2016 BMW X5 technical service bulletins
364 technical service bulletins and manufacturer communications cover the 2016 BMW X5, including 5 warranty extensions.
Bulletins tell dealers how to fix known problems. A warranty extension means the manufacturer pays for that repair for longer.
- The Exhaust Gas Recirculation (EGR) Cooler (with EGR Valve) and the Auxiliary Exhaust Gas Recirculation...
- The electric auxiliary heater assembly limited warranty for defects in materials and / or workmanship has...
- The High-Voltage (HV) Battery Assemblys Cell Modules Temperature Sensors (Internal NTC repair...
- The High-Voltage (HV) Battery AssemblysCell Modules Temperature Sensors (Internal NTC repair kit-specific)...
- N63TU1 class action settlement svc campaign: oil consumption diagnosis/repair
- The vehicle demonstrates a power loss and the malfunction indicator lamp (MIL) on. The following fault...
- The basic conditions for initializing the power windows are not met.
- The electrical system of BMW vehicles has been subject to an ongoing development process over the last few...
- At low outside temperatures (below 40 degrees F) and slow driving speeds (i.e. when parking,...
- Situation
- Engine will crank but not start
- Customers may state that the alarm system (DWA) is not active after locking their unoccupied vehicle
- Diesel fuel injectors: ltd wty extension to 10 years/120,000 miles
- Second seat row blocking access to third seat row, program seat modules
- Various functions of the camera-based driver assistance systems (ADCAM system) can lead to customer...
- This situation can result in two customer complaints: 1. Wind noise 2. Excess water entry
- ?The front seat will not calibrate/initialize, and the stored faults cannot be deleted.
- With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered into a nationwide...
- Upon opening and closing the tailgate, a creaking/groaning sound can be heard from tailgate actuator.
- After programming the head unit (HU-H2), activating the FSC (German word Freischaltcode) Enabling Codes...
- The 3G network in the US has been shut down
- With the court's FINAL approval, BMW of North America, LLC (BMW NA) has entered into a nationwide...
- For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the...
- According to the customer, the airbag warning light was on, but it may not be illuminated when the vehicle...
- Coolant is leaking from under the car which is equipped with the S63 engine
- The driver's side (left rear) of the 60/40 split 2nd row seat may intermittently not fully latch into...
- When returning the 2nd row seat 60% (left) side from Easy-Entry: The seat stops moving before reaching the...
- When returning the 2nd row seat 40% (right) side from Easy-Entry: The seat stops moving before reaching...
- The passenger's side (right rear) of the 60/40 split 2nd row seat may intermittently not fully latch into...
- The front sunroof glass seal has shrunk, creating a gap which can
- Customer is unable to power up or charge accessories through a plug adapter inserted in the front 12-volt...
- Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may...
- The Lane Change Warning (LCW) yellow triangle symbol on either one, or both the exterior side view mirrors...
- Driver Assistance reduced checked control message (CCM) appears
- The fuel gauge may indicate the incorrect fuel level (full and reserve).
- Component specific limited warranty extension for the Exhaust Gas Recirculation Valve.
- A check control message for the restraint system appears
- Vehicle cannot be opened or closed using comfort access, engine start is not possible, and the vehicle may...
- The Headunit High (HU-H), also called NBT, began replacing the Car Information Computer (CIC) on certain...
- Component specific limited warranty extension
- A groaning noise is present from the door frame of any door, most commonly when driving over rough roads...
- BMW of North America, LLC (BMW NA) has entered into a nationwide settlement with the plaintiffs in the...
- The red air bag warning light is illuminated.
- For the eligible vehicles with the Electrical Machine Electronics (EME) wiring harness connector (A190...
- Inform the customer during a consultation that the M Compound (standard equipment) and M Carbon Ceramic...
- For the eligible vehicles, BMW of North America, LLC (BMW NA) is extending the limited warranty for the...
- The discontinuation of 3G cellular communication for Combox, TCB 3G and ATM 3G (Telematics ControlModule)...
