2015 Kia Sorento: engine knocking or ticking

Filed Oct 11, 2026 · Engine · MS

My car's check engine just started flashing and the ECU has reduced my drivability to limp mode stating that my knock sensors are showing up on scan test and camshaft position exhaust sensor. When I removed the camshaft exhaust vvt sensor it indeed had metal shavings on it. A have a P1326 and a p0014 code which is basically telling me that my engine is having issue within the internal engine and oil consumption.

Filed Oct 5, 2026 · Engine · TX

1) The engine control system / KSDS knock sensor system triggered safety recall code P1326, accompanied by a flashing check engine light. The vehicle and components are currently at the dealership available for inspection under RO #148484 (Issued on October 2) 2) A flashing check engine light and active P1326 code indicate a potential severe engine failure or severe misfire risk while driving, forcing the vehicle to lose power and rendering it unsafe for operation on public roads. 3) Yes, the vehicle was towed to an authorized Kia dealership on September 24th; however, the dealer initially refused to generate a Repair Order or diagnose the safety recall for over a week until corporate intervention forced RO #148484 to open on October 2nd. It is currently awaiting diagnostic testing. 4) No. It has only been towed to the authorized dealer facility where it awaits initial diagnostic testing under the active safety recall. 5) Yes. A flashing check engine light and code P1326 appeared immediately prior to towing the vehicle to the dealership on September 24th.

Filed May 18, 2026 · Engine · WA

I am filing a safety complaint regarding a 2015 Kia Sorento equipped with the 2.4L Theta II engine. The vehicle developed progressive engine knock, reduced power, and check engine warnings while driving. Diagnostic trouble codes include P0017, P0014, and P0340 relating to crankshaft/camshaft timing correlation and camshaft position faults. A Kia dealership performed diagnostic testing using Kia diagnostic equipment (KDS) and documented abnormal knock activity across all cylinders. The dealer repair order specifically states: * “Found data PIDs for additional knock noise” * “All registering knock on all cylinders” * “Recommend replacement of engine sub assy based on knock detection” The vehicle experiences engine knocking and loss of power that create concern for sudden engine failure or stalling while driving, which could increase crash risk. This complaint is being submitted because the symptoms appear consistent with the known Theta II engine defect involving connecting rod bearing failure, engine knock, seizure, and potential engine failure.

Filed Mar 21, 2026 · Engine, Transmission · MA

I was driving with my son when my 2015 Kia Sorento stopped in traffic. I remember warning lights coming on my dash including the engine light, oil light and battery light. However, I was more concerned about getting my hazards on so we would not be hit by another car. Traffic was heavy, it was raining and getting dark. I needed to push my car off the road with the help of another driver. A Hyannis ambulance was a few cars behind me and the EMT's also assisted with the traffic and moving my vehicle out of the road. I called AAA and had my car towed. I was told in writing by the Kia dealership that the engine needed to be replaced. I was told verbally by Kia that it was a rod knock issue. When I asked how it was diagnosed with rod knock she said the mechanic put something down in the engine and said its rod knock. I requested through Kia corporate that the car be inspected for the WTY039 extended warranty and corporate said they would reach out to the dealer and ask that it be checked. I have not received any further communication from the dealership or Kia corporate. Yes the vehicle is available for inspection. Safety was an issue because the car stopped so suddenly in heavy traffic. I was not able to slowly decelerate or steer to the side of the road. I felt like a sitting duck. We were extremely lucky that we were not hit from behind at 35 mph resulting in injury to us and to the drivers behind us. Prior to this event there were no warning lights that had come on and no strange noises from the car. They first appeared when it stopped in traffic.

Filed Mar 18, 2026 · Engine · NC

Was driving vehicle and it began to run hot, check engine light came on then started to make a knocking sound when getting to 30-35 mph. Was inspected by a service center. There it was confirmed an issue with the motor/head gasket

Filed Mar 3, 2026 · Engine · 128,405 miles · IL

The contact owns a 2015 Kia Sorento. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated and remained illuminated. There was a knocking sound coming from the engine. The vehicle was towed the local dealer and was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. No further information was available. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 128,405.

Filed Feb 12, 2026 · Engine · 98,954 miles · GA

The contact owns a 2015 Kia Sorento. The contact stated that while driving approximately 40-45 MPH, the vehicle stalled. There was no warning light illuminated. The vehicle was pulled over to the side of the road. The contact attempted to restart the vehicle, but the engine made abnormal knocking sounds. The vehicle was towed to the residence and failed to restart. A mobile technician diagnosed the vehicle with engine failure. The vehicle was not repaired. The dealer and the manufacturer were not contacted. The failure mileage was 98,954.

