2015 Ford Fusion: airbag warning light

Filed Nov 14, 2023 · Airbags · AR

1.Air bag-control module :P&A RCM failed. 2.control module not working that's mean upon impact the sensors will send the signal to the control module ,but the module will not be able to initiate the deployment of the airbags,putting the passengers of the vehicles at risk. 3.yes the component been inspected by ford dealership . 4.yes airbag lamp is on. a month ago the lamp is on.

Filed May 30, 2023 · Seat belts · 41,690 miles · TN

The contact owns a 2015 Ford Fusion. The contact stated that while parked, upon starting the vehicle, several unknown warning lights illuminated. The contact noticed later that the air bag warning light had remained illuminated; however, the warning light turned off independently. The vehicle was taken to the dealer, who diagnosed a failure with the front passenger’s side seat belt. The vehicle was not repaired due to the contact declining service because she previously had the dealer replace the seat position sensor. The manufacturer was notified of the failure and advised the contact to contact the federal safety agency Hotline; however, a case was not opened. The failure mileage was 41,690.

Filed May 30, 2023 · Airbags, Seat belts · TN

On May 15, 2023 I got in my car, proceeded to drive off when I noticed that the airbag light was still illuminated on the instrument panel. I notified the dealership the next day and dropped my car off on May 17, 2023. On May 19 a diagnostics test was run and revealed that I had a faulty seat belt buckle. I declined service on the car. This was shocking to me since I took my car to them less than 4000 miles and less than a year ago for the airbag light staying on again in 2022. At that time it was revealed that it was the passenger seat position sensor & it was repaired. In 2020 my car was also a part of Recall 19S25 for the seat belt. In 2018 repairs were also done on my car due to the airbag light coming on as well. I'm driving the car but now don't know if it is safe to drive. When I picked up the car, the light was still on but about 4-5 days later the light went off by itself. The passenger seat has barely been used since I purchased the car in 2015. After the repairs were done in 2022, the seat/seat belt has not been used so I don't understand how it can be faulty. It seems to me that there's a defect somewhere and it should be investigated. I would appreciate if this is given serious consideration. When I spoke with Ford Motor Company, they told me to contact you to have you investigate the matter. I am working with the Customer Relations Rep with Ford of Franklin- [XXX] at [XXX] regarding this matter. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Filed Apr 19, 2023 · Brakes, Steering · 50,000 miles · OH

The contact owns a 2015 Ford Fusion. The contact stated while driving at various speeds, the steering wheel drifted to the left while depressing the brake pedal, and excessive force was needed to maneuver the steering wheel. The air bag warning light was intermittently illuminated. The vehicle was taken to a local dealer on numerous occasions, where the failure could not be duplicated. The vehicle was taken to an independent mechanic on four separate occasions, where it was diagnosed that a wheel alignment was needed; however, after the alignment was completed, the failure persisted. The vehicle was taken to another independent mechanic, where it was diagnosed that all tires needed to be replaced. The vehicle was repaired; however, the failure persisted. The vehicle was then taken to Kings Ford (9555 Kings Auto Mall Rd, Cincinnati, OH 45249), where it was diagnosed that another alignment was needed; however, the failure persisted after the repair. Additionally, the contact received notification of the federal safety agency Campaign Number: 23V162000 (Service Brakes, Hydraulic); however, the part to do the recall repair was not yet available. The vehicle was taken back to the dealer and the mechanic related the failure to the recall; however, the dealer confirmed that parts were not yet available for the recall repair. The vehicle was not repaired. The contact was advised to apply the parking brake whenever parking the vehicle. The manufacturer was made aware of the failure. The approximate failure mileage was 50,000.

