2020 Ford Explorer: engine stalls while driving

Filed Oct 16, 2026 · Transmission · 72,000 miles · SC

The contact owns a 2020 Ford Explorer. The contact stated that on more than one occasion, the vehicle stalled while driving. The contact stated the vehicle experienced difficulty shifting into gear. The vehicle was taken to an independent mechanic, where diagnosis confirmed the transmission failed and required replacement. The vehicle was repaired. The manufacturer was notified of the failure. The contact associated the failure with the federal safety agency Campaign Number: 26V402000 (Power Train). The failure mileage was 72,000.

Filed Oct 4, 2026 · Lights · MI

Drivers side low beam intermittently does not operate. Becoming more and more common. Now, passenger side lamp is doing the exact same thing, and both shut down while in motion at night. These lamps should not fail like this. There is an existing recall for 2026 vehicles with the exact same issues.

Filed Jul 28, 2026 · Transmission · 90,000 miles · CT

The contact owns a 2020 Ford Explorer. The contact received notification of the federal safety agency Campaign Number: 26V402000 (Power Train); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated that while driving at an undisclosed speed, the vehicle jerked back and forth and then stalled. No warning light was illuminated. The contact turned off and restarted the vehicle, but the failure persisted. The vehicle was taken to a transmission specialist; however, the cause of the failure could not be determined. The dealer was not made aware of the failure. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 90,000.

Filed Jul 23, 2026 · MI

I own a 2020 Ford Explorer Platinum equipped with Adaptive LED Headlamps. The passenger-side low-beam headlamp intermittently failed and would turn off while driving. The vehicle displayed the warning message, **"Check Headlamp System – See Manual."** Initially, the headlamp would occasionally begin working again after restarting the vehicle, but for approximately the past three months, the passenger-side low beam has remained inoperative. The failed component is the passenger-side adaptive headlamp assembly and related headlamp system. The vehicle is available for inspection upon request. This creates a significant safety concern because nighttime visibility is reduced with only one functioning low-beam headlamp. It also makes it more difficult for other drivers to see my vehicle, increasing the risk of a crash, especially on dark roads or during poor weather conditions. The warning message first appeared before the headlamp permanently failed. The problem was intermittent at first but has progressively worsened until the passenger-side low beam no longer functions. I have learned that numerous owners of higher-trim Ford Explorers equipped with Adaptive LED Headlamps have reported experiencing the same issue. I understand that similar complaints have already been submitted to the federal safety agency. The replacement cost is extremely expensive and often requires replacement of the entire adaptive headlamp assembly, leaving owners to pay out of pocket for what appears to be a widespread defect. I respectfully request that the federal safety agency investigate this issue to determine whether a manufacturing or design defect exists and whether Ford should issue a recall or other corrective action. Also, I do have the vehicle available to show.

Filed Jul 2, 2026 · Transmission · NC

The transmission shifts into park while driving causing the vehicle to jerk and slow down or stall. I contacted Ford and they stated that this was not a safety issue and that this was an advance notice and that no remedy is available until June 2027. They refused to provide a loaner vehicle until this time when the recall is "released". June of 2027 is a year from now and I drive this car daily with small kids and I am afraid that this vehicle will stall while driving and cause harm or death to my family members.

Filed May 20, 2026 · Transmission · VA

When trying to accelerate on interstate drive train light and I have to pull over turn off car on interstate then start again to keep out of limping mode also when backing up car stalls jumps and makes a grinding noise need a remedy

Filed May 6, 2026 · Engine · AR

Vehicle with 42k miles and regular dealer maintenance suddenly stalled out in traffic, creating dangerous situation for driver and children passengers. Towed to dealership from which it was purchased. Told it was a catastrophic engine failure and had coolant and oil mixed. Dealer unwilling to explore exact cause. Vehicle 11 months past 5 year power train warranty but well under mileage.

Filed Apr 17, 2026 · Electrical · 113,849 miles · TX

The contact owns a 2020 Ford Explorer. The contact stated that while driving approximately 65 MPH, the vehicle lost automotive power and stalled. The contact stated that there was an abnormal whining sound coming from the vehicle prior to the vehicle stalling. The vehicle was stopped and there was an abnormal burning rubber odor inside the cabin of the vehicle. The contact stated that the messages “Charging System Fault” and “Service Steering” were displayed. The contact stated that unknown warning lights were illuminated. The vehicle was towed to the residence. The contact stated that her husband replaced the battery and the alternator, however the failure persisted, and the vehicle was losing automotive power. The vehicle had not been taken to a local dealer or independent mechanic. The vehicle was not diagnosed or repaired. The contact researched online and related the failure to the federal safety agency Campaign Number: 19V687000 (Electrical System). The manufacturer was informed of the failure, and the contact was informed that the VIN was not included in the recall. The failure mileage was 113,849.

