2014 Ford Fusion: engine overheating

Filed Nov 8, 2026 · Engine · GA

Shortly after purchasing the vehicle it began to loose oil seemingly out of nowhere, there were no visible leaks or drain spots on the ground where the vehicle would sit. Now my engine will not function properly because coolant is constantly mixing with the engine and causing overheating/stalls. The only fix I've been advised of is total engine replacement which I cannot afford and do not feel should be responsible for since this is a known issue with the engine model/year of vehicle.

Filed May 14, 2026 · Engine · LA

coolant leaking into engine * sudden engine failure risk * overheating * loss of power * expensive engine replacement from known defect 2014 Ford Fusion EcoBoost is losing coolant internally into the engine. Ford dealership diagnosed coolant intrusion requiring full engine replacement costing approximately $14,000. This appears to be a known defect affecting many Ford EcoBoost vehicles. Vehicle experiences coolant loss and risk of engine failure.

Filed Jun 9, 2025 · Electrical, Engine · GA

I had multiple coolant leaks in the pass and I have to constantly replace the hose about every 2000-3000 miles Also my screen went out in my dashboard causing me to not be able to make any audio changes or station adjustments in my car Lastly whenever I get ready to increase my speed my car jerks back

Filed Mar 24, 2025 · Engine · 188,000 miles · NC

The contact owns a 2014 Ford Fusion. The contact stated while driving 10 MPH, the vehicle was shaking with a rattling sound coming from the engine compartment. A code was displayed on the instrument panel; however, the contact was unsure what the code referenced. The contact stated that the vehicle was not safe to drive. The contact stated that an independent mechanic inspected the vehicle and diagnosed that there was a coolant leak, causing the coolant and oil to mix that caused engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The mechanic informed the contact of the federal safety agency Campaign Number: 17V209000 (Engine and Engine Cooling); which was related to the failure experienced. The manufacturer was informed of the failure and confirmed that the VIN was not included in the federal safety agency Campaign Number: 17V209000 (Engine and Engine Cooling) and opened a case. The manufacturer referred the contact to the federal safety agency Hotline to report the failure. The failure mileage was approximately 188,000.

Filed Jan 27, 2025 · Engine · 65,000 miles · MA

The contact owns a 2014 Ford Fusion. The contact stated while driving at an undisclosed speed, the engine overheated. The contact stated that several unknown warning lights were illuminated. The contact pulled over to the side of the road and the check engine warning light illuminated. The vehicle was towed to an independent mechanic where it was diagnosed with an unknown pump failure. The vehicle was not repaired. The contact was advised to take the vehicle to the dealer. The contact stated that after the first failure, the vehicle was taken to the dealer; however, no cause for the failure was found. The contact stated that the failure persisted. The contact stated that while depressing the accelerator pedal, the engine made revving sounds with ticking sounds coming from the vehicle. The manufacturer was made aware of the failure and filed a claim and the contact was referred to the federal safety agency Hotline. The failure mileage was approximately 65,000.

Filed Jan 10, 2025 · Engine · OH

Experiencing repeated coolant leaks. Heating/coolant was repaired last winter. Failed again this winter. Car keeps needing additional coolant added. Will be taking it in on Monday to find out which parts failed this time.

Filed Jan 7, 2025 · Engine · MI

I bought the 2014 Fusion in 2019 used. It had roughly 60 some thousand miles. I had to replace the motor at 94 thousand miles. Now at 131 thousand miles, I am faced with the same issue and need to replace the motor again after only 37 thousand miles. From what the dealer said (Copper Country Ford in Houghton Michigan) both issues have been coolant leaking into the cylinders and killing the motor. The first motor was around $4500.00 and now it is roughly the same $4500.00. So $9000.00 in 4 years!!!!! I called Fo Mo Co and they will do nothing to help. They say there is no recall and or order from the federal safety agency about this issue. Nor do they have any other programs to help resolve this issue or help pay for the repair. First Motor Replaced August 2020 at 94,000 Second Motor Died December 2024 at 131,000

Filed Dec 20, 2024 · Engine · 47,000 miles · MO

The contact owns a 2014 Ford Fusion. The contact stated that while parked, it was discovered that the vehicle was slowly losing coolant. The failure became a reoccurring failure. The vehicle was taken to a local dealer however, a diagnostic test was pending. The vehicle was not repaired. The manufacturer was notified of the failure and referred to the federal safety agency Hotline for assistance. The contact referenced an unknown manufacturer’s recall that was related to the failure; however, the manufacturer confirmed that the VIN was not associated. The approximate failure mileage was 47,000.