Filed Jun 23, 2022 · Airbags, Electrical · 65,000 miles · TN

The contact owns a 2015 Ford Fusion. The contact stated while driving 65-70 MPH, the messages: "Failed to Connect to AC Control System”, “SRS Air Bags System Malfunctioning" and "Blind Spot Visual System Not Working" were displayed. Additionally, the vehicle went into limp mode independently and would not accelerate over 65 MPH. The contact stated upon parking the vehicle, the doors and windows failed to unlock. The contact banged the front driver's side door several times and the door finally unlocked. The contact was also able to unlock the rear driver's side door after several attempts. However, the front and rear passenger side doors remained locked. The vehicle was taken to the dealer but the dealer declined to assist. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 65,000.

Filed May 20, 2022 · Airbags · 38,000 miles · TN

The contact owns a 2015 Ford Fusion. The contact stated while driving at an undisclosed speed, the air bag warning light illuminated. The contact stated that the vehicle was then taken to the dealer to be diagnosed. The contact was informed that the air bag seat position sensor needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 38,000.

Filed Jul 4, 2021 · Airbags, Electrical · UT

Randomly and without warning, the entire climate control system shuts off as well as the entire center console. The only message during this period is "temporarily lost communication with climate control". When all this shuts off, the drivers side controls for the windows becomes inoperative as well as the passenger side lock/unlock button. This renders a safety hazard because during times of heat and cold it becomes impossible to run the climate control or roll the windows down for any air movement. Also an extreme hazard is the passenger is unable to unlock the doors in even of an emergency. Occasionally when this happens, the air bag light will illuminate, causing unknown safety hazards in that aspect. I have contacted the dealership and was told it sounds like a potentially faulty computer module, or faulty wiring that could cost thousands to repair. The issue occurs 80% of the time the car is in operation and seems to happen more on hot days where it becomes critical to have air movement/AC.

Filed May 12, 2021 · Airbags · 60,000 miles · PA

Air bag light came in, ford dealer says seatbelt retractor pin broken, electrical connection corroded and entire assembly needs replaced! The have a service alert on this problem but no recall. Airbag will not operate until fixed! Cannot afford the cost of repair! Help!

Filed Apr 20, 2020 · Engine · 140,000 miles · KS

Tl* the contact owns a 2015 ford fusion. Contact stated that while driving at various speeds, the engine and air bag warning lights illuminated. The vehicle loss motive power and acceleration. The contact drove the vehicle back to the residence. The vehicle was taken to mel hambelton ford, inc,(11771 w kellogg dr, wichita, ks 67209, (888) 489-1719) to be diagnosed. The contact was informed that the coolant was pressed into the cylinder and the engine needed to be replaced. The vehicle was not repaired. The failure recurred. The manufacturer was contacted and informed of the failure. The failure mileage was approximately 140,000.

Filed Sep 17, 2019 · Airbags, Engine · 139,888 miles · IL

Tl* the contact owns a 2015 ford fusion. While driving at any speed, the air bag indicator illuminated and flashed on and off. The contact received notification of the federal safety agency campaign number: 19v590000 (seat belts) and another unknown recall letter regarding the air bags. The contact took the vehicle to bob rohrman schaumburg ford (847‑605‑0800, located at 815 east golf road, schaumburg, il 60173) where the dealer stated that there was no recall. The vehicle was not diagnosed or repaired. The manufacturer was called, but the line was busy. The failure mileage was approximately 139,888. *as the consumer stated the engine, stability control, transmission lights have all illuminated. The vehicle broken down twice.

Filed May 14, 2019 · Airbags, Seat belts · FL

Vehicle displayed airbag warning light. After ford inspected the vehicle they stated that the defect was in the driver's seat belt buckle and that it would need to be replaced at a cost of $400. Ford stated that the defect would not allow the air bags to deploy. I asked for my vehicle back but had to pay $89 for diagnostics. Took vehicle home and removed driver belt buckle and discovered wire broken at base of buckle (see attached images). This defect that will not allow airbags to deploy and involves a broken wire in the belt buckle should be a safety recall. Otherwise, what will happen is all the vehicles that have broken wires will not get fixed and the only defense is the seat beat alone.

Filed May 10, 2019 · Electrical · 77,000 miles · VA

Turned my AC on one night and my air bag light came on and is still on after 12 days