2017 Ford Explorer: harsh or hard shifting

Filed Jun 4, 2026 · Suspension · NY

I had the rear toe links replaced under recall 21s32 on April 1, 2026. Within a month I started hearing a clunking noise from the back drivers side wheel whenever I hit a bump. My local mechanic looked at the Explorer and said the problem is the knuckle bushing. I contacted the Ford service department and asked them to fix it under customer satisfaction program 22N01. They told me I wasn’t eligible but for $185 they could do a diagnostic test and I’d be responsible for the full cost of any needed repairs.

Filed Apr 10, 2026 · NC

The rear toe link arm is not adjustable, so I can't get it aligned. It has caused a clunking noise when I turn and everytime I align my front end, it does not last.

Filed Mar 24, 2026 · Suspension · 138,871 miles · MI · crash · 1 injury

The contact owns a 2017 Ford Explorer. The contact stated that after the completion of the federal safety agency Campaign Number:Â 20V675000(Suspension), the vehicle started experiencing suspension failures. The contact stated that while driving at various speeds, the vehicle vibrated and made an abnormal clunking sound. Additionally, the contact stated that while driving 30 MPH, the vehicle felt like the front end suspension was fighting with the rear end suspension, causing the contact to lose control of the vehicle, and the vehicle crashed into a pole. The pole was damaged and bent. The vehicle sustained front-end damage. No police report was filed. The contact sustained seat belt burn and bruising on the right shoulder by the collar bone. The vehicle was driven to Sweets Auto Repair, where suspension repairs were performed. The contact stated that since 2023, the front and rear wheel hub assembly, the rear driver's side upper control arm, the front driver CV axle, the front stabilizer, and the front driver lower control arm and ball joint assembly had been replaced. Additionally, the sway bar link was replaced three times, all four tires were replaced due to premature wear on one occasion, and the front tires were replaced at 4,000 miles due to premature wear on another occasion. The front-end alignment was performed; however, the failure persisted. The vehicle was taken to another certified independent mechanic, where it was diagnosed that the front passenger's side struts were loose and nearly detached, the front driver's side struts were finger tight, the front and rear sway bar links were internally worn out, and all four tires were prematurely worn out and needed to be replaced. The vehicle was not yet repaired. The manufacturer was notified of the failure on several occasions. The failure mileage was approximately 138,871.

Filed Jul 28, 2025 · Engine, Transmission · 52,590 miles · CA

The contact owns a 2017 Ford Explorer. The contact stated that while starting the vehicle, there was an abnormal sound coming from the engine. In addition, while driving at undisclosed speeds, there was an abnormal sound coming from the vehicle. The check engine warning light was illuminated. The contact stated that on a separate occasion, while driving 40 MPH, the vehicle failed to accelerate as intended while depressing the accelerator pedal, and the vehicle jerked before slamming into gear. The check engine warning light was continuously illuminated. Additionally, the vehicle was leaking oil onto the ground and the engine was consuming an excessive amount of engine oil. The vehicle was taken to an independent mechanic who diagnosed the vehicle with coolant intrusion into a cylinder, which caused the engine failure. The spark plugs were replaced. The mechanic also informed the contact that the transmission had failed. The contact stated that the failure persisted. The manufacturer was made aware of the failure and referred contact to the federal safety agency Hotline to report the failure. The failure mileage was 52,590.

Filed Apr 4, 2025 · Engine, Transmission · 145,000 miles · MI

The contact owns a 2017 Ford Explorer. The contact stated while driving at various speeds, the vehicle made an abnormal clunking sound, went into LIMP Mode, and failed to exceed 25 MPH. The check engine warning light was illuminated. The contact shifted to reverse(R), but the vehicle failed to respond. The contact called the independent mechanic whom the vehicle was purchased from, but no assistance was provided. The vehicle was taken to a local dealer, where it was diagnosed with catastrophic transmission damage. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. There was no warranty coverage on the vehicle for the failure. The manufacturer was contacted and referred the contact to the federal safety agency Hotline for assistance. The failure mileage was approximately 145,000.

Filed Feb 27, 2025 · Acceleration · KY

The car has a hard time with acceleration and I hear clunking noises

Filed Oct 12, 2023 · Engine, Transmission · TN

While driving cross country, driver began to experience lag in acceleration and delayed shifting. In some cases, noted transmission was not down shifting. At destination, the check engine light came on and we took the vehicle into a Ford dealership for repair. It should be noted that there was a low coolant light just prior to the trip and we filled up approximately a quart to bring it back to serviceable limits. The dealer called after several hours to explain the car would need a new 2.3L EcoBoost engine and new Automatic transmission. The engine had evidence of coolant in the engine/oil. The transmission was diagnosed to have a failure of an internal component. The vehicle was been regularly serviced for the 79000 miles with no previous warning lights. We currently have the vehicle in our garage trying to decide if it's worth fixing for $25000 quoted by the dealer.

