2020 Ford Explorer: transmission slipping

Filed Oct 19, 2026 · Transmission · SC

I was driving to work on XXX. My explorer slipped out of gear while driving. I was a minute from work so I went and parked it. The vehicle wouldn’t shift out of gear or into park. The symptoms seemed to be tied to recall 26S48 / the federal safety agency Recall 26V402 so I had the car towed to a ford dealership. The service guy said it would be diagnosed in 1-2 weeks. It was finally diagnosed 3 weeks later. The service person told me I’d need a new transmission and it would cost 9800 to replace. I asked for the mechanics notes and diagnostic codes. They sent this: “Concerns verified, no crank no start the vehicle is stuck in park setting dtc P07E4. Found ssm 49685 and checked ground G210 and G214. Both grounds are not loose continued normal diagnosis. Completed work shop manual pinpoint test I. Found no issues with PCM or transmission harness wiring. Removed the transmission fluid pan for further testing. Found that the transmission fluid is black in color and is contaminated with metal debris. Found large chunks of steel within the transmission fluid pan. With further inspection found that the park pawl actuator rod has broken and has caused damage to the parking pawl causing the vehicle to hang in park. Dtc P07E4 sets because the vehicle cannot physically shift out of park. This failure has caused fluid contamination and has caused further damage to the transmission. Catastrophic failure is present. Transmission replacement is recommended along with replacing the transmission fluid cooler as fine metal debris may not be able to flushed from the cooler. -- [XXX]” I believe that the park pawl breaking is exactly the recall issue. I called ford corporate and they said they can’t do anything until the final remedy notice letter comes out at the end of this week 10/23 and can’t do any interim repairs until the recall is finalized. I texted the dealership to hold the vehicle until the letter is released. I’ve been out of a vehicle for a little over 3 weeks and frustrated. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT

Filed May 21, 2026 · Transmission · PA

While the vehicle was under warranty, I reported a transmission problem to an authorized Ford dealership involving sudden slipping out of gear into neutral at highway speeds, resulting in momentary loss of power and acceleration. The dealership performed diagnostic testing but stated they could not identify a problem and advised that the vehicle was safe to continue driving. The condition persisted intermittently. After the warranty period expired, the vehicle experienced a catastrophic transmission failure while on a heavily traveled highway. The vehicle suddenly lost power and the rear wheels locked, creating a dangerous traffic situation requiring assistance from two state police vehicles until the vehicle could be towed. The vehicle was taken to the same Ford dealership that previously evaluated the transmission concern. The dealership then diagnosed a complete transmission failure requiring replacement at a cost of approximately $9,000. I contacted Ford Headquarters regarding this issue and the prior warranty period complaint, but Ford has not responded to the matter in any way. I believe the transmission failure is a continuation of the original transmission defect that was reported during the warranty period but not repaired. I am submitting this complaint because of the significant safety risk created by sudden loss of power and rear wheel lockup while driving at highway speeds. All documentation of original issue and current repair is at the Ford Dealership.

Filed Sep 24, 2025 · Engine · IA

slipping gears between 1&2nd gear, harsh/delayed shifting, some power loss. Vehicle is around 120k miles

Filed Aug 27, 2025 · Transmission · AL

While braking vehicle downshifted harshly with a noticeable slam into gear. While under acceleration, vehicle rpms raised sharply as transmission slipped and would not engage and accelerate. Potential risk to injury as vehicle transmission failed on interstate with loss of acceleration. Towed vehicle to Ford dealership. Ford dealership inspected to the conclusion of "Fluid full/extremely burnt. Possible A clutch failure due to faulty front support". Ford dealer recommended to remove and replace transmission. - Transmission failure, not available for inspection. - Safety risk due to transmission failure at interstate speeds with loss of acceleration. - Problem reproduced by Ford dealership - Transmission inspected by Ford dealership - Wrench light illuminated shortly after initial harsh downshift and acceleration with transmission slip.

Filed Aug 18, 2025 · Transmission · OK

What component or system failed or malfunctioned, and is it available for inspection upon request? The transmission failed at approximately 80,000 miles. It requires a complete rebuild/replacement. The failed transmission is available for inspection upon request. It is currently at the transmission shop. How was your safety or the safety of others put at risk? Although the vehicle was technically still drivable, it did not feel safe. The transmission slipped and struggled to shift, and the vehicle felt like it could break down or cause a wreck at any point. The sudden and unpredictable loss of proper control put me and other drivers at risk. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. An independent transmission repair service confirmed the failure and determined that the transmission required a full rebuild/replacement. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? The vehicle has not been inspected by the manufacturer, police, or insurance representatives. It has only been inspected and diagnosed by an independent repair service. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? There were no warning lamps or dashboard messages prior to the failure. The first symptoms were slipping and difficulty shifting gears, which began shortly before I took it to a repair shop.

