken to Kia for further inspection and repair. Kia has indicated, now, that SC147 was closed due to the inspection and KSDS update done in 2017, and that we are not covered by the extended warranty associated with SC147 due to the branded title, which contradicts what was previously stated by Kia's service department. Kia has stated that they will NOT replace the engine. Even though this is a safety issue associated with SC147, Kia is unwilling to take accountability and seems to be sidestepping replacement due to having a branded/salvage title.

Filed May 13, 2025 · Engine, Fuel system · GA

my vehicle falls under the 2013 Kia Sorrento engine replacement and fuel pump. Recall these have not been done to my vehicle. I even double checked with the previous owner and Kia did not service the engine or replace it although it has a recall under mine, and all the symptoms stated in the recall with the engine and fuel pump are happening with my vehicle now how do I get this service covered under the recall also a very strong fuel odor

Filed Feb 12, 2025 · Engine · 71,935 miles · IL

The contact owns a 2013 Kia Sorento. The contact stated that while his daughter was driving the vehicle with her boyfriend seated in the passenger’s seat, while approaching a stop sign at 30 MPH, the vehicle stalled. There was no warning light illuminated. The vehicle was stopped safely on the side of the road, and then the vehicle was towed to a local independent mechanic to be diagnosed. The contact was informed that the engine had seized. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact related the failure to the federal safety agency Campaign Number: 17V224000 (Engine and Engine Cooling). The manufacturer was not made aware of the issue. The approximate failure mileage was 71,935.

Filed Nov 14, 2024 · Engine · 77,000 miles · PA

The contact owns a 2013 Kia Sorento. While the contact's wife was driving at an undisclosed speed, the engine was knocking before the engine seized. The contact stated that due to the failure, the vehicle side-swiped a concrete mailbox. The vehicle was towed to the dealer where it was diagnosed with engine failure. In addition, the contact was informed that the engine rod had fractured the oil pan. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact stated that in June 2018, the engine was replaced; however, in April 2019 the failure reoccurred. The vehicle was repaired. The manufacturer was made aware of the failure and a case was filed. The contact was informed of an unknown expired recall repair however, the VIN was not included. The contact was informed that the recall repair might have prevented the failure; however, the contact stated that the recall notification was not received. The failure mileage was approximately 77,000.

Filed Nov 2, 2024 · Engine · OH

Engine failed to start and made loud knocking noises. Knocking noises continued and vehicle towed to dealer. Oil level was full and all routine maintenance performed up to this point. Oil level full at time of failure. Dealer confirmed knocking, stated the knocking went away after running for a period of time. Dealer requested 3 hours of labor and we are currently determining our next step. The vehicle is available for inspection at Kings Kia in Northern Cincinnati. 137,000 miles. Also have video of engine knock. Recently had HECU recall and it potentially caused ABS light, independent repair shop recommended new HECU after recall performed due to low voltage from yellow wire, dealer claimed replacing wheel speed sensor, we still suspected other electrical issues may have been caused.