2016 Ford E-350 problems

Filed Aug 3, 2023 · Transmission · 100,000 miles · WY

 The contact owns a 2016 Ford E-350. The contact stated that while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to an independent mechanic, who related the failure to Ford Campaign Number:19B40 (Coast Clutch Cylinder and One-Way Clutch Replacement). The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 100,000.

Filed Mar 27, 2019 · Body · MD

The econoline van for the exhaust odor, when we first tested the vehicle in the shop with the vehicle running (no exhaust hose on the tailpipe) the co detector read 49 ppm after about 15 minutes. When we tested the second time, the vehicle was in the same spot but a exhaust hose run from the tailpipe to outside the shop and the co detector read 9 ppm after about 15 minutes. The third test, the vehicle was outside and after about 15 minutes the co detector read 0 ppm and we also tested in the utility body which read 0 ppm. We know that the vehicle is not leaking exhaust, any "exhaust odor" or co measured in the cabin of the vehicle is most likely from the exhaust surrounding the vehicle and entering through the porous utility body. *dt

Filed Mar 20, 2018 · Seats · 2,833 miles · OH

Vehicle is upfiitted by morgan olson with seats by freedman seating. The pin that holds the seat pedestal to the seat base falls out and the seat falls to its lowest position without warning. This has happened to several of our fleet trucks. The detent ball spring is to weak. We have modified 2 of our vehicles by drilling out the ball and installing hairpin clips. On the others we have installed a zip-strip through the pin ring while waiting for instruction from morgan olson concerning a authorized repair. Have made several attempts to obtain feedback over the course to 2 years, but have not received any instruction as to how this issue is being handled. The seat fell while the vehicles were in motion in every incident, startling the driver.

Filed Mar 2, 2018 · Brakes · 4,000 miles · OH

The parking brake cable is routed through the left front wheel area in such a way that the tire contacts it during normal steering/suspension movements and is chaffing the cable.

Filed Mar 2, 2018 · Transmission · 4,000 miles · OH

The automatic transmission shifter control cable contacts the parking brake pedal assembly, therefore when applying/releasing the parking brake the cable is getting chaffed.