- Telematics unit deactivation due to 3G cellular technology discontinuation
- Telematics unit retrofit to 4G cellular technology
- Diagnosis of Compound Brake System Complaints in M Vehicles: 1. Visible cracks are caused by high thermal...
- Diesel fuel injectors: ltd wty extension to 10 years/120,000 miles
- Ticking noise from the front axle when cornering
- Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full: Low Washer Fluid Warning...
- Bmw turbocord portable EV 120 v/240 v charger
- Cracking noises from the frontaxle area while turning the wheels, when station
- Ticking noise while cornering without the brakes applied
- Vehicle does not start battery totally discharged
- Navigation system - reporting missing or incorrect roadmap data
- N47T/N57T EGR cooler ltd wty extension to 10 years without mileage limit
- Ticking noise while cornering without the brakes applied
- Tailgate unintentionally opens
- Check control messages for brake suspension and air bag system malfunction
- Automated activation of navigation system during pdi/QC1
- Connecteddrive/bmw assist system diagnosis information
- N47T/N57T EGR cooler - ltd wty extension to 10 years without mileage limit
- N47/N57T nox sensors before/after the scr-ltd wty ext to 10 yrs/120000 mi
- Diesel Engine Intake Manifold Damaged: If Recall Campaign 18V-755: Exhaust Gas Recirculation (EGR) Cooler...
- DIAGNOSING NON FUNCTIONING eDRIVE: Vehicle will not go into "eDrive". No pertinent electric drivetrain...
- Malfunction indicator lamp (MIL) multiple motor position sensor faults stored in eme
- Deactivation of the interior movement detector/tilt alarm sensor is not possible
- Limited warranty extension to 15 years/150000 miles
- Limited warranty extensionto 10 years/120000 miles
- Air bag lamp illuminated
- Noise when adjusting the steering column up or down
- Helpful information for customer discussions regarding motorsport vehicle brakes
- Helpful information for customer discussions regarding motorsport vehicle brakes: information
- Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full : The low washer fluid...
- N47T/N57T diesel fuel injectors: ltd wty extension to 10 years/120,000 miles.
- Vehicle will not unlock using the remote control key button.
- Rattle/popping from tailgate area
- GROANING NOISE FROM DOORS: A groaning noise is present from the door frame of any door most commonly when...
- GURGLING NOISE FROM SUNROOF DRAINS: A gurgling noise can be heard from the front sunroof.
- Security improvements for connecteddrive.
- N63T engine fuel injectors: limited warranty extension to 10 years/120000 miles
- Diagnostic hint: catalytic converter inspection after loss of crankshaft signal.
- N47T/N57T high pressure fuel pump: limited warranty extension to 10 years/120,000 miles.
- Engine vibrations or noise
- N55 engine: fc 28A0 or 101F01 throttle valve opening angle.
- Malfunction indicator lamp (MIL): ihka fc 801386
- Service Information May 2019 Engine Electrical Systems B12 15 19 Technical Service
- High voltage diagnostic specialist training and equipment strategy
- Information
- Telematics control unit activation via dcsnet for bmw assist.
- N47T/N57T diesel particulate sensor: limited warranty extension to 10 years/120000 mileage
- Eme ground connection monitoring faults - ccm - drive
- Vehicle does not start battery totally discharged
- The Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full This Service...
- This Service Information bulletin supersedes SI B01 14 17 dated August 2018.
- The vehicle does not start battery totally discharged.
- Standard occasional use cable charging complaint troubleshooting
- Humming noises when air conditioning is activated.
- Modified front brake pads are being supplied
- Automatic hatch does not open completely.
- Black spot in the central information.
- Malfunction indicator lamp (MIL) multiple motor position sensor faults stored in eme.
- Standard occasional use cable - charging complaint troubleshooting.
- SCR system fault 805256 stored in very cold weather.
- Door opens to first stage while driving.
- Sunroof repair kit components.
- The display goes black, the engine CAN be switched off only via the emergency-off..
- RAIN/LIGHT SENSOR (RLS): OIL LEAKAGE FROM GEL PAD. ??Oil leaking from the Rain/Light Sensor (RLS). Note:...