Filed Feb 8, 2026 · Engine · AZ

I am filing this complaint regarding a suspected safety defect involving the Theta II engine in my 2015 Kia Sorento. The vehicle developed progressive engine failure symptoms including: Engine knocking and abnormal mechanical noise Loss of power while driving Misfire conditions Excessive oil consumption Progressive deterioration of engine performance These symptoms began at approximately 150,000 miles and worsened over time. Given the documented history of Theta II engine failures involving rod bearing defects, sudden engine seizure, loss of power, and fire risk, I believe my vehicle is experiencing a progression of the same known defect. 2) Safety Risk to Driver and Public The engine condition created serious safety risks, including: Potential sudden engine failure while driving Loss of power in traffic or at highway speeds Increased risk of collision Potential fire hazard associated with Theta II engine failures Despite these risks, Kia and its authorized dealership advised me to continue operating the vehicle. I was explicitly told to “drive it until it fails.” This guidance was given despite Kia’s documented knowledge of Theta II engine defects and associated safety hazards. 3) Manufacturer Response and Denial I reported the engine failure to Kia and its authorized dealership. Kia denied coverage, stating: The vehicle had “too many miles,” and The failure was allegedly “not rod bearing related.” However, Kia and the dealership refused to provide: Complete diagnostic trouble codes (DTCs) Technician notes or inspection reports Compression or leak-down test results Oil analysis or evidence proving bearing failure was ruled out Without this information, Kia’s conclusion that the failure is not related to the Theta II defect is unsupported and unverifiable. 4) Concern of Misdiagnosis and Defect Misclassification Based on the symptoms and known Theta II failure patterns, I believe Kia may be misclassifying a progressive bearing-related engine failure as a non-covered

Filed Jun 15, 2025 · Engine · SC

On [XXX] while driving at approximately 45 mph the check engine light came on and the car would not accelerate. It was towed to the Kia Dealership in Charleston South Carolina. A Code P1326 was diagnosed. They performed bearing clearance test and it passed. Also Performed software update. The car drove as normal until [XXX]. On [XXX] while on the interstate, going about 65 mph, the check engine light began flashing and car would not accelerate. The car was taken to the Kia dealership in Florence, South Carolina where we were told the knocking sensor needed to up updated. We told them it already had been updated in January by the Kia dealership in Charleston South Carolina. We were then told we had to take it back to Charleston and have that dealership work on the car. We called Kia Customer Care Center because the Florence Kia was refusing to work on the car. Kia Customer care also told us to have the car towed back to Charleston because the Florence Kia was backed up months before they could even look at it. We were told towing would be reimbursed. We had the car taken back to Charleston and have provided all the service records we had to the dealership. It has been over six weeks and still waiting for an answer about the engine. Kia Support says they haven't received any of our services records from the dealership and the dealership says they sent the records. We are not allowed to send the records straight to Kia support. We have asked the Kia Dealership what needs to be done to fix the car but they said they can't tell us until Kia support tells them. We do not know if any inspections have been done of the car yet. We are given very little information by the dealership. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed May 3, 2025 · Engine · GA

With little to no warning my check engine, steering, and oil lights turned on and the engine stalled after a loud noise as I was coming to a stop. This occurred on a major highway and could have been catastrophic and dangerous if it occurred at full speed by leaving my vehicle in the middle of the road open to potential collisions that could harm myself or others. Thank goodness i did not have any passengers. I was barely able to pull off to the median and had the vehicle towed to a mechanic who confirmed the engine had seized due to rapid oil loss and found metal debris in the engine oil. They are recommending a full engine replacement. I called the dealership to see if they would agree to inspect the vehicle or see if there had been any reports or recalls associated. I specifically asked them is there was a knock sensor update needed on my vehicle since the mechanic told me there are open complaints about this upgrade not being done and it causing engine failure. The dealership I spoke with stated there are no upgrades or recalls open for my vehicle and refused to inspect the vehicle stating "there is nothing in their system that would indicate an issue". The vehicle is available for inspection for now. I see there are many similar reports over the past year or so for this model. There apparently was a recall for this issue on the following year's model and the 2.4 engine, however I strongly believe the 2015 Sorento 3.3 engine should be thoroughly investigated.

Filed Apr 4, 2025 · Engine · TX

Kia Sorento Limited 2015. Regular oil changes on engine using Valvoline synthetic oil. 118k miles on the 3.3L engine. Car is in mint condition. I have all records. At oil change, Valvoline tech mentioned it was low on oil. Never had a tech tell me that before. 24 hours after oil change, I started the engine and heard a pinging noise. I let the engine warm up and the sounds smoothed out. I drove it for less than 5 minutes on the highway at 60mph and warning lights came on and the car had no power from the engine. No loud sounds or knocking at the time. Kia South Dealer is telling me I have to buy a rebuilt engine for $5.5k and will cost $6K to install. That cost is more than the car is worth. With me research, there are two huge issues with the engine. Head bolts loosing and lack of oil distribution on one cylinder causing bearings to melt. I know there is not a recall on this but there is on the same engine for the Hyndai Sante Fe. I baby this car and I feel very betrayed that the engine gave it the way it did. My car looks brand new as I take great care of it but now I have an engine that should last twice as long that is now dead. Shouldn't this engine should be applicable for an extended warranty or for Kia to step up and help with the cost? What can I do? Really appreciate your help!!!!! Sincerely, [XXX] Original Owner since I bought it Dec 2014. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Apr 1, 2025 · Engine, Fuel system · VA

Engine died in the middle of the right of way suddenly and would not restart. Knocking sound ensued when restart was attempted. Within the previous 48 hours, the engine had been topped off with 2 quarts of oil. The dealership it was towed to to assess the issue confirmed they added an additional 3 quarts of oil during the assessment. They confirmed the engine would need to be replaced. Mileage at the time of incident was 68K. Kia corporate confirmed they would not replace the engine since there are 4 owners on the vehicle history, and the warranty expired at 60K miles as a result.