While driving my 2020 Kia Sorento on the freeway at highway speed, the panoramic sunroof suddenly shattered without warning. There was a very loud explosive sound that startled and frightened me while I was driving. I was not aware of anything striking the sunroof immediately before it shattered, and there were no warning lights, messages, noises, cracks, or other indications that the glass was about to fail. Because I was traveling at freeway speed when this occurred, the sudden explosion/shattering of the glass was extremely distracting and created a serious safety concern. I was frightened by the unexpected loud noise and could have lost control of the vehicle. Broken glass from a panoramic sunroof also presents a risk to the occupants of the vehicle and to other motorists. The component that failed was the panoramic sunroof glass. To my knowledge, the failure has not yet been reproduced or confirmed by a Kia dealer or independent repair facility, and the vehicle has not yet been inspected by Kia for the cause of the failure. I am reporting this incident because the sunroof appeared to shatter suddenly during normal highway driving without any prior warning, and I am concerned that this may represent a safety defect.
Kia Sorento sunroof shattered problems
186 of the 10,244 owner complaints about the Kia Sorento describe sunroof shattered, most of them for the 2012 model year.
- owner complaints
- 186
- worst model year
- 2012
- typical repair cost reported
- $1,280
- typical mileage
- 48,032
By model year
Often reported together
What owners say
About a minute into my drive, I heard an explosion. I looked back thinking something happened to my twin toddlers and saw nothing. I heard the sound of glass cracking and looked up to see the front glass of my moonroof shattered. I pulled over to safety and closed the sun cover for the moonroof before any more glass could fall into the car in fear of my toddlers getting injured. The car itself had been on for maybe 5 minutes prior to driving away from my house.
While traveling on a freeway, the front sliding portion of our sunroof exploded outward and upward. Sunroof was closed at the time with no impact present to cause the event. A very expensive repair for something that is clearly a defect of some sort. KIA was contacted and not willing to warranty or help cover.
My sunroof exploded.
Sunroof/Moonroof After a stop light, while driving at less than 30mph, sunroof/moonroof exploded outwards. There were no surrounding cars in front or beside or in other lane direction. It was not hot or cold out. Evening time. No weather issues. If the fabric shade screen had not been closed all the glass would have fallen all over driver. There was no warning of any kind. Glass just exploded outward into a point like a mountain peak. Then glass started falling inwards into car. Took to dealership, had insurance company evaluate for repairs, insurance approved repairs performed by dealership. Dealership service writers said this has happened on other kia's.
The contact owns a 2013 Kia Sorento. The contact stated that while driving, a sound of an explosion was heard and the sunroof shattered, the slider of the sunroof was closed so the glass did not enter the vehicle. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 100,000.
Today, May 12, 2026 at 12:10pm the panoramic sunroof spontaneously exploded. I heard some shacking sounds in the car, right as I was picking up speed on the freeway and then heard a bang above my head. Nothing had hit the car. It sounded like a balloon had popped in my ear. When I stopped the car 5mins later, I could see the glass was getting pushed out from the inside and then broke apart in the sunshade. I am my kids were not in the car at the time. It was above their car seats.
A few weeks ago my sunroof began with out warning began to malfunction. It stopped closing all the way . When finally close I noticed the right rear side of the roof not closing all the way. I've noticed the bracket that holds up the glass roof to the track was broken. I took the car back to my car dealership, Gerald kia of Matteson. They told me that it was my fault because the tracks wasn't greased. Something that I wasn't at first purchased a car brand new. So they told me that consider an outside influence ira it would not be covered under a factory warranty. The reason I am filling this is because of hearing about some roofs , exploding , and this could be a situation similar to that.
Sunroof exploded when driving sounded like a shotgun. This is a known issue by kia.the glass blow upward.
The Panoramic sunroof randomly exploded while driving down the highway. Nothing around us or above us to cause it. Myself, my [XXX] pregnant wife, and [XXX] daughter were in the car and had glass rain down on us after the very loud boom. We almost wrecked. The issue has not yet been inspected by the dealership but I understand this to not be uncommon. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
Related recalls
No recalls on record for this model year.
Questions about the Kia Sorento sunroof shattered
Which Kia Sorento years have sunroof shattered problems?
The model years with the most reports are 2012 (32 complaints), 2013 (25 complaints) and 2011 (24 complaints).
How much does it cost to fix sunroof shattered on the Kia Sorento?
Owners who mentioned a price put the repair at about $1,280 (median of 6 complaints that include a dollar amount). Costs vary with mileage, warranty and where the work is done.
VIN decoder
See the problems and recalls for an exact car
Buying a used Kia Sorento?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history