Filed Feb 16, 2026 · Engine, Transmission · CA

I own a 2020 Ford Explorer with approximately 85,776 miles. The vehicle has experienced two separate loss-of-propulsion events in traffic. On both occasions, the vehicle suddenly lost power while driving and stalled in the middle of a busy intersection. There was no prior warning of imminent engine failure. After stalling, the vehicle would crank but would not restart. The vehicle was disabled in the intersection for approximately 45 minutes to one hour each time. My family was inside the vehicle during these incidents. The vehicle displayed multiple malfunction warnings including “Shift System Fault” and messages indicating the vehicle was not in Park even when the shifter was in the Park position. The dealership, Hansel Ford of Petaluma, verified the concern and referenced Ford Technical Service Bulletin (TSB) 23-2249 related to internal transmission components, including the valve body and park pawl actuator system. The dealership confirmed that when the vehicle is placed in Park, it may actually remain in Neutral. This creates an additional safety risk of unintended vehicle movement. This issue presents a serious safety hazard due to: •Sudden loss of propulsion in traffic •Vehicle disabled in active intersections •Extended inability to restart •Potential rollaway risk due to Park malfunction The vehicle is currently pending major transmission-related repairs. I am submitting this complaint due to concerns about loss of propulsion and park system malfunction creating a safety risk for occupants and surrounding traffic.

Filed Jan 6, 2026 · Electrical · NY

I have a leaking antenna (likely the "shark fin" or roof antenna base) on my 2020 Ford Explorer. This has caused significant electrical issues, leading to safety concerns like malfunctioning lights, infotainment, or even stalling, the water shorting wiring harnesses or modules located in the roof or headliner area. This should be a recall, but rather it is a known problem where water intrusion damages sensitive electronics, necessitating immediate professional inspection and repair to prevent further damage and ensure safety, as electrical failures can be dangerous. My GPS and satellite do not work because of this and I am being charged significantly by the dealership because I have to repair this or the damage will become more severe. The antenna's base seal can fail, allowing water to seep into the roof, drip down the pillars, and saturate the headliner and wiring harnesses. Common Symptoms: Interior lights, instrument cluster, or dashboard warnings. SYNC system freezing or failing. Windows, locks, or other accessories malfunctioning. Even potential water on the front passenger floor. Safety Risks: Loss of Control!!!!!!! Malfunctioning lights (headlights, brake lights) or sudden power loss can create dangerous driving conditions. Reduced Visibility: Issues with the infotainment screen or instrument cluster can distract the driver. System Failures: Critical safety systems, if affected by water, could fail unexpectedly. I barely get car washes or anything. This is certainly a manufacturers issue & poor design or cheap casing/ seals that leak and corrode too easily. This problem is a known weakness for the 2020 Explorer, often requiring a thorough inspection beyond just the antenna itself, as water can travel far from the entry point. And sure enough I have plenty of damage that I should not have to pay for. This is not a fluke, there are forums all across the internet about this. Please help! This is truly unfair to the customers.

Filed Aug 4, 2025 · Lights · MD

Headlamp modules and headlamp do not properly function. Water can get into the module causing zero lights for the driver and is a safety hazard. Lights flicker or just turn off while driving. Electrical issue and not designed or installed properly. It should be able to be fixed with a new lightbulb but that is not the case.

Filed Jul 8, 2025 · Electrical, Engine · 89,156 miles · OH

The contact owns a 2020 Ford Explorer. The contact stated that while reversing, the vehicle stalled. The vehicle jolted forward while parking. The brakes were locking up. While driving 5 MPH, the steering wheel locked up. The 4-WD fault light was illuminated. The contact stated that the Pre-collision Assist, Hill Assist and Reverse messages were displayed. The contact stated that the failure was related to Technical Service Bulletin: 23-2174. The vehicle was taken to the local dealer, where it was diagnosed that the AWD actuator was faulty and needed to be replaced. The vehicle was not repaired. The manufacturer referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 89,156.