Filed Aug 18, 2025 · Transmission · AZ

Transmission slipping at 32m/h when downshifting

Filed Jul 29, 2025 · Driver assistance, Transmission · NY

At approximately 30k miles (but after the 5 year warrantee had expired) the car started giving warnings about the brake system failing even though the brakes worked properly. Shortly after that, and without any warning indicators on the dash, the car began jerking when applying the brakes and down shifting at 35 mph. In the 4 months since the problem started, the jerking has become violent and other issues have begun. It also jerks when downshifting at 25 mph occasionally. It has a problem upshifting in gears 1-4, especially (but not only) when accelerating quickly. It seems that the gears are slipping. The engine revs higher because the gears are not properly shifting. My 18 month old child, my wife, and I have been put at risk driving in a vehicle that fails to shift properly accelerating through intersections and stopping at intersections. Both a Ford dealership and an independent auto repair shop have duplicated the problem and said the car needs either a new transmission ($8k) or to replace parts in the existing tranny that would cost $6k. Evidently there is a TSB from Ford on this issue, but not a recall. Ford has refused to offer financial assistance.

Filed Jul 14, 2025 · Transmission · 19,000 miles · NJ

The contact owns a 2020 Ford Explorer. The contact stated that while driving at an undisclosed speed the transmission was slipping and the vehicle was slow accelerate. The vehicle lost motive power. Additionally, the contact stated that the RPM was high while driving at low speeds. No warning lights were illuminated. The vehicle was taken to an independent mechanic, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was repaired, but the failure reoccurred. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 19,000.

Filed Jul 6, 2025 · Transmission · NH

11/5/24 Transmission failed. Gear selector knob went unresponsive. Wrench light on dash came on. 1/2/25- new transmission received. 4/25/25- car hesitates going into reverse gear- 10 second delay. Still continues. 7/1/25- transmission starts slipping again. 7/2/25- transmission slamming while accelerating.

Filed Jun 28, 2025 · Transmission · CT

The rear axle is slipping when going up any incline and when traveling on regular roads has vibration they have a recall but say mine not covered when it comes from the same plant in question during the time frame listed

Filed Jun 10, 2025 · Transmission · VA

On May 14, 2025, at approximately 72,000 miles, the vehicle began making a loud rumbling noise when put into gear and proceeding in forward or reverse. The rumbling\shaking would happen to a lesser degree if torque was maintained in the system and all turns were made while accelerating. The vehicle was immediately taken to the Ford Dealership. The transmission tech began to back up the vehicle, at which point the rumbling\shaking occurred and the tech stated that the rear differential (RDU) had failed. The vehicle was left at the Ford Dealership awaiting complete diagnosis. The vehicle was previously taken to the dealership on October 8, 2024, October 14, 2024, October 24, 2024, November 19, 2024, and December 16, 2024 to have the rumbling\jerking\slipping issues fixed and the complete drivetrain evaluated. On May 30, 3025, the owner was advised that the diagnosis was a failed rear differential and a failed transmission. As documented in the federal safety agency Safety Issue ID# 11655556, both front axles were just fully replaced replaced three times on October 2, 2024 (65,221 miles), October 16, 2024 (65,301 miles), and October 28, 2024 (65,597 miles) September to address issues with severe vibrations and rumbling which occurred when making turns and driving around curves. These severe vibrations and rumblings coupled with rough shifting and a hop\slip of the transmission when approaching 0 mph caused alarm and deep concern to the passengers in the car, so much so that they expressed fear for their safety as the vehicle shook and jerked. The axle replacement on October 28, 2024 included performing TSB 23-2174 to swap axle types completely by removing the Front Axle Disconnect Assembly. The rumbling\clunking\hopping\slipping persisted off and on after the replacement of the axles and transmission (TCM\PCM) reprogramming by the Ford Dealership. There were no warning lights or messages. The passengers were scared to ride in the car and the driver was nervous. Vehicle can be inspected.

Filed May 4, 2025 · Transmission · MN

At 84000 miles, just roughly 6k after my "extended warranty" expires ford says my transmission needs to be replaced. I had an issue with my transmission September 07, 2023, they looked at it verified it was slipping and the fluid was dirty but did nothing to replace it at that time acting like that was normal. Ok. It would have and should be covered under the warranty I paid for, they took advantage of me because I'm a women. I have the paperwork from that and I would like someone to reach out to me personally. On top of that there is a recall on other 2020 ford explorer with the exact same engine and transmission as mine. At 84000 miles I should not be looking at replacing a 10,000$ transmission! Especially when they should have fixed it the first time.