2015 Jeep Grand Cherokee: fire, smoke or burning smell

Filed Oct 2, 2026 · Engine · 150,000 miles · IN · fire

The contact owned a 2015 Jeep Grand Cherokee. The contact stated that while her son was driving approximately 40-45 MPH, the electronic control warning light illuminated before the failure. The contact pulled over and turned off the vehicle; however, the vehicle independently restarted. The contact exited the vehicle shortly afterwards, and the vehicle suddenly caught on fire. The fire department extinguished the fire. The contact associated the failure with the federal safety agency Complaint Number: 20V699000 (Engine and Engine Cooling). The vehicle was towed to a tow lot. The manufacturer was contacted by email and phone and opened a claim. The claim was declined. The investigator had taken photos. The contact was informed that the mileage had been exceeded. The failure mileage was approximately 150,000.

Filed May 19, 2026 · Engine, Fuel system · IL · fire

vehicle had a strong odor of gasoline then started spuddering and then caught fire while driving.

Filed Aug 26, 2024 · Engine · 120,000 miles · TX

The contact owns a 2015 Jeep Grand Cherokee. The contact stated while the vehicle was idling at a stop light, there was a loud popping sound coming from the engine compartment. The contact stated that while accelerating forward there was steam and smoke coming from under the hood with the engine temperature gauge indicating that the engine was hot before the vehicle lost motive power and stalled. The vehicle was later towed to the residence. The cause of the failure was not yet determined. The manufacturer was notified of the failure, but no assistance was offered. The local dealer was not yet contacted. The failure mileage was 120,000.

Filed Mar 9, 2024 · Body, Electrical · WI

When raining the water will leak throug the sunroof or headliner not sure where it comes through but it comes from 2 places one hitting the arm rest / middle console which caused the terrain selection to go out and im worried it will cause the screen or something else to go out and catch on fire as I read it is common with these problems , when I purchased the vehicle as well they said it was just a frozen trunk gate spring but once I looked up the problem happening it is said to cause the gate to go out

Filed Sep 3, 2023 · Engine · LA

The oil cooler located on top of the engine intake failed and began leaking oil. The part of the oil cooler that failed was made out of plastic. The top of the engine gets very hot which likely caused the plastic to become brittle and fail. Oil began leaking all over the motor and onto the exhaust pipes. I could smell burning oil and worried it could cause a fire once I realized what was happening. The repair shop said that they fix so many of these and they are not even a dealer, nor could they understand how a recall has not been issued on this item. The component was not inspected by anyone other than the mechanics at the repair shop. The replacement was an aftermarket made out of aluminum and not plastic like the oil cooler that failed. There were no warning lamps indicating there was a problem. When I saw the oil under my vehicle and the smell of burnt oil on the exhaust pipes I brought the vehicle to the repair shop.

Filed Aug 12, 2023 · Electrical, Fuel system · WA

I had a warning code of service electronic throttle. It then started to regenerate and we took it to Lithia Jeep to fix EGR recall. They needed to replace engine intake because it caught fire. Several months later the car broke down while driving, sputtering, knocking, squealing. Upon inspection, metal flakes found in oil. Suspected HPFP sucked into engine causing havoc. The HPFP is an open recall but no available replacement parts. I'm currently out of a vehicle. I've contacted Jeep but haven't heard a reply

Filed Aug 4, 2023 · Electrical · CA · fire

USB 12V connector caught fire and melted the panel while car was off Yes it is available for inspection upon request If it would have happened while driving it would’ve put all passengers at risk It has not been confirmed by a dealer It hasn’t been inspected by mfg. insurance or police. There were no warning lamps, symptoms or msg. prior to the failure this happened 7/31/2023 I was unloading my groceries from the back when I came back out to get more bags, I noticed that the cabin was full of smoke. I’m trying to get an estimate to replace it so I can file a claim with my insurance company.

Filed Jun 16, 2023 · Transmission · NC

I’ve recently noticed when leaving my driveway my 2015 jeep grand Cherokee shifts hard / feels as if the transmission is slipping. Today out of now where my vehicle starts slowing down and the rpm is getting higher . I luckily was able to get to the side of the highway to pull over with 3 children in the car . I cut the vehicle off opened and closed the door cranked it and it drove as normal until I was a couple of miles away from home when this happened again . I could not go over 40 mph and the vehicle wasn’t shifting it just sounded like it was reving up . I’ve also been smelling a burning smell inside of the vehicle that smelled like burnt rubber / burning wires. The smell is worse when cutting on the seat warmers . When putting the vehicle in park it sometimes takes a few seconds before the vehicle realizes it’s in park . My headlights at night also appear to look like they are smoking or has a certain smell to them when you get up close

Filed May 11, 2023 · Engine, Transmission · FL

Vehicle purchased 2/9/23 First claim is filed at tire kingdom 2/14/23 ( tires needed balancing , lower oil pan gasket , belt tensioner mentioned the engine shaking and was told they aren’t sure ) Tire kingdom ; 2/16/23 ( engine mounts changed ) Tire kingdom ; 2/20/23 engine diagnostics ( tire kingdom found no failure no check engine light ) Tirekingdom; 2/23/23 ( spark plugs , harmonic balancer ) Dealership 2/27/23 cylinder head replacements Dealership ; 3/14/23 engine mounts , alignment tire balance ( claim denied ) thermostat denied as no failure Tirekingdom ; 3/15/23 referred back to dealership for engine issue again . Dealership ; dropped off on 3/20/23 reported complete engine failure . Inspectors report 4/10/23 - inspection report confirmed engine failure . 4/22/23 received vehicle back 4/22/23 contacted silverrock and noted burning smell , poor acceleration, whining noises etc 4/23/23 check engine light comes on . 4/25/23 takes vehicle back to service center vehicle has an evap code . 5/1 contacted dealership to check on status of the vehicle , dealership has noted transmission failure , leaking oil pan . The engine that was used ( the dealership informed carvana / silverrock at the time of receipt is defective ) has indeed been categorized as defective .

Filed Dec 20, 2022 · Acceleration, Electrical · NC · fire

Cruise Control, O2 SENSOR, Fuel/Propulsion System , BATTERY, If your check engine light is not on when you take it to the service department they say its hard to detect serves needs. Come back when it comes on again. Trouble while driving when using cruise congtrol it excellerate15miles beyond speed set very scary while driving next 30 minutes smell smoke next flames and smoke coming from underneath hood, open door flames and smoke can into jeep. Causing me to hit my head tryng to watch the fire and get out the truck and getting the two kids out the back the we ran then the exploded. The 911 button inside did not work! Now we can't sleep!

Filed Jan 7, 2022 · Engine · NE

The oil cooler/ oil filter housing cracked. My 2015 Jeep only has 49,000 miles on it. This is a huge safety problem. The oil leaked all over the transmission case and the exhaust. It was smoking really bad, this is a fire hazard!!! I found out that there has been many complaints on this issue and should be recalled for safety. The dealership told me to have it towed in because you can not drive it because it can catch on fire. Not good, someone can really get hurt!!! Recall this product.

Filed Dec 15, 2021 · Electrical, Seats · WI · 1 injury

2015 Jeep Grand Cherokee drivers side heated seat burned a nickel size hole through the seat, burned a hole through my girlfriends sweatshirt and burned her skin. Thank god she was able to maintain her composure and pull over to a parking lot and get out. What if she had jerked the wheel (as it startled her) and caused a crash? What if she was on the highway?? What if the vehicle started on fire?? The vehicle is currently at the dealership and being inspected. There were no warning lamps or other symptoms.