2018 Ford Edge: stuck in gear or won't shift

Filed Apr 25, 2025 · Engine · 96,000 miles · WA

The contact owns a 2018 Ford Edge. The contact stated while driving 5 MPH in a parking lot, the check engine warning light illuminated. The contact stated that the engine went into LIMP Mode. The contact pulled over and turned off the vehicle. The contact restarted the vehicle after several minutes. The vehicle was taken to Pep Boys, where it was diagnosed that the spark plugs, and ignition coils had failed and needed to be replaced. The vehicle was repaired, but the failure persisted. The vehicle was taken back to Pep Boys and was diagnosed with coolant intrusion into the cylinder, causing a misfire in cylinder #3 and engine failure. The vehicle was not repaired. Upon further investigation, the contact related the failure to Ford Campaign Number: 22-229. The manufacturer was made aware of the failure and referred the contact to the federal safety agency Hotline. The failure mileage was approximately 96,000.

Filed Jan 28, 2025 · Engine · NM

Car went into limp mode and over temp light came on. Coolant reservoir empty. Research led to TSB 19-2346. Prior to this CEL was coming on and off and throwing code P0301 errors. Replaced plugs and coil packs at the suggestion of the dealer but made no difference. Started out with rough idle but smoothed out after about 30 seconds. Dealer diagnosed issue and quoted $6,900.00 plus tax to install new long block. Ford finally agreed to cover part of the repair costs but still left me with a $3,000 bill. Car is now repaired but I'm hoping to recoup some of my expenses now.

Filed Dec 12, 2024 · Engine · NM

Car went into limp mode and over temp light came on. Coolant reservoir empty. Research led to TSB 19-2346. Prior to this CEL was coming on and off and throwing code P0301 errors. Replaced plugs and coil packs at the suggestion of the dealer but made no different. Started out with rough idle but smoothed out after about 30 seconds. Dealer diagnosed issue and quoted $6,900.00 plus tax to install new long block. Safety concern is the engine started to overheat. Fortuantely we stopped before anything serious happened, but found several reports online of this causing engine fire and destroying the car.

Filed Dec 11, 2024 · Engine · 52,000 miles · GA

The contact owns a 2018 Ford Edge. The contact stated while accelerating from a complete stop, the vehicle hesitated while responding. The contact stated that the failure progressively worsened. The contact also noticed that the vehicle was experiencing excessive coolant consumption. The check engine warning light was illuminated. The contact stated that upon starting the vehicle, the vehicle experienced a rough start and was shuddering temporarily. Additionally, the contact stated while attempting to drive from a complete stop onto the road, the message "Caution - Coolant Temperature Overheat" was displayed, and the check engine warning light was illuminated. The vehicle went into LIMP Mode. The contact stated that upon depressing the accelerator pedal again the vehicle was sputtering and was significantly sluggish. The contact stated that the vehicle was able to accelerate to 30 MPH after driving for 1 mile. The vehicle was driven to the residence. The vehicle was towed to the dealer, where it was diagnosed with coolant intrusion in the cylinders. The dealer determined that the engine needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and offered to partially cover the repair. The failure mileage was approximately 52,000.

Filed Oct 4, 2022 · Engine · 78,000 miles · NM

The contact owns a 2014 Ford Edge. The contact stated that while driving on an incline at an undisclosed speed, the vehicle went into Limp Mode and stalled. The coolant temperature warning light and the engine safe mode light illuminated. The contact was able to restart the vehicle and the vehicle was taken to an independent mechanic where it was confirmed that the spark plugs and injectors needed to be replaced. The vehicle was repaired; however, the contact stated that he noticed light smoke coming from the exhaust and smelled a burning odor. The vehicle was taken back to the dealer where it was diagnosed that the lower engine block needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that a portion of the cost for the repair would be covered. The failure mileage was approximately 78,000.