Filed Oct 12, 2024 · Electrical, Engine · MS

I've had my Ford Fusion SE ecoboost 1.5, 2014 in for service on 2 separate occasions a day apart for the same reoccurring problems. The first service there was the actions done related to recalls which are consistent with 20S15 A-C and recall 23E03 B. The reasons for my Ford Fusion 1.5 to have been brought to the Premier Ford, Waveland, Ms was as follows: The temperature overheat lamp light was jared, there was 3 leaks from the overheat, there was a Shutter and sounds that came from the engine, (LIMP*)and there was no fuel power through acceleration. There had been moisture located on exhaust before brakedown without having been driven for approximately 10hrs before brakedown. 2ed service was as follows: temperature overheat lamp light jared, no power through fuel to accelerate, and issues starting. LIMP* I had not on this brakedown paid attention to if my Fusion needed water, the engines performance in regards to shakes or sounds nor did I look to notice nor did I look for leaks. I called directly to Premier Ford, Waveland and had my Ford towed in. The service was as follows: 1) 3U2Z*14S411*HYB WPT988 WIRE ASY 2) DS7Z*8501*E PW556 PUMPASP-WATER 3) BE8Z*8507*A GASKET-WATER PUMP 4)VC*13*G 3801132 ANTI-FREEZE 5) 6 BM5Z*6K2543*S437 SCREW 6) BM5Z*6K254*A TENSIONER - TIMING BELT With the parts 261.44 Labor 1748.99 misc charges 50.00 for a total of after taxes 2204.66 I picked up my Ford Fusion on October 4, 2024 and on October 9, 2024 I went beck to the Premier Ford and spoke with the service department because I had to stop and let my Fusion cool every 20 to 30 minutes, I stated that there was some loss of water and it was overheating, the power train light warning notify me of an issue, and that my Fusion would not go over 80miles per hr. The service department associate seemed frustrated with me and argued the fact that it had ran hot and said that the reason for the speed issue was that the lamp was Identifying the keylock complete on pdf

Filed Sep 29, 2024 · Engine, Fuel system · MS

On [XXX] ford premier out of waveland evaluated my car after I had to have it towed in due to overheating. The high temperature warning notification was lock and wouldn't change to normal after it cooled. I was not fully aware of my car overheating due to no warning other the the temperature overheat warning. A couple of days prior without driving it for 10hrs I noticed a moist to the exhaust pipe. When it broke down the engine had a misfire, a shake, and had not power to the engine to accelerate. There was 3 different puddles of fluids underneath the car. When I had spoke to the service department on this breakdown I made them aware of everything with one of the Mechanics witnessing the shake within the engine. There was a confusion on my part due to the sticker showing a 1.5l and my Insurance showing through carfax a 2.5l with also Descripting a 1.5l that showed for my car to be compatible to a 2.0l, 1.6l Installation of coolant system, that of which lead me to request recalls through Vin# on [XXX] through Verified and it was shown to be compatible for recall. Premier Ford service department Assured me that nothing was wrong with the coolant system that the power train control module reprogramming took care of the breakdown. He assured me when I picked up my car That nothing was wrong with my car. Except for me needing to go, change the brakes so that he could change the brake hoses that are part of the recall associated with the brakes. This was on [XXX]. On [XXX] I broke down again with the same issue with this time before the breakdown there was a stall when I started my car And when they had my car on [XXX] I asked them the check the Fuel Injections and he stated there was nothing wrong with the fuel injections. My car has shown every sign that shows through the coolant system of a fire hazard. I am requesting that the Department to assign the safety recall 17s09 to my vin# [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Filed Sep 5, 2024 · Engine · AL

My 2014 ford fusion titanium 2.0 ecoboost engine has Coolant leaks causing engine overheating, missfire on cylender 4, car keeps shuddering and stalling while driving. Contacted ford about this issiue they refused to fix it even though there is a mass recall on the same Caras mie for the same issiues

Filed Aug 25, 2024 · Engine · KY

Vehicle showing signs of coolant leak with no visible of signs of coolant on ground. Check engine light came on and running rough on startup and high speeds. White smoke and sputtering under load. Took to local mechanic and had signs of coolant in #3 cylinder. Replaced all spark plugs and ignition coils along with thermostat and pressure tested. Vehicle still throwing codes and having heavy misfires in #3 cylinder with coolant loss. Stated will need a new long block. Vin number not covered by recall. But Def needs to be.