2020 Ford Explorer: windshield wiper failure

Filed Oct 8, 2026 · Steering, Transmission · MI

on the highway it was raining heavily, and my [XXX] old was in car back seat. Suddenly wipers stopped working, Steering wheel wasn't working, indicator was not working, I was getting multiple warnings on my screen. We would have ended up in a major accident. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Jul 27, 2026 · Electrical · IN

My wife was driving and the horn started blowing and the rear wiper started ejecting all the wiper fluid. When I showed up to assist, it smelled super hot and I had to pull the fuse and negative lead to make the wiper pump and horn stop. It was towed to a Ford dealer, who found the main engine harness had MELTED going into the engine compartment fuse box. The horn and wiper fluid pump also had to be replaced. It's fortunate this did not result in a fire. Ford dealer had the vehicle for TWO MONTHS to repair (and we had to take it back for the horn and washer pump). The Ford dealer said they could not give any reason for why this happened. The entire main harness and fuse panel had to be replaced. No check engine or warning lights appeared when this happened. My wife had to pull over on the side of the road.

Filed Jul 21, 2026 · Visibility · TX

The front windshield wiper motor on my 2020 Ford Explorer is experiencing severe intermittent failure and physical binding/clunking while in operation, resulting in a total loss of front visibility while driving in rain. This failure matches the exact root cause and symptoms described in Ford Safety Recall 26S14 / the federal safety agency Campaign 26V117 (intermittent wiper function progressing to complete electrical continuity failure due to internal terminal misalignment). However, Ford claims my specific VIN falls just outside their designated production date window, leaving my vehicle uncovered under the safety recall despite suffering from the identical defect. Although Ford confirmed there is an active Customer Satisfaction Program (CSP) listed for my vehicle's wiper motor, severe supply chain restrictions and dealership backlogs have prevented repairs. Ford has placed a restricted distribution hold on replacement motors, preventing independent shops and local dealers from securing parts, while requiring a multi-day diagnostic wait during which I am expected to drive a vehicle with non-functioning wipers. Driving a vehicle with active, unpredictable wiper failure poses an immediate safety hazard and severe crash risk. Ford's refusal to expand recall coverage or immediately supply unrestricted safety components leaves vehicle owners exposed to hazardous driving conditions. Furthermore, customers face a mandatory four-day intake period solely for vehicle diagnostics. To qualify for a wiper motor replacement under warranty guidelines, Ford requires the motor to experience total failure while under dealership care. If technicians are unable to duplicate the fault condition during testing, the vehicle is returned to the owner without repair, leaving an ongoing safety hazard completely unresolved. I have also contacted Ford Corporate and filed a formal complaint and that was of no assistance.

Filed Jun 20, 2026 · Electrical, Visibility · NJ

The front windshield wiper on my vehicle,may become inoperative. The Ford Motors says that they don't have the part to replace,and when they have it I have to pay for the repair.

Filed Apr 30, 2026 · Transmission · WA

Customer states the charging system light is on and there is a starting system fault, please advise verified concern. Retrieved otcs ano p0a1e, u0120 present in PCM. Cleared ores and light stayed on ano both returned. Customer left vehicle for diagnosis. Pulled vehicle into bay and warning lights off. Retrieved dtcs- p0a1e, u0120 memory in PCM. Cleared dtcs and both cleared. Test drove vehicle ano battery light returned with b11d9:09 in bcm and p06ef in PCM. Suspect voltage concern. Removed wiper cowl and trunk trim, disconnected and warranty charged/tested both batteries- both passed. Reassembled vehicle, cleared dtcs and test drove- no concerns returned. Test drove again next day ano no concerns present. Concern was module errors caused by discharged battery from sitting for extended period of time. Concern resolved during diagnosis.

Filed Mar 10, 2026 · Visibility · IA

My Right windshield wiper dose not working properly . When I turn on the wipers the right one don't move . Sometimes it will come up but the only one that's works right is the left one . This is a safety hazard for driving

Filed Oct 4, 2022 · Visibility · IL

On multiple occasions the wipers have stop working while raining. The bounce back and forth about an inch. This on at least 4 separate occasions forces us to pull over on the side of the road, including the highway. With not being able to see the shoulder well, we had to slow way down causing a potential hazard for other vehicles on the road as we try and navigate to the side of the road. Restarting the vehicle does not seem to do the trick. Sometimes stopping the wipers, picking them off the windshield and letting them smack on the window. This sometimes works. This increases the risk for severe injury on the side of the road outside the car in less than ideal driving conditions. I have taken the car to the dealership multiple times and they refuse to do anything because they cannot duplicate the issue. I showed them videos and did not car. Called ford, opened case with them. They did not do anything after 2 weeks. They've given me no suggestion or offered any solution or option. The last time it was a downpour and could not see anything. I had to slow down to less than 20mph, stick my head out the window to try and find a place to pull off as this road did not have a shoulder.

Filed Aug 22, 2022 · Visibility · 48,000 miles · MO

The contact owns a 2020 Ford Explorer. The contact stated that while activating the windshield wipers, the driver’s side windshield wiper was inoperable. The vehicle was taken to the dealer and the driver’s side windshield wiper was replaced; however, the failure reoccurred. The vehicle was taken to the dealer and the mechanic stated that the bracket had sunk into the vehicle causing the wiper to not function correctly. The mechanic stated that an additional screw would be added for the wiper to function as needed. The vehicle was not yet repaired. The manufacturer was not contacted. The failure mileage was 48,000.