Filed Jan 1, 2023 · Steering, Suspension · NJ

In March of 2022, this vehicle was repaired for a rear suspension toe link recall. On Christmas evening, December 25, 2022, the toe link failed. The car fishtailed briefly before veering uncontrollably off the road. I had no warnings that this was going to happen aside from a slight "clunk" in the rear of the car a second beforehand. Fortunately oncoming traffic immediately stopped and avoided me and I was able (with much difficulty) to move the car to safety. I was only going about 35 mph; I cannot imagine how much carnage I would have created had I been on the highway I was headed to just 3 miles away. The car was flat-bedded to the Ford dealership that has always repaired the car the very next morning, December 26. While waiting for the wrecker, I walked the area where I heard a "clunk" just before the car's steering became inoperable and found a bolt which I brought with me to the dealership. In conversations on December 27, 28 and 29, the Ford service manager stated to me that he and the shop foreman were at a loss as to why the rear suspension toe link failed, but in examining the bolts, they believe they were machined/bored just a little too small allowing it the ability to unscrew itself from the toe link assembly and fall off the car. While the car was at the dealership, I reached out to Ford Motor Company's customer escalation team with the issue. My concern was not just for my own safety, but there are 600,000 other Ford Explorers on the road that might experience the same failure. On Friday, one of the team's members called me back to say that her investigation revealed that the bolt simply unscrewed itself. When I asked "well don't you think this is a huge recall issue?" she stated that investigation/issuing safety recalls are not the job of Ford. When I asked if the bolt unscrewing itself seemed plausible, she responded "I don't know." I have not yet picked up the car though the dealer replaced both toe link assemblies. I am GRAVELY concerned.

Filed Dec 26, 2022 · Transmission · ME

On 11/21/22, my car ‘lost’ it’s transmission at 72,704 miles. This is when a wrench light came on the dashboard, and the car went into limp mode-putting myself and my 2 children at risk while driving. I was luckily able to pull off the road. When I restarted the car, the light went off and allowed me to slowly drive back to my house. We had it towed to a Ford Dealership for further investigation. Prior to this incident, the car had been having intermittent issues with shifting gears on hills, and an occasionally clunking noise that paired with it. We had taken it to the dealership and asked them to investigate. They told us there were no issues, that the transmission was fine, which meant no codes. We had just had some powertrain issues resolved, due to other lights associated with the terrain management system. The issues continued, intermittently, but we were unable to get into another appointment prior to its failure. Once in, we were informed that it was ‘rare’ and that while they hadn’t fully investigated the issue the prior time-there had been no computer codes to indicate this would happen. So, now we have no car and an $8200 bill to fix it, as quoted by our Ford Dealership

Filed Jun 17, 2022 · Suspension · OK

We are experiencing a clunk in the rear along with some sway at times when driving. We have had a mechanic verify that is a bushing issue that has been recalled (21S32) on this vehicle, but ours was not included because it was determined to be outside of the region of the recall. Ford will not honor the recall.

Filed Jul 29, 2021 · Wheels · CA

While driving on the freeway, I heard a clunking noise from the rear of my vehicle and immediately started to fishtail violently back and forth across all 3 lanes of the highway narrowly avoiding crashing into other cars on the highway while avoiding spinning or flipping the vehicle. I was able to gain control of the vehicle while it whipsawed back and forth with all four tires screeching and smoking slowing down to navigate to the shoulder out of harms way. It was one of if not the most frightening experiences I ever had as a motor vehicle operator. On inspection, I observed the rear left wheel was loosely connected to the drive train and severly out of alignment by ~30% which was what caused the vehicle to begin to fishtail and whipsaw so violently at freeway speed which at the time of mechanical failure was approximately 70 miles per hour. The road was clear, dry and void of any debris in the road.

Filed Oct 17, 2020 · Brakes, Engine · 29,000 miles · MN

When backing up and the wheel is turned there's a hesitation then what feels like I hit something. (a clunk w/o the noise ) then when break peddle is pressed the car shimmies bad . I also smell antifreeze coming from the heater vents .brought it back to dealership for them to fix it since it was just purchased there .. They had it for 5 days .. Nothing got fixed. They turned front rotors and topped off fluids. I do believe that I have a bad rear tow bearing or a u-joint. Breaks not sure but the car is worse than before. Still smell antifreeze and there's a dark film on the windshield which indicates a bad heater core. I've brought this to the attention of the dealership bit they won't return my calls or emails or texts. I believe I was sold a lemon. There's an oxidation on the engine and a black stain on bottom of engine. Also the exhaust manifolds have been replaced. This is a 2017 and shouldn't have this many issues .