- Delivery stop: refrigerant air conditioning.
- Air bag lamp illuminated
- N63 and N63T engine: engine oil consumption, engine oil top-ups and refill capacity.
- DIAGNOSING NON FUNCTIONING eDRIVE. Vehicle will not go into "eDrive" No pertinent electric drivetrain...
- ?ENGINE LEAK DIAGNOSIS ON TURBOCHARGED V8 ENGINES. When diagnosing an engine oil leak or a coolant leak on...
- ?CONNECTEDDRIVE/BMW ASSIST SYSTEM DIAGNOSIS INFORMATION. ConnectedDrive/BMW Assist features are partially...
- ?BMW ONLINE NON-FUNCTIONAL: CHECK ICC-ID IN ACCOUNT. BMW Online/BMW ConnectedDrive not functional
- ?REMOTE KEY WILL NOT OPEN OR START VEHICLE. Remote key battery in service significantly less (under a...
- High-voltage battery safety box: limited warranty extension to 10 years/120,000 mileage
- Air bag lamp illuminated
- Connecteddrive/bmw assist system diagnosis information
- Diagnosis of Compound Brake System Complaints in M Vehicles
- The display goes black, vehicle doesnt start again after switching the engine off.
- X5 PHEV, I3 rex and I8 fuel tank pressure sensor: limited warranty extension to 10 years/120,000 miles
- Turbo boost actuator rod loose (diesel)
- Memory seat adjustment is limited
- Navigation system: reporting missing or incorrect road map data
- Component protection active
- Sme fcs 21F156 21F1F7
- Navigation pro (nbt evo) map update not possible, navigation does not start
- Bmw online non-functional: check icc-id in account: bmw
- Head unit high 2 reset while bluetooth is connected
- Malfunction indicator lamp (MIL): ihka fc 801386
- Drive warning ccm messages
- Cracking noises from the front axle area while turning the wheels, when stationary or parking
- Ticking noise from the front axle when cornering
- Instrument cluster outside temperature display implausible
- Nbt-evo
- Iphone: call list missing after restart
- Nbt-evo
- Connecteddrive-remote services do not function
- TICKING NOISE FROM FRONT AXLE ON TURNS: A hard mechanical clacking noise is heard when making turns coming...
- Leaking rear differential (QMVH)
- Tailgate unintentionally opens
- High voltage system: isolation faults
- BMW Maintenance Program: 12-Volt Battery Replacement Measure:
- Headlight assemblies have visible internal moisture/condensation
- HVAC BLOWER NOT WORKING: HVAC blower is not working.
- A/c failure: fc 801252 electric a/c compressor: internal fault detected
- Engine Oil Quick Reference Chart and Drain Plug Torque: The current version of ISTA/D has an error in the...
- Dme fault code CDC203
- Bmw apps randomly starts playing on its own
- Engine vibrations or noise.
- N20 and N26 engines turbocharger electric wastegate actuator linkage pin corrosion
- Cracking noises from the front axle area while turning the wheels, when stationary or parking
- No audio playback after replacing the head unit high 2 (HU-H2)
- Nbt-evo (next generation navigation professional) head unit cannot be swapped between vehicles for...
- Remote key will not open or start vehicle
- Bluetooth Connection Failures: There are various connectivity failures with the following devices: Apple...
- Noise when adjusting the steering column up or down
- EME FAULT CODES S0728 / S0729: A fault (S0728 for F15 PHEV or S0729 for i3) is found stored in the EME...
- NBT Head Unit High (HU-H) Resets Intermittently or Permanently
- Replace emissions label
- Lack of power or driving readiness cannot be established
- N63T and S63T engine: valve seal replacement
- Door Opens to First Stage While Driving
- Grating or Scraping Noise When Turning Steering Wheel
- Airbag warning light: acsm fc 930A60 or 930A1C seat occupancy detection.
- Sme fault code 21F04B.
- Noise from a/c on power-up and vent selection.
- ConnectedDrive/BMW Assist System Diagnosis Information This Service Information bulletin replaces SI B84...
- ConnectedDrive/BMW Assist System Diagnosis Information
- Powertrain faults due to chafing of engine wiring harness.
- ?General Electrical Systems Technical Service
- MIL OR ""POWERTRAIN MALFUNCTION!"" CCM DISPLAYED IN INSTRUMENT CLUSTER. One or both of the following check...
- Charging of the high voltage battery is interrupted and will not complete
- ?N20, N26, N55, N63TU, S63TU and S55 Engines: Bosch Injector ETK Part Number Error What's New: ?...
- Ticking Noise from the Front Axle When Cornering What's New: ? Changes to the procedure, parts information...
- Loss of seat adjustment control.
- Slight shuddering under acceleration from 40-60MPH.
- Check charging of the high voltage battery.
- HV CHARGING INTERMITTENTLY NOT POSSIBLE. HV charging is intermittently not possible
- Sme fault code 21F02A.
- ?BMW Maintenance Program: 12-Volt Battery Replacement Measure What's new: ? "Models" updated: Model Year...
- List of available FM radio stations temporarily not available
- ?Telematics Device Spares Replacement Part Activation via DCSnet for BMW Assist What's New: ? Model: All...
- DIAGNOSING NON FUNCTIONING eDRIVE: Vehicle will not go into "eDrive"
- Headunit navigation maps (hu-h HU-H2 hu-b)
- N20, N26, N55, N63TU, S63TU and S55 Engines: Bosch Injector ETK Part Number Error What's New: ? Procedure...
- Thump at end of rear window travel .
- ?NBT HEAD UNIT ABORTS IMPORT OF CD Whats New: ? G12 (7 Series) removed ? I01 (i3) removed ? Warranty...
- ?SATELLITE RADIO DETERIORATION IN RECEPTION QUALITY DUE TO NEW CELLULAR FREQUENCIES . INFORMATION Inform...
- ?N63T AND S63T ENGINE: VALVE SEAL REPLACEMENT . This SI provides a new tool and a new procedure for the...
- ?N63, N63TU, N63R, S63 AND S63TU ENGINES: UPPER OIL PAN REMOVAL AND INSTALLATION REPAIR INSTRUCTIONS This...
- ?CCM: ""START/STOP FAILED"": LOSS OF POWER . Malfunction Indicator Lamp (MIL) is illuminated Check Control...
- ? DIAGNOSING NON FUNCTIONING ""eDRIVE"" This Service Information bulletin supersedes SI B12 27 16 dated...
- ? DIESEL PARTICULATE FILTER (DPF) CLEANING . The following performance issues may be noticed by the...
- ? NO REGENERATION OF THE DIESEL PARTICULATE FILTER (DPF) This Service Information bulletin supersedes SI...
- ?AUTOMATIC TRANSMISSION DRIVEABILITY COMPLAINTS . Hesitant drive off, sluggish driving behavior
- ?RATTLE/ POPPING FROM REAR HATCH AREA . There are two related but separate issues (only one may be present...
- Change to PHEV HV battery cell modules
- ?Service action: targeted illumination
- ?June 2016 Maintenance and General Hints: technical Service Plugin Hybrids, (PHEV) MPGe Fuel Economy Rating.
- ?Emissions Recall Campaign 16E-A03. Please perform the procedure outlined in this Service Information on...
- ?SERVICE ACTION: REAR SIDE WINDOWS MAY NOT BE PROPERLY AFFIXED TO BODY. Please perform the procedure...
- ?Electrostatic discharge damage the seat module
- ?SERVICE ACTION: CHECK CHARGING OF THE HIGH VOLTAGE BATTERY Please perform the procedure outlined in this...
- ?MIL LAMP ILLUMINATED due to an internal fault in the EME. Replace EME.
- Loss of seat adjustment control.
- Sme fault code 21F21F.
- Delivery stop: check the charging process of the high-voltage battery.
- Si B65 09 15
- DIAGNOSING NON FUNCTIONING ""eDRIVE"". The
- FC 44E4D1 stored in Transmission Control Unit, either: 1. When no other fault codes stored
- Headlight assemblies have visible internal moisture/condensation.
- Third Row of Seats Blower is Inoperative
- Nbt-evo
- Shudder or jerking in 7TH and 8TH gears at 1000
- Cbs brake pad calculation and correction.
- ?AUDIO VOLUME NOT RESTORED AFTER MSA STOP, ENTRY HEAD UNIT. Volume of audio system (when set to near...
- Nbt navigation does not route on toll roads
- Kafas camera-based assistance system limits
- Check control message: no oil pressure.
- Dde fault code: 28DE00 - exhaust gas pressure sensor before turbine, plausibility.
- Clicking noise from front axle
- Service engine soon (MIL) - sme fc 21F20D.
- HVAC blower not working
- Diesel Engine: Intake Manifold Damaged This Service Information bulletin supersedes SI 11 07 16 dated May 2016
- Delivery Stop: Remove Engine Oil Label
- Tailgate unintentionally opens.
- Noise from the front seat when entering / exiting the vehicle.
- Charging Not Possible
- HVAC BLOWER NOT WORKING. HVAC blower is not working
- A/c failure: fc 801252 electric a/c compressor: internal fault detected.
- Information on the operation of the smart opener
- Incorrect tire and loading information label.
- Bmw online non-functional: check icc-id in account.
- Bmw online non-functional: check icc-id in account
- Ticking Noise from the Front Axle When Cornering This Service Information bulletin supersedes SI B34 05 15...
- Head-up Display is no Longer Visible
- Diesel Engine: Intake Manifold Damaged
- Program Variable Damper Control (VDC) Unit
- BMW Maintenance Program: 12-Volt Battery Replacement Measure
- HeadUp Display does not Show Full Street Names
- N63, N63TU and N63R Engines: Upper Oil Pan Removal and Installation Repair Instructions This Service...
- Program control units (DME data status)
- Delivery Stop
- F15, F30 PHEVs- Gear Selector Plausibility Faults
- Passenger Side Mirror Dimming Feature Operational Change
- Charging Not Possible
- Incomplete AdBlue Check Control Message (CCM) on the Central Information Display
- Crackling Noise from the Fresh Air Grille This Service Information bulletin supersedes SI B64 05 16 dated...
- Airbag (SRS) Warning Lamp Illuminated
- ""Collision Warning Failed"" or ""Pedestrian Warning Failed"" CCM Display
- Bluetooth Connection Failures
- Tech24 Snap-in Adapter Return
- CM ""Engine fault! Power loss"" and/or ""Battery charging fault!"". Upon unlocking or starting the...
- The Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full
- SOS Malfunction Is Displayed In Kombi Sporadically
- TEC26 Turbo Charger Return
- Tec25 Wishbone Return
- CCM ""Engine fault! Power loss"" and/or ""Battery charging fault!"". Upon unlocking or starting the...
- Humming/Buzzing Noise from Passenger Side Dashboard
- Air Conditioning Refrigerant R1234yf Introduction
- Crackling Noise from the Fresh Air Grille
- False Alarms of the Anti-Theft Alarm System
- NBT Head Unit Aborts Import of CD. While importing a CD to the internal music collection of an NBT head...
- NBT and Entry Head Unit Software Update for Improved Satellite Radio Reception
- Nbt-evo
- ""Comfort Access Restricted"" Check Control Message is Displayed
- MINI "Enhanced" dealer self authorized (DSA)K goodwill program
- MINI engine oil part number transition and model year 2016 engine oils
- Under certain engine operating conditions the measured air mass between the cylinder banks 1-4 and 5-8 is...
- The DDE software application for exhaust gas recirculation control (EGR) does not favorably match the...
- Si B13 03 15
- Si B36 01 15
- February 2016 General Electrical Systems Technical Service This Service Information bulletin supersedes SI...
- Head-up Display is no Longer Visible
- Subject
- Si B84 03 14
- Vehicles which have had the Instrument Cluster (KOMBI) replaced may display incorrect CBS (Condition Based...
- Instrument Cluster Multifunction Display Intermittently Blank . Some information displays in the...
- Whistling Noise Coming from the Center Vent
- Program PHEV Control Units
- ?SI B13 10 15 Fuel Systems December 2015 Technical Service
- Ticking Noise from the Front Axle When Cornering
- Sunroof Makes a Creaking Noise During Operation
- The Low Washer Fluid Warning Light is illuminated when the Washer Fluid Tank is Full
- Instrument Cluster Outside Temperature Display Implausible
- SI B12 39 15November 2015 Engine Electrical SystemsTechnical Service This Service Information Bulletin...
- Leaking Rear Differential (QMVH). There is an oil leak from the rear differential housing
- Charging Not Possible
- Instrument Cluster display is partially blank
- Instrument Cluster display inoperative FC B7F689
- HU-H: Headunit Resets Intermittently or Permanently
- Comfort Access Does Not Function After Vehicle Enters Sleep Mode
- Check Control Message: Tire Pressure Monitor (RDCi) Failure
- Instrument Cluster display is partially blank
- N57T
- Shudder from the Driveline on Vehicles with xDrive
- Diagnosis of Compound Brake System Complaints in M Vehicles This Service Information bulletin supersedes...
- This Service Information bulletin supersedes SI 37 02 14 dated February 2015
- Grating or Scraping Noise When Turning Steering Wheel
- Vibration or Shudder from Driveline when Accelerating from a Stop
- Engine Malfunction Warning Illuminated with FC 193208: Fuel Level Plausibility Stored in DME. The
- Reduced Engine Power with ""Charging Pressure Too High"" Faults Stored
- Noise When Adjusting the Steering Column Up or Down
- Ticking Noise from Front Axle When Cornering
- Affected vehicles in dealer inventory must not be retailed or delivered until the label is removed
- Rear Seat Heater Inoperative
- NAV Road Map Installation Using USB Stick
- Clicking noises are coming from the front axle when driving on low speed
- Clicking Noise from Front Axle
- ?SI B12 21 14May 2015 Engine Electrical SystemsTechnical Service This Service Information bulletin...
- Valve Stem Replacement with Wheel Electronics
- Check Control Messages Related to Battery Charge During Cold Ambient Temperatures
- A/C Makes Unusual Whistling Noise from Center Vents
- A/C Operation: Reduced or No Airflow After Long Drive
- ?SI B00 06 14April 2015 Maintenance and General HintsTechnical Service This Service Information bulletin...
- Program Control Units (SCR). The Selective Catalyst Reduction (SCR) control module can make an error when...
- Surround View Camera Last User Mode Operation Change
- N63T: Oxygen Sensor Internal Resistance Faults
- Water Leaking from Headliner
- Heating and Air Conditioning March 2015 Technical Service This Service Information bulletin supersedes SI...
- One or both of the situations listed below may be encountered: ? Android device connection stability...
- SI B12 21 14February 2015 Engine Electrical SystemsTechnical Service This Service Information bulletin...
- Subject
- SI B37 02 14February 2015 Special Suspension SystemsTechnical Service This Service Information bulletin...
- ?SI B37 03 14February 2015 Special Suspension SystemsTechnical Service This Service Information bulletin...
- SI B61 30 14February 2015 General Electrical SystemsTechnical Service This Service Information bulletin...
- Subject
- Airbag Warning Light: ACSM FC 930A60 or 930A1C Seat Occupancy Detection
- Subject dme
- Subject N55
- SUBJECT N20, N26, and N55 Engines with Injector Electrical Faults
- SI B16 16 14January 2015 Fuel SystemsTechnical Service This Service Information bulletin supersedes SI B16...
- This Service Information bulletin supersedes SI B65 13 12 dated September 2012
- This Service Information bulletin supersedes SI B65 24 13 dated January 2014
VIN decoder
See the problems and recalls for an exact car
Buying a used 2016 BMW X5?
Check the exact car before you pay: accidents, salvage or flood titles, odometer readings and previous owners